1 Safety Precautions 1.1. General Guidelines 1. When servicing, observe the original lead dress. If a short circuit is found, replace all parts which have been overheated or damaged by the short circuit. 2. After servicing, see to it that all the protective devices such as insulation barriers, insulation papers shields are properly installed.
2 Warning 2.1. Prevention of Electrostatic Discharge (ESD) to Electrostatically Sensitive (ES) Devices Some semiconductor (solid state) devices can be damaged easily by static electricity. Such components commonly are called Elec- trostatically Sensitive (ES) Devices. Examples of typical ES devices are integrated circuits and some field-effect transistors and semiconductor [chip] components.
2.2. About lead free solder (PbF) Note: Lead is listed as (Pb) in the periodic table of elements. In the information below, Pb will refer to Lead solder, and PbF will refer to Lead Free Solder. The Lead Free Solder used in our manufacturing process and discussed below is (Sn+Ag+Cu). That is Tin (Sn), Silver (Ag) and Copper (Cu) although other types are available.
3 Service Navigation 3.1. Service Hint Board Name Function Board Name Function Power Supply Data Driver (Upper Right) DC-DC Converter Data Driver (Upper Center) Speaker out, Sound Processor Data Driver (Upper Left) AV Terminal, AV Switch, Ethernet LAN Data Driver (Lower Left) Digital Signal Processor, Micom, HDMI Interface Data Driver (Lower Center) Peaks PRO, GC6...
4 Specifications Power Source AC 220 - 240 V, 50/60 Hz Power Consumption Average use 700 W Standby condition 0.4 W (Without monitor out recording) 20 W (With monitor out recording) Plasma Display panel Aspect Ratio 16:9 Visible screen size 165 cm (diagonal) 1,434 mm (W) ×...
Page 8
Note • Design and Specifications are subject to change without notice. Mass and Dimensions shown are approximate. • This equipment complies with the EMC standards listed below. EN55013, EN61000-3-2, EN61000-3-3, EN55020, EN55022, EN55024.
5 Service Mode 5.1. How to enter into Service Mode While pressing [VOLUME ( - )] button of the main unit, press [0] button of the remote control three times within 2 seconds. 5.1.1. Key command [1] button...Main items Selection in forward direction [2] button...Main items Selection in reverse direction [3] button...Sub items Selection in forward direction [4] button...Sub items Selection in reverse direction...
5.1.2. Contents of adjustment mode • Value is shown as a hexadecimal number. • Preset value differs depending on models. • After entering the adjustment mode, take note of the value in each item before starting adjustment. 5.1.3. How to exit Switch off the power with the [POWER] button on the main unit or the [POWER] button on the remote control.
5.2. Service tool mode 5.2.1. How to access 1. Select [SRV-TOOL] in Service Mode. 2. Press [OK] button on the remote control. 5.2.2. Display of SOS History SOS History (Number of LED blinking) indication. From left side; Last SOS, before Last, three occurrence before, 2nd occurrence after shipment, 1st occurrence after shipment. This indication except 2nd and 1st occurrence after shipment will be cleared by [Self-check indication and forced to factory ship- ment setting].
5.3. Hotel mode 1. Purpose Restrict a function for hotels. item Function Access command to the Hotel mode setup menu Hotel Mode Select hotel mode ON/OFF In order to display the Hotel mode setup menu, please Initial INPUT Select input signal modes. enter the following command (within 2 second).
6 Troubleshooting Guide Use the self-check function to test the unit. 1. Checking the IIC bus lines 2. Power LED Blinking timing 6.1. Check of the IIC bus lines 6.1.1. How to access Self-check indication only: Produce TV reception screen, and while pressing [VOLUME ( - )] button on the main unit, press [OK] button on the remote control for more than 3 seconds.
6.2. Power LED Blinking timing chart 1. Subject Information of LED Flashing timing chart. 2. Contents When an abnormality has occurred the unit, the protection circuit operates and reset to the stand by mode. At this time, the defective block can be identified by the number of blinks of the Power LED on the front panel of the unit.
Page 15
6.3. No Power First check point There are following 2 states of No Power indication by power LED. 1. No lit 2. Red is lit then turns red blinking a few seconds later. (See 6.2.)
7 Disassembly and Assembly Instructions 7.1. Remove the Back cover 6. Remove the screws (×12 1. See Service Hint (Section 3) 7.2. Remove the P-Board Caution: To remove P.C.B. wait 1 minute after power was off for dis- charge from electrolysis capacitors. 1.
7.4. Remove the tuner unit 1. Unlock the cable clampers to free the cable. 2. Disconnect the connectors (A1, A3, A5, A6, A7, A8, A9, A11, A51, A53, H11 and H12). 3. Remove the screws (×4 ) and remove the tuner unit. P-Board backside 7.3.
7.7. Remove the Speaker box assy (L, R) 1. Unlock the cable clampers to free the cable. 2. Disconnect the relay connectors. 3. Remove the screws (×4 ) and remove the Speaker box assy (L, R). 7.6. Remove the HC-Board 1.
7.8. Remove the FFC Shield Metal 7.10. Remove the D-Board remove Core 1. Remove the Tuner unit. (See section 7.4.) 2. Disconnect the connectors (D3, D5 and D25). Holder (A) 3. Disconnect the flexible cables (D20, D31, D32, D33, D34, 1.
7.12. Remove the SU-Board 7.14. Remove the SC-Board 1. Remove the flexible cables (SU1B, SU2B, SU3B, SU4B 1. Remove the SU-Board and SD-Board. (See section 7.12. and SU5B). and 7.13.) 2. Disconnect the flexible cable (SU11-SD11) and discon- 2. Disconnect the connectors (SC2 and SC20). nect bridge connector (SU41-SC41).
7.16. Remove the SS3-Board 7.18. Remove the Vertical Bar (L, R) and the V-Bar fixing metal (A, 1. Unlock the cable clampers to free the cable. 2. Disconnect the connector (SS35) and disconnect the flex- B, C, D) ible cables (SS57 and SS58). 3.
7.21. Remove Cabinet-fixing 3. Remove the screws (×4 ) and remove the Fan. metal (A) (Upper) 1. Remove the screws (×4 each). 2. Remove the Cabinet-fixing metal (A). 7.20. Remove the Fan unit (L) and Fans 1. Disconnect the relay couplers. 2.
7.23. Remove the Support metal (R) 7.25. Remove the Plasma panel sec- , ×1 tion from the Cabinet assy 1. Remove the screws (×3 2. Remove the support metal (R). (glass) 1. Remove the Speaker box assy (L, R). (See section 7.7.) 2.
7.27. Remove the C1-Board 6. Remove the spacers and spacer rings (×6 1. Remove the Fan unit (R). (See section 7.19.) 2. Remove the Cabinet-fixing metal (A) and (B). (See sec- tion 7.21. and 7.26.) 3. Remove the flexible cables holder fastening screws (×10 4.
Page 27
7.29. Remove the C3-Board 7.32. Remove the C5-Board 1. Remove the Fan unit (L). (See section 7.20.) 1. Remove the Tuner unit. (See section 7.4.) 2. Remove the Cabinet-fixing metal (A) and (B). (See sec- 2. Remove the Cabinet-fixing metal (B). (See section 7.30.) tion 7.21.
4. Remove the Speaker (Squawker/L, Squawker/R). 5. Remove the GH-Board. 6. Remove the screws (×2 ) and remove the GS-Board. 7. Remove the screws (×3 8. Disconnect the connector (G51) and remove the G- Board. 7.37. Remove the K-Board and 7.35.
7.39. Replace the plasma panel (fin- 7. Remove the screws (×2 8. Remove the K-Board and disconnect the connector (K1). ished) 1. Place the new plasma panel (finished) on the flat surface of the table (covered by a soft cloth), with the plasma panel surface facing downward.
8 Measurements and Adjustments 8.1. Adjustment Procedure 8.1.1.2. Adjustments Adjust driver section voltages referring the panel data on the 8.1.1. Driver Set-up panel data label. Check or adjust the following voltages with the multimeter. 8.1.1.1. Item / Preparation 1. Input a white signal to plasma video input. Name Test Point Voltage...
8.1.2. Initialization Pulse Adjust 1. Input the White signal to plasma video input. 2. Set the picture controls as follows. Picture menu : Dynamic PNR : OFF Aspect : 16:9 3. Connect Oscilloscope to TPSC1 (SC). Check the voltage (T2) at 100 us period on the down slop. Test point Volume Level...
Page 32
8.1.4. Adjustment Volume Location 8.1.5. Test Point Location...
GC6+1.2V PA35 CIRCUIT DCDC +1.8V(GC6) GC6+1.8V PA36 F+15V +1V(FRC) (LED:11 TIMES) FRC+1V PA37 DCDC DCDC +2.5V(FRC) from P7 FRC+3.3V FRC+2.5V FAN CONTROL +15V(FAN) DCDC +2.6V(FRC) +5V(STB) FRC+2.6V DIGITAL SIGNAL PROCESSOR TH-65PY800P, PZ800B/E TH-65PY800P, PZ800B/E Block (1/7) Diagram Block (1/7) Diagram...
Page 34
DATA DATA DATA DATA DATA DATA DATA DATA DATA DATA DATA DATA DATA POWER SWITCH DRIVER DRIVER DRIVER DRIVER DRIVER DRIVER DRIVER DRIVER DRIVER DRIVER DRIVER DRIVER DRIVER DRIVER DRIVER TH-65PY800P, PZ800B/E TH-65PY800P, PZ800B/E Block (2/7) Diagram Block (2/7) Diagram...
Page 35
F_STBY_15V SOS DET OVER TP853 VOLTAGE FAN STOP (LED:11 TIMES) FAN SOS PB33 PB35 D853 FAN_MAX D855 D861 PB36 MAIN9V D856 PB37 D857 IC850 +15V(FAN) TPFA1 D860 TP850 +15V(FAN) +9/7.2V TH-65PY800P, PZ800B/E TH-65PY800P, PZ800B/E Block (3/7) Diagram Block (3/7) Diagram...
Page 36
AI_SENSOR POWER LED MAIN3.3V_SENSE G_LED_ON DDR3.3V REMOCON SUB3.3V_SENSE D5579 D5580 R_LED_ON STB_LED AI_SENSOR PC2511 G_LED_ON ANALOG ASIC FAN SOS AI SENSOR RMIN R_LED_ON FAN_MAX SUB+5V RM2501 TUNER_SUB_ON STB+3.3V REMOTE ECO_ON TH-65PY800P, PZ800B/E TH-65PY800P, PZ800B/E Block (4/7) Diagram Block (4/7) Diagram...
Page 37
(LED:6TIMES) SOS6_SC1 SOS6_SC1 IIC_DATA2 RESET RESET IC555 (LED:7TIMES) (LED:7TIMES) SOS7_SC2 SOS7_SC2 IIC2 IIC_CLK2 PC502 +15V(P) PANEL SOS PANEL SOS PHOTO +15V(P) COUPLER ERROR DET PANEL STATUS PANEL STATUS +15V(P) COLD TH-65PY800P, PZ800B/E TH-65PY800P, PZ800B/E Block (5/7) Diagram Block (5/7) Diagram...
Page 38
ERROR DET MAIN_STOP +5V(P) INVERTER VSCN TPSOS7 Q16875,79 IC14961-65 SUSTAIN IC16564 D16718 D16717 VSET VSET SUSTAIN CONTROL ERROR DET IC16801 CONTROL OC2A (LED:7TIMES) (LED:7TIMES) CQR4 VSET2,6 SCAN OUT (LOWER) SUSTAIN CONNECTOR TH-65PY800P, PZ850B/E TH-65PY800P, PZ800B/E Block (6/7) Diagram Block (6/7) Diagram...
10 Wiring Connection Diagram 10.1. Caution statement. Caution: Please confirm that all flexible cables are assembled correctly. Also make sure that they are locked in the connectors. Verify by giving the flexible cables a very slight pull. 10.2. Wiring (1)
Page 109
I C 0 0 1 T H E R M A L C 1 4 6 P A D L 0 1 9 C 3 0 6 R 0 2 5 TH-65PY800P, PZ800B/E TH-65PY800P, PZ800B/E GH-BOARD TXNGH1RHTB GH-BOARD TXNGH1RHTB HC-BOARD TXNHC1RHTB HC-BOARD TXNHC1RHTB...
Page 110
P b F C 7 2 7 TNPA4519 1 GS S E E R E V E R S E F O R O R D E RN O . TH-65PY800P, PZ800B/E TH-65PY800P, PZ800B/E G-BOARD TXN/G1RHTB G-BOARD TXN/G1RHTB GL-BOARD TXNGL1RHTB...
Page 111
P C 2 5 1 1 D2532 D2532 C2510 C2510 RM2501 RM2501 CL007 CL007 T N P A 4 5 2 0 D 2 5 3 1 TH-65PY800P, PZ800B/E TH-65PY800P, PZ800B/E TH-65PY800P TH-65PZ800B/E TH-65PY800P TH-65PZ800B/E PA-BOARD TXNPA1RHTB PA-BOARD TXNPA1RHTB S-BOARD TNPA4535AB K-BOARD TXN/K1RHTE K-BOARD TXN/K1RHTB...
Page 115
R 1 3 9 R 1 3 8 R 1 3 7 R 1 7 6 R 1 4 6 D 0 2 5 C 1 3 8 R 1 9 4 TH-65PY800P, PZ800B/E TH-65PY800P, PZ800B/E D-BOARD TZTNP01RATB D-BOARD TZTNP01RATB...
Page 116
C 1 3 7 C 0 6 9 O R D E R N O . F L 0 0 4 R 1 6 8 R 1 2 4 P b F TH-65PY800P, PZ800B/E TH-65PY800P, PZ800B/E D-BOARD TZTNP01RATB D-BOARD TZTNP01RATB...
Page 117
R 1 4 4 CRNO.17 R 1 3 9 C 1 3 6 R 1 4 0 ZA103 ZA104 TNPA4620 1 C1 P b F O R D E R N O . TH-65PY800P, PZ800B/E TH-65PY800P, PZ800B/E C1-BOARD TXNC11RATJ C1-BOARD TXNC11RATJ...
Page 118
R 2 5 1 R 2 5 4 R 2 5 6 I C 2 1 2 R 2 4 9 F L 2 0 2 I C 2 0 8 R 2 3 6 TH-65PY800P, PZ800B/E TH-65PY800P, PZ800B/E C2-BOARD TXNC21RATJ C2-BOARD TXNC21RATJ...
Page 119
C R N O . 1 7 R 3 4 4 ZA306 ZA301 R 3 4 3 R 3 1 5 R 3 4 2 I C 3 0 6 R 3 0 2 C 3 0 1 TH-65PY800P, PZ800B/E TH-65PY800P, PZ800B/E C3-BOARD TXNC31RATJ C3-BOARD TXNC31RATJ...
Page 120
R 4 6 9 R 4 6 8 R 4 7 0 R 4 7 5 R 4 7 1 R 4 7 7 R 4 7 2 CB11 CB12 CB14 CB15 CB13 TH-65PY800P, PZ800B/E TH-65PY800P, PZ800B/E C4-BOARD TXNC41RATJ C4-BOARD TXNC41RATJ...
Page 121
R 5 7 9 R 5 7 3 R 5 7 6 R 5 8 0 R 5 7 1 R 5 7 8 R 5 7 7 R 5 7 2 TH-65PY800P, PZ800B/E TH-65PY800P, PZ800B/E C5-BOARD TXNC51RATJ C5-BOARD TXNC51RATJ...
Page 122
R 6 4 9 R 6 5 4 R 6 5 0 R 6 5 5 R 6 5 1 R 6 5 6 R 6 5 7 R 6 5 2 TH-65PY800P, PZ800B/E TH-65PY800P, PZ800B/E C6-BOARD TXNC61RATJ C6-BOARD TXNC61RATJ...
Page 123
D481 L591 D464 D463 D462 D461 D441 D482 D483 D484 T P 4 T P 1 6 T P 3 2 T P 3 1 T P 5 T P 3 3 TH-65PY800P, PZ800B/E TH-65PY800P, PZ800B/E SC-BOARD TXNSC1RATJ SC-BOARD TXNSC1RATJ...
Page 124
R 4 5 3 L 5 9 1 R 4 5 2 R 4 5 1 R 5 9 1 D 4 5 1 R 5 4 0 R 5 3 3 TH-65PY800P, PZ800B/E TH-65PY800P, PZ800B/E SC-BOARD TXNSC1RATJ SC-BOARD TXNSC1RATJ...
Page 125
A 5 4 A 5 4 A 5 4 A 5 4 D 9 1 4 A 5 4 A 5 4 D 9 0 8 D 9 1 3 D 9 0 4 TH-65PY800P, PZ800B/E TH-65PY800P, PZ800B/E SU-BOARD TXNSU1RATJ SU-BOARD TXNSU1RATJ...
Page 126
C 3 5 8 C 9 7 7 A 5 4 A 5 4 A 5 4 A 5 4 C 3 7 4 A 5 4 A 5 4 C 3 8 2 TH-65PY800P, PZ800B/E TH-65PY800P, PZ800B/E SD-BOARD TXNSD1RATJ SD-BOARD TXNSD1RATJ...
Page 127
D 0 4 0 Q 0 4 3 Q 0 4 4 T P V S U S V R 0 0 0 S S 1 2 S S 1 1 T P 6 TH-65PY800P, PZ800B/E TH-65PY800P, PZ800B/E SS-BOARD TXNSS1RATJ SS-BOARD TXNSS1RATJ...
Page 128
D 0 4 0 C 0 4 2 C 0 4 1 C 0 4 4 C 0 4 3 SS12 R 3 1 5 SSMM2 R 3 1 4 R 3 1 3 TH-65PY800P, PZ800B/E TH-65PY800P, PZ800B/E SS-BOARD TXNSS1RATJ SS-BOARD TXNSS1RATJ...
13.2. Electrical Replacement Parts List 13.2.1. Replacement Parts List Notes...
Page 140
13.2.2. Electrical Replacement Parts List Safety Ref. No. Part No. Part Name & Pcs Remarks Description Safety Ref. No. Part No. Part Name & Pcs Remarks C2108 F2G0J470A019 E 47UF 6.3V Description C2109 F1G1C104A116 C 0.10UF, K, 16V C2110 F1G1C104A116 C 0.10UF, K, 16V K1KA12A00317 12P CONNECTOR C2111 F1H0J2250008 C 2.2UF, K, 16V...
Page 141
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description C2246 F1J1A106A043 C 0.010UF, K, C2621 F1G1A104A012 C 0.01UF, K, 10V C2622 F1G1A104A012 C 0.01UF, K, 10V C2251 F1J1A106A043 C 0.010UF, K, C2623 F1G1A104A012 C 0.01UF, K, 10V...
Page 142
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description C3180 F1J1A106A043 C 0.010UF, K, C3811 F1G1C104A116 C 0.10UF, K, 16V C3812 F1G1C104A116 C 0.10UF, K, 16V C3181 F1J1A106A043 C 0.010UF, K, C3813 F1J0J106A004 C 0.010UF, K,...
Page 143
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description C4271 F1G1C104A116 C 0.10UF, K, 16V C4550 F1G1C104A116 C 0.10UF, K, 16V C4272 F1G1C104A116 C 0.10UF, K, 16V C4551 F1G1C104A116 C 0.10UF, K, 16V C4273...
Page 144
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description C5019 F1G1C104A116 C 0.10UF, K, 16V C5325 F1G1E103A123 C 0.010UF, K, C5020 F1G1C104A116 C 0.10UF, K, 16V C5326 F1G1C104A116 C 0.10UF, K, 16V C5021 F1H0J1050012 C 1UF, K, 16V...
Page 145
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description C5603 F1G1E103A123 C 0.010UF, K, C7725 F1H1H150A971 C 15PF, K, 50V C7729 F1H1H150A971 C 15PF, K, 50V C5604 F1G1C223A116 C 0.022UF, K, C7731 F1H1H150A971 C 15PF, K, 50V...
Page 146
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description C8057 F1G1A104A012 C 0.01UF, K, 10V C8314 F1G1E103A123 C 0.010UF, K, C8058 F1G1A104A012 C 0.01UF, K, 10V C8319 F1G1E103A123 C 0.010UF, K, C8059 F1G1A104A012 C 0.01UF, K, 10V...
