Hyundai HT600 User Manual

Hide thumbs

Table Of Contents

Table of Contents

Quick Links

Download this manual

HT600

User Manual

Table of Contents

Summary of Contents for Hyundai HT600

Page 1 HT600 User Manual...
Page 3 Thanks for choosing Hyundai! Let's get started!
Page 5 WE'VE GOT YOU COVERED! Contact us by phone at 1-877-528-3772, email us at support@hyundaipower.ca, or visit us online at www.hyundaipower.ca if you have any questions SAVE THESE INSTRUCTIONS This user guide contains important instructions for your product, that should be followed during installation and maintenance.
Page 6 Product registration is required for all product support and warranty coverage. Warranty support, operation assistance and product support is provided by Midland Power Inc., a licensed manufacturer of Hyundai Power Equipment. Please contact us directly for any warranty service questions. 1-877-528-3772 support@hyundaipower.ca...
Page 7: Table Of Contents
TABLE OF CONTENTS 1. Safety 2. Learn About Your Light Tower 3. Operation 4. Turn On the FloodLights 5. Turn Off the FloodLights 6. Transportation and storage 7. Winch Maintenance 8. Troubleshooting 9. Limited Warranty HT SERIES...
Page 8: Safety
1. SAFETY 1.1 HIGH VOLTAGE DANGER! This unit uses high voltage circuits capable of causing serious injury or death. Only a qualified electrician should troubleshoot or repair electrical problems with this unit. WARNING! Before operating the equipment, read the user guide carefully. Otherwise, personal injuries or equipment damage may result.
Page 9 1.2 MECHANICAL HAZARDS WARNING! Do not operate this equipment unless all safety and protective guards are in place. Operate this equipment on level ground only. Failure to do so could result in serious injury caused by tipping, rolling, sliding, or falling. ...
Page 10: Learn About Your Light Tower
2. LEARN ABOUT YOUR LIGHT TOWER This section will show you how to identify key parts of your light tower. Going over the terminology below will make sure we’re on the same page. 2.1 COMPONENT IDENTIFICATION LED Lamp Mast Winch Steering Brake pedal Circuit Breaker...
Page 11: Operation
3. OPERATION 3.1 WINCHING THE MAST UP AND DOWN Rotate the winch clockwise to raise the mast, rotate it counter-clockwise to lower the mast. The winch is self-locking and will remain at the height it is winched to. The winch is also assisted on the way down so the tower will come down smoothly.
Page 12 3.2 BRAKES To lock the brakes, firmly push down the brake lever with your foot until it is fully de- pressed then pull it towards the back of the tower to lock it into place. To release the brakes, push the brake pedal in and away from the back of the tower until it unlocks and returns to its original position.
Page 13 3.4 STEERING The steering handle controls the direction of the front wheels. Turn the handle left or right to steer the front wheels left or right. HT SERIES...
Page 14: Turn On The Floodlights
4. TURN ON THE FLOODLIGHTS Plug the light tower into an external power source (a generator for example). Flip the circuit breaker to the ON position and check to make sure all lamps come on. Allow a minimum of 2 minutes for the lamps to reach full luminance.
Page 15: Transportation And Storage
6. TRANSPORTATION AND STORAGE TRANSPORTATION Allow the floodlights to cool for at least 20 minutes before transporting. STORAGE Allow the light tower to cool for at least 20 minutes before storing if it has been in use. Clean the light tower before storing in a dry location. 7.
Page 16: Troubleshooting
8. TROUBLESHOOTING Symptom Possible Cause & Correction Floodlights Will Not Turn Lamps are too hot. Allow to cool for 20 minutes before restarting. Faulty lamp connection. Check all lamp connections and wires are connected correctly and tightly. The plug is loose or damaged. ...
Page 17: Limited Warranty
Toll Free: 1-877-528-3772 E-mail: support@hyundaipower.ca Online: www.hyundaipower.ca Hyundai Power Equipment products are distributed by: Midland Power Inc. 376 Magnetic Drive, Toronto, ON M3J 2C4, Canada This product is warranted to be free of defects in material and workmanship for three years from date of purchase.
Page 18 Exclusions Not Covered by this Limited Warranty Normal wear and tear Consumables such as bulbs Damage caused by lack of maintenance as described in the Hyundai User Guides Damage caused by accidents, improper installation or storage;...
Page 19 Warranty Claim Procedure Warranty service must be performed by one of our authorized service dealers. Do not return your product where purchased. If you feel your light tower is malfunctioning due to a defect or misuse, simply contact our customer support center for technical advice, a warranty claim or general information.
Page 20 Customer Service Toll Free: 1-877-528-3772 E-mail: support@hyundaipower.ca Online: www.hyundaipower.ca...
Page 21 Enjoy! Be sure to check www.hyundaipower.ca for updates regarding your light tower. HT SERIES...
Page 22 For Inquiries, Please Contact: Midland Power Inc. 376 Magnetic Drive, Toronto, ON Canada M3J 2C4 1-877-528-3772 support@hyundaipower.ca www.hyundaipower.ca Distributed by Midland Power Inc., Canada Licensed by Hyundai Corporation, Korea...