Replacement manuals are available upon request at no charge. All specifications are nominal and may change as design improve- ments occur. Greenlee Textron shall not be liable for damages resulting from misapplication or misuse of its products. Slug-Buster and Slug-Splitter are registered trademarks of Greenlee Textron.
• Near junction boxes with energized circuits Failure to observe this warning can result in severe injury or death. Greenlee Textron / Subsidiary of Textron Inc. 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815/397-7070...
Failure to observe this warning can result in severe injury or death. CAPACITY RATING FREQUENT MAXIMUM CAPACITY 1904 with Slug-Splitter punches only 1904 with Slug-Splitter, Slug-Buster, or standard Greenlee punches and dies MILD STEEL STAINLESS STEEL CONDUIT SIZE CONDUIT SIZE MATERIAL THICKNESS...
Stud Selection Table to determine the corresponding draw stud. Install the draw stud as shown. Note: All draw studs for the 1904 have left-hand threads. Greenlee Textron / Subsidiary of Textron Inc. 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815/397-7070...
The spindle must be in the starting position and the stud must be threaded completely into the spindle. Greenlee Textron / Subsidiary of Textron Inc. 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815/397-7070...
43.2 mm 503 2009.2 Pg-36 47.0 mm 500 4061.8 1-1/2" conduit 49.6 mm 503 2011.4 Pg-48 60.0 mm 500 4063.4 2" conduit 61.5 mm Greenlee Textron / Subsidiary of Textron Inc. 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815/397-7070...
(9). free from the race. Should this happen, refer to Assembly of Ball Nut at the end of the Maintenance section. Greenlee Textron / Subsidiary of Textron Inc. 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815/397-7070...
Page 9
Install spindle hub unit, wave washer (4), and retaining ring (3). Be sure to seat the retaining ring completely in the groove. Greenlee Textron / Subsidiary of Textron Inc. 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815/397-7070...
GREASE 10. Place the tube clamp over the tube (taking care to keep the two halves together) and secure with the clamp screws. Greenlee Textron / Subsidiary of Textron Inc. 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815/397-7070...
If any balls are in need of replacement, a complete set should be ordered to ensure proper consistency of size. Lubricate with light machine oil Locking detent Greenlee Textron / Subsidiary of Textron Inc. 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815/397-7070...