Table of Contents
Advertisement
Quick Links
E
C
C
LECTRIC
OUNTERTOP
HARBROILER
ELECTRIC COUNTERTOP
CHARBROILERS
TECC 4224 / TECC 4236
Free-Standing, Floor Model
INSTALLATION - OPERATION - MAINTENANCE
MODEL TECC4236
Middleby Philippines Corporation
~
113 Technology Ave., Laguna Technopark Inc., Binan, Laguna, Philippines 4024
Phone (632) 5208170 - Fax (632) 5208191 - www.middleby.com
Toastmaster
P
13
M
AGE
®
ANUAL TECC105-TECC4224-4236
Advertisement
Chapters
Table of Contents
Related Manuals for Toastmaster TECC 4224
Summary of Contents for Toastmaster TECC 4224
- Page 1 LECTRIC OUNTERTOP HARBROILER ELECTRIC COUNTERTOP CHARBROILERS TECC 4224 / TECC 4236 Free-Standing, Floor Model INSTALLATION - OPERATION - MAINTENANCE MODEL TECC4236 Middleby Philippines Corporation 113 Technology Ave., Laguna Technopark Inc., Binan, Laguna, Philippines 4024 Phone (632) 5208170 - Fax (632) 5208191 - www.middleby.com Toastmaster ®...
-
Page 2: Safety Precautions
Be sure this Operator’s Manual and important papers are given to the proper authority to retain for future reference. Toastmaster ® This symbol warns of immediate hazards that will result in serve injury or death. - Page 3 Congratulations! You have purchased one of the finest pieces of commercial cooking equipment on the market. You will find that your new equipment, like all Toastmaster equipment, has been designed and manufactured to meet the toughest standards in the industry. Each piece of toastmaster equipment is carefully engineered and designs are verified through laboratory tests and field installations.
-
Page 4: Installation
Place disconnect switch in ON position, energizing the unit. Set thermostats to 300 F Let a few drops of water fall on each section to assure it’s operating. The unit is now ready for operation. LECTRIC OUNTERTOP HARBROILER Toastmaster ®... -
Page 5: Operation
12" of the grid width. c. Adjacent to each thermostat is an amber signal light indicating when the heating elements are nergized. The signal will glow on the off during operation, indicating the desired temperature is being maintained. Toastmaster ® PERATION... - Page 6 Clean the exterior of the broiler with hot water and soap, rinse with clear water, dry and polish with a soft cloth. Avoid using abrasives to prevent scratching of finish. If abrasives are necessary to remove baked on food particles, rub in the direction of the grain to avoid scratching. LECTRIC OUNTERTOP HARBROILER Toastmaster ®...
-
Page 7: Operation
LECTRIC OUNTERTOP HARBROILER COOKING GUIDE FOR TOASTMASTER CHARBROILERS FOOD Canadian Bacon Hamburger & Cheeseburger Corned Beef Patties Sausage Patties Sausage Links Minute Steaks Club Steaks Ham Steaks Beef Tenderloin Boiled Ham New York Strip Steaks Toastmaster ® CONTROL SETTING TIME IN... -
Page 8: Service
Mark and disconnect wire leads to thermostat. g. Remove two screws holding thermostat to mounting cup. h. Reverse procedure to install new thermostat. Check for shorts before re-energizing unit. ° ° ° F 10 F reading is obtained LECTRIC OUNTERTOP HARBROILER Toastmaster ®... - Page 9 Remove bottom cover of case. e. Check contactor, if necessary, to replace Proceed as follows: 1. Mark and disconnect wire leads to contactor. 2. Remove contactor. 3. Reverse procedure to reinstall new contactor. 4. Check for short before re-energizing unit. Toastmaster ® ERVICE...
-
Page 10: Parts
PARTS LIST TECC4224 / TECC 4236 LECTRIC OUNTERTOP HARBROILER Toastmaster ®... -
Page 11: Parts
TA710E8745 1000719 1000690 1000705 1850152 1000106 1800196 1800197 S1172857 Toastmaster ® QUANTITY TUBULAR HEATER 240V 2700W MEAT RACK C'BRLER ELECT. CONTACTOR 3P 30A 208/240 THERM GRIDDLE 150-450F KNOB TSTAT 300F/700F W IRE SET CB 24 W IRE SET CB 36... - Page 12 LECTRIC OUNTERTOP HARBROILER MODEL TECC 4224 MODEL TECC 4236 Toastmaster ®...
- Page 13 When service is needed, contact a Toastmaster Autho- rized Service Agency, or your dealer. To avoid confusion, always refer to the model number. Serial number, and type of your unit.