Page 147
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description C8640 F1J1A106A043 C 0.010UF, K, C9112 F1G1C104A116 C 0.10UF, K, 16V C9113 F1G1C104A116 C 0.10UF, K, 16V C8641 F1G1A104A012 C 0.01UF, K, 10V C9114 F1G1C104A116 C 0.10UF, K, 16V...
Page 148
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description C9191 F1G1C104A116 C 0.10UF, K, 16V C9320 ECJ1VB1H104K C 0.1UF, K, 50V C9192 F1G1C104A116 C 0.10UF, K, 16V C9321 ECJ1VB1H104K C 0.1UF, K, 50V C9193...
Page 149
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description C9832 F1J1A106A043 C 0.010UF, K, K1KB31BA0064 31P CONNECTOR K1KA20AA0009 20P CONNECTOR C9837 F1J1A106A043 C 0.010UF, K, K1MN35BA0266 35P CONNECTOR K1KA13B00069 13P CONNECTOR C9840 F1G1E103A123 C 0.010UF, K,...
Page 150
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description D4510 EZAEG2A50AX DIODE D9002 K7AAAY000003 PHOTO LINK D4511 EZAEG2A50AX DIODE D9014 MA2J11100L DIODE D4512 EZAEG2A50AX DIODE D9017 MA2J11100L DIODE D4513 B0BC5R6A0275 DIODE...
Page 151
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description IC2013 C0DBGYY00281 IC IC9002 C1ZBZ0003577 IC IC2106 C1AB00002909 IC IC9003 C1ZBZ0003775 IC (HC) IC2107 C0DBFFD00003 IC IC9003 MN103SG4GPF3 IC IC2109 C0DBGHF00001 IC IC9011...
Page 152
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description L2026 J0JCC0000059 CHIP INDUCTOR L5414 G1C100MA0291 INDUCTION COIL L2029 J0JCC0000059 CHIP INDUCTOR L5415 J0JYC0000068 CHIP INDUCTOR L2030 J0JYC0000068 CHIP INDUCTOR L5501 G0A2R7HA0011 CHOKE COIL L2031...
Page 153
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description PA9900 K5H5022A0031 FUSE Q5501 2SD0601ASL TRANSISTOR Q5522 2SB0709ARL TRANSISTOR PC2511 B3JB00000046 IC Q5531 2SD0601ARL TRANSISTOR Q5532 2SD0601ARL TRANSISTOR A-65PZ800B CIRCUIT BOARD A PAVCCZ...
Page 154
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R1109 ERJ2GEJ101 M 100 OHM, R1219 ERJ2GEJ103 M 10KOHM, J,0.063W J,0.063W R1110 ERJ2GEJ473 M 47KOHM, R1220 ERJ2GEJ103 M 10KOHM, J,0.063W J,0.063W R1124...
Page 155
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R2095 ERJ2GEJ473 M 47KOHM, R2606 ERJ2GEJ560X M 56 OHM, J,0.063W J,0.063W R2096 ERJ2GEJ473 M 47KOHM, R2607 EXB2HV560JV RESISTOR ARRAY J,0.063W R2608 EXB2HV560JV...
Page 156
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R2674 EXB28V680JX RESISTOR ARRAY R3142 ERJ2GEJ331 M 330 OHM, J,0.063W R2675 EXB28V680JX RESISTOR ARRAY R3143 ERJ2GEJ331 M 330 OHM, R2676 ERJ2GEJ101 M 100 OHM,...
Page 157
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R3395 ERJ2GEJ221 M 220 OHM, R3481 D0YAR0000007 M 0 OHM 1/4W J,0.063W R3482 D0YAR0000007 M 0 OHM 1/4W R3397 ERJ2GEJ221 M 220 OHM,...
Page 158
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R3829 D0GA2R7JA014 M 2.7OHM, R4506 ERJ2GEJ680 M 68 OHM, J,0.063W J,0.063W R3830 D0GA2R7JA014 M 2.7OHM, R4507 D0YAR0000007 M 0 OHM 1/4W J,0.063W R4526 ERJ2GEJ102X...
Page 159
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R4651 ERJ2GEJ680 M 68 OHM, R4723 ERJ2GEJ220 M 22 OHM, J,0.063W J,0.063W R4652 ERJ2GEJ473 M 47KOHM, R4724 ERJ2GEJ220 M 22 OHM, J,0.063W J,0.063W...
Page 160
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R5026 D1BB2700A055 M 270 OHM, 1/10W R5210 ERJ2GEJ103 M 10KOHM, J,0.063W R5049 ERJ2GEJ470 M 47 OHM, J,0.063W R5216 ERJ2GEJ472 M 4.7KOHM, J,0.063W...
Page 161
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R5556 ERJ2GEJ472 M 4.7KOHM, R5625 D0YAR0000007 M 0 OHM 1/4W J,0.063W R5626 D0YAR0000007 M 0 OHM 1/4W R5557 ERJ2GEJ473 M 47KOHM, R5627...
Page 162
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R7726 D0GB103JA041 M 10K OHM J 1/ R8117 ERJ2GEJ103 M 10KOHM, J,0.063W R7727 D0GB103JA041 M 10K OHM J 1/ R8118 ERJ2RKD330 M 33 OHM, J, 2W...
Page 163
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R8199 D0YAR0000007 M 0 OHM 1/4W R8242 ERJ2GEJ470 M 47 OHM, J,0.063W R8201 ERJ2GEJ470 M 47 OHM, J,0.063W R8243 ERJ2GEJ470 M 47 OHM,...
Page 164
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R8314 D0YAR0000007 M 0 OHM 1/4W R8428 ERJ2GEJ680 M 68 OHM, J,0.063W R8315 D0YAR0000007 M 0 OHM 1/4W R8429 ERJ2GEJ680 M 68 OHM,...
Page 165
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R8476 ERJ2GEJ221 M 220 OHM, R8545 ERJ2GEJ121 M 120 OHM, J,0.063W J,0.063W R8477 ERJ2GEJ221 M 220 OHM, R8546 ERJ2GEJ121 M 120 OHM, J,0.063W...
Page 166
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R8651 ERJ2GEJ103 M 10KOHM, R8748 ERJ2GEJ560X M 56 OHM, J,0.063W J,0.063W R8661 ERJ2GEJ103 M 10KOHM, R8749 ERJ2GEJ560X M 56 OHM, J,0.063W J,0.063W R8663...
Page 167
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R8795 ERJ2GEJ103 M 10KOHM, R8905 ERJ2GEJ103 M 10KOHM, J,0.063W J,0.063W R8796 ERJ2GEJ560X M 56 OHM, R8906 ERJ2GEJ103 M 10KOHM, J,0.063W J,0.063W R8798...
Page 168
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R8974 ERJ2GEJ560X M 56 OHM, R9117 ERJ2GEJ472 M 4.7KOHM, J,0.063W J,0.063W R8995 ERJ2GEJ560X M 56 OHM, R9118 D0GDR00Z0002 M 0 OHM, 1/10W J,0.063W R9118 ERJ3GEYJ471...
Page 169
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R9154 ERJ2GEJ470 M 47 OHM, R9205 ERJ2GEJ331 M 330 OHM, J,0.063W J,0.063W R9155 ERJ2GEJ103 M 10KOHM, R9206 ERJ2GEJ102X M 1K OHM J 1/4W J,0.063W R9207...
Page 170
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R9272 ERJ2GEJ101 M 100 OHM, R9353 EXB38V470J RESISTOR ARRAY J,0.063W R9354 EXB2HV103JV RESISTOR ARRAY R9273 ERJ2GEJ470 M 47 OHM, R9355 ERJ2GEJ103 M 10KOHM,...
Page 171
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R9950 EXB38V470J RESISTOR ARRAY K1MN68BA0266 68P CONNECTOR R9951 EXB38V470J RESISTOR ARRAY K1MN68BA0266 68P CONNECTOR R9952 ERJ2GEJ470 M 47 OHM, K1KA04AA0728 4P CONNECTOR J,0.063W K1MN68BA0266 68P CONNECTOR...
Page 172
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description C14992 F1H1C105A008 C 1UF, K, 16V C16413 F2A2T251A004 E 250UF, 220V C16003 F1L2J562A022 C 5600UF, K,6.3V C16414 F2A2T251A004 E 250UF, 220V C16011 F2A2T251A004 E 250UF, 220V C16415...
