Table of Contents
Advertisement
Quick Links
Installation
We suggest that our products be
installed by professionals that are
locally licensed by the authority
having jurisdiction in gas piping.
WARNING
•Improper installation, adjustment, alteration, service, or maintenance can cause injury or property
damage. Read the installation, operating, and maintenance instructions thoroughly before installing or
servicing this equipment.
WARNING
•Do not store or use gasoline or other flammable vapors and liquids in vicinity of this or any other
appliance.
•An LP-cylinder not connected for use shall not be stored in the vicinity of this or any other appliance.
DANGER
If you smell gas:
1) Shut off gas to appliance.
2) Extinguish any open flame.
3) If odor continues, keep away from appliance and immediately call gas supplier or fire
department.
INSTALLER: Leave this manual with the appliance.
CONSUMER: Retain this manual for future reference.
Match Lit Fire Pit Insert Manual
Installation & Operation Instructions
WARNING: FOR OUTDOOR USE ONLY
Service
We suggest that our products
be serviced by a professional
certified in the US by the
National Fireplace Institute
(NFI) as NFI Gas Specialists.
Advertisement
Table of Contents
Summary of Contents for NCP Match Lit
- Page 1 Match Lit Fire Pit Insert Manual Installation & Operation Instructions Installation Service We suggest that our products be We suggest that our products installed by professionals that are be serviced by a professional locally licensed by the authority certified in the US by the having jurisdiction in gas piping.
-
Page 2: General Information
Index: 1) General Information 2) Selecting the Location 3) Construction of Enclosure 4) Installation of Fire Pit 5) Media Product Specific Information 6) Parts List 7) Assembly 8) Fire Pit Operation 9) Maintenance 10) Troubleshooting 11) Warranty General Information Please carefully follow the instructions in this manual to prevent personal injury or property loss. Instructions are updated as needed. -
Page 3: Selecting The Location
Selecting the Location WARNING: All fire pits, match lit kits, spark ignition, safety pilot and electronic ignition systems are designed and intended for outdoor use only. WARNING: All fire pits must have a gas shutoff on the outside of the exterior of the fire pit to allow for emergency shut off and maintenance. - Page 4 Installation of Fire Pit Burner Assembly WARNING: We suggest that our products be installed by professionals that are locally licensed by the authority having jurisdiction in gas piping. WARNING: We suggest that our products be serviced annually by a professional certified in the US by the National Fireplace Institute (NFI) as NFI Gas Specialists.
- Page 5 Lava Rock & Glass Application Please follow the instructions below to add the finishing touch to your fire pit. Remember the deeper your lava rock or glass the more risk of reducing if not smothering the flame. Particular attention needs to be on the pilot assembly area. Incorrect media installation will cause the pilot flame to suffocate and turn off pit or delay main burner ignition.
-
Page 6: Parts List
Parts List 1) Burner (1) 2) Pan (1) 3) Key Valve (1) 4) Properly Sized Orifice for Natural Gas or LP (1) 5) Coupler- (2) 6) Close Nipple (1) 7) Flex Line (2) 8) Flare Fittings (4) 9) Elbow (1) 10) Lava Rock (1) 11) Instructions (1) Fire Pit Burner Assembly... - Page 7 10) For key valve assembly sequence is the same for either Natural Gas or LP. Flex Line > Fitting > Valve > Elbow > Gas Supply Flex Line 11) Connect fuel supply line to Key Valve. 12) Perform leak test as described in this manual. Perform leak test on all fittings and back pressure checks for LP with media installed.
-
Page 8: Maintenance
Maintenance Service We suggest that our products be serviced by a professional WARNING: Any guard or protective device removed for servicing must be replaced prior to certified in the US by the operating the fire pit. National Fireplace Institute (NFI) as NFI Gas Specialists. WARNING: Installation and repair should be done by a qualified service person. - Page 9 LP Gas Fossill 30 Fire Pit Installation Instructions Step 1: Level the pad. Level a 48” circular area of gravel or rock on compacted soil with the top of the pad being 1” below grade. Fire Pit enclosure parts list: 19 blocks, 1 Key valve block (block with hole), 8 top caps.