Related Manuals for Bajaj Pulsar RS200 BS VI
Summary of Contents for Bajaj Pulsar RS200 BS VI
- Page 5 Parameter Pulsar RS 200 BS VI Pulsar NS 200 BS VI Engine 4 Stroke, Single Cylinder 4 Stroke, Single Cylinder Bore x Stroke 72 mm x 49 mm 72 mm x 49 mm Engine Displacement 199.4 cc 199.4 cc Compression Ratio 0.5 : 1 11+/- 0.5 : 1 Idling Speed...
- Page 6 Parameter Pulsar RS 200 BS VI Pulsar NS 200 BS VI Fuel Tank Capacity Full 13 Liters (No Reserve) 12 Liters (No Reserve) Dimensions Length 1999 mm 2017 mm Width 765 mm 804 mm Height 1114 mm 1075 mm Wheel base 1345 mm 1363 mm Ground Clearance...
- Page 7 LED-Yellow LED-Yellow Coolant Temp. Indicator LED-Red LED-Red Low Oil Pr. Indicator LED-Red LED- Red Low Battery Indicator LED-Red LED-Red Bajaj Logo LED-Blue LED-Blue REV Indicator LED-Orange LED-Orange Service Reminder Side Stand Indicator ABS Indicator LED-Yellow LED-Yellow Rear No. Plate Lamp...
- Page 9 BS VI Reex Reector Belly Pan...
- Page 10 BS VI Reex Reector Belly Pan...
- Page 12 • There is no fuel cock. • Always maintain minimum 3 Liter Petrol in fuel tank. • Do not use adulterated fuel or fuel additives as it will result in rusting & clogging of Injector, Fuel pump module & catalytic Convertor.
- Page 15 hould be driven at reduced speeds When you apply Front brake/Rear brake by pressing Front brake lever/Rear brake pezdal under conditions which may lock the wheels, you feel a corresponding sensation (pulsation) in Front brake lever/Rear brake pedal. (as applicable to model) This is normal and it means ABS is active.
- Page 23 • Center stand return to it’s fully up position. (Applicable for Pulsar NS 200) • Function of all lights and horn.
- Page 24 • Ensure minimum 3 liters petrol is available in fuel tank. please bring the vehicle to bajaj authorised workshop for repairs.
- Page 26 • Do Not rev engine in standstill condition. • •...
- Page 27 Always maintain minimum 3 Liter Petrol in fuel tank. Always maintain brake uid level Brake Fluid above minimum mark.Ensure no leakage of brake uid in brake system. Always maintain coolant level coolant between minimum & maximum mark. Ensure no leakage of coolant in cooling system.
- Page 28 • It is suggested to customer to take appropriate Safe Riding Tips care in area of heavy monsoon or high rainfall • Always wear Helmet while driving or area. The appropriate surface preventive coat to riding. Your helmet should conform avoid rusting / poor surface finish on account of to appropriate Indian standards.
- Page 29 Recommended Engine Oil: Always insist on Bajaj DTS-i Engine Oil for optimum engine performance and warranty benefits. It is a specially formulated oil for vehicles with DTS-i engines. Recommended Engine oil Model Bajaj DTS-i 20W50 BS6 Compliant SAE 20W50 JASO ‘MA2’ API SN...
- Page 30 • Tyre warranty is settled by tyre manufacturer. • Decision is taken based on tyre wear and running of vehicle. • BAL settles tyre warranty for only imported tyres.
- Page 37 Service Coupon Please follow following procedure : - • Please provide your mobile number to Dealer at the time of buying of new Bajaj Vehicle. In case of change in mobile number, please update to • Dealer / ASD. •...
- Page 38 Servicing with water wash Top-up,R Engine oil (Bajaj DTSI 10000 oil) Top-up Top-up Top-up Engine oil Filter Oil strainer Air cleaner element** & air filter cover ‘O’ ring. Drain tube cleaning. in-line fuel filter Inline fuel filter nylon hoses with quick connector...
- Page 39 Recommended frequency - Service interval & Kms 10th 11th 12th 13th 14th 15th 16th Remarks 39500 49500 69500 74500 34500 44500 54500 59500 64500 35000 40000 45000 50000 55000 60000 65000 70000 75000 Ensure to prevent water entry in Petrol tank, Silencer & electrical ...
- Page 40 Recommended frequency - Service interval & Kms Servicing Activities / Check (Free) (Free) points 4500 9500 14500 19500 24500 29500 5000 10000 15000 20000 25000 30000 Check Coolant level in expansion tank / Hose clamp adjustment Coolant & Radiator hoses Replacement at every 30000 Kms or 3 year (whichever occurs earlier) Engine foundation silent bushes for cracks Silencer drain hole cleaning...
- Page 41 45000 55000 60000 65000 75000 Coolant top up if required Use BAJAJ Koolex coolant only. Replacement at every 30000 Kms or 3 year (whichever occurs earlier) Replace if required Damaged conduit / PVC sleeves protection by applying C,A,T C,A,T C,A,T...
- Page 42 Recommended frequency - Service interval & Kms Servicing Activities / Check (Free) (Free) points 4500 9500 14500 19500 24500 29500 5000 10000 15000 20000 25000 30000 side stand pivot pin Steering play Steering stem bearing & Cap steering bearing (Plastic)** C,CL,L C,CL,L C,CL,L...
- Page 43 Recommended frequency - Service interval & Kms 10th 11th 12th 13th 14th 15th 16th Remarks 34500 39500 44500 49500 54500 59500 64500 69500 74500 40000 50000 70000 75000 35000 45000 55000 60000 65000 Use recommended AP grease. C,CL,L C,CL,L C,CL,L C,CL,L Replace if required.
- Page 44 Recommended frequency - Service interval & Kms Servicing Activities / Check (Free) (Free) points 4500 9500 14500 19500 24500 29500 5000 10000 15000 20000 25000 30000 General lubrication – Clutch lever Tyre air pressure. Mirror position & joint firmness. All fasteners tightness, few are, Front &...
- Page 45 Recommended frequency - Service interval & Kms 10th 11th 12th 13th 14th 15th 16th Remarks 39500 49500 69500 34500 44500 54500 59500 64500 74500 35000 40000 45000 50000 55000 60000 65000 70000 75000 Use recommended AP grease. Ensure model wise tyre air pressure. Use model wise torque values.
- Page 48 “Pulsar RS 200 BS VI / Pulsar NS 200 BS VI” motorcycle manufactured by us. Bajaj Auto Limited undertake no liability in the matter of consequential loss or damage caused due to the failure of Every possible care and precaution has been taken to the parts.
- Page 49 Dealers & Recommended Authorised Service Dealers. 5. All consumables like Engine oil, Fork oil, Brake Oil, Grease etc. are chargeable to customer. 4. Usage of only recommended engine oil “Bajaj DTS-I 10000 10W50” at specified frequency 6. Any defect arising...
- Page 50 Ta x i a n y o t h e r m e a n s c o m m e r c i a l Auto Limited, if found is the sole judgement of Bajaj transportation. Auto Limited, such...
- Page 53 Notes - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -...
- Page 54 Notes - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -...
- Page 55 Notes - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -...
- Page 56 Notes - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -...
- Page 57 Notes - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -...
- Page 58 Notes - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -...