Volkswagen Golf 2015 Repair Manual page 79

– Install the two bolts into the flange and counterhold the flange
shaft with the pry lever to remove the right flange shaft bolt
-arrow-.
– Remove the flange shaft.
Note
Check the seal for leaks before removing the flange shaft. If
♦
the seal has leaks, replace it when installing. Refer to
⇒ 1.3 Right Seal, Replacing , page 185
♦ If transmission fluid leaks out while removing the flange shaft,
drain and refill transmission fluid on the installed transmission
and installed flange shaft. Refer to
⇒ 8 Transmission Fluid , page 125
– Attach the spindle -A- from the Seal Installer - Driver Set -
3066- into the threaded piece on the differential.
– Insert the Seal Installer - One-Piece Seal - T10148- and se‐
cure with the nut -B-.
Note
The Seal Installer - One-Piece Seal - T10148- protects the
♦
right seal and the transmission from dirt.
A M8 x 105 mm bolt may be installed by hand into the differ‐
♦
ential threaded piece instead of a spindle -A-.
Caution
There is a danger of causing damage to the decoupling ele‐
ment.
♦ Pay attention. Refer to ⇒ Rep. Gr. 26 ; Emissions Control;
Overview - Emissions Control .
– Remove the bracket bolts -arrows- for the exhaust system on
the subframe.
Manual Transmission - Edition 12.2014
.
.
Golf 2015 ➤ , Golf Variant 2015 ➤
2. Transmission, Removing and Installing
73