Page 173
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description C16813 ECA2CM101 E 100UF, 160V C17305 F1H1A1050032 C 10UF, 50V C16814 F1H1H561A971 C 560UF, 50V C17310 F1K2A105A006 C 1UF, 100V C16821 ECJ1VB1H104K C 0.1UF, K, 50V C17313...
Page 174
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description C17624 F1H1C104A143 C 0.1UF, K, 16V D16021 MA3DF30000LW ZENER DIODE C17625 F1H1C104A143 C 0.1UF, K, 16V D16022 MA3DF30000LW ZENER DIODE C17626 F1K2A105A006 C 1UF, 100V D16032...
Page 175
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description D16609 MA2J11100L DIODE D17208 B0ECKM000038 DIODE D16610 MA2J11100L DIODE D17209 B0ECKM000038 DIODE D16618 B0ECKP000047 DIODE D17210 B0ECKM000038 DIODE D16619 B0ECKP000047 DIODE D17301...
Page 176
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description IC16301 MIP9L02MBS L16011 G0C1R4KA0118 PEAKING COIL IC16302 C0CBALC00012 IC L16012 G0C1R4KA0118 PEAKING COIL IC16303 C0JBAB000715 IC L16013 G0C1R4KA0118 PEAKING COIL IC16464 C0JBAB000715 IC L16014...
Page 177
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description Q16023 B1JAEN000004 TRANSISTOR Q16810 B1ABCF000231 TRANSISTOR Q16024 B1JAEN000004 TRANSISTOR Q16814 B1ABCN000007 TRANSISTOR Q16025 B1JAEN000004 TRANSISTOR Q16815 B1ABCN000007 TRANSISTOR Q16041 2PG0330000RP TRANSISTOR PAVCCZ...
Page 178
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R14926 D0GD103JA036 M 10KOHM,J,0.25W R14995 D0GD103JA036 M 10KOHM,J,0.25W R14928 ERJ6GEYJ221V M 220 OHM,J,1/ R14996 D0GD103JA036 M 10KOHM,J,0.25W R14997 D0GD103JA036 M 10KOHM,J,0.25W R14929 ERJ6GEYJ221V M 220 OHM,J,1/...
Page 179
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R16191 D0GD151JA036 M 150 R16322 ERJ6GEYF561 M 560 OHM,F,1/ OHM,J,0.25W R16192 ERJ6GEYJ103V M 10K OHM J 1/ R16323 ERJ6GEYJ103V M 10K OHM J 1/ R16195 ERJT08J1R0V...
Page 180
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R16506 ERJT06J100V M 10 OHM,F,0.25W R16612 ERJT06J470V M 47 OHM,F,0.25W R16507 ERJT06J100V M 10 OHM,F,0.25W R16613 ERJ8GEYJ473 M 47KOHM, J,1/8W R16509 ERJT08J1R0V M 1.8OHM,J,...
Page 181
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R16737 ERJ6ENF2103 M 210KOHM, 1/10W R16872 ERJ6GEYJ332V M 3.3K OHM J 1/ R16738 ERG1FJS823D M 82KOHM, J, 1W R16873 ERJ6ENF2491 M2.49KOHM, 1/10W...
Page 182
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R17215 ERJT14J6R8U C6.8 OHM, J,1/4W R17336 ERJT14J6R8U C6.8 OHM, J,1/4W R17216 ERJT14J6R8U C6.8 OHM, J,1/4W R17337 ERJT14J6R8U C6.8 OHM, J,1/4W R17217 ERJT14J6R8U C6.8 OHM, J,1/4W...
Page 183
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R17505 EXB38V471J RESISTOR ARRAY R17606 EXB38V471J RESISTOR ARRAY R17506 EXB38V471J RESISTOR ARRAY R17607 EXB38V471J RESISTOR ARRAY R17507 ERJT14J6R8U C6.8 OHM, J,1/4W R17608 EXB38V471J...
Page 184
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description SS56 K1MN13B00091 13P CONNECTOR TW-4BS-2L LUG TERMINAL SS57 K1MN13B00091 13P CONNECTOR SS58 K1MN13B00091 13P CONNECTOR A601 AYRA362MSV7T ARRESTOR A602 AYRA362MSV7T ARRESTOR SSMM2...
Page 185
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description C802 ECKENA101KBR C 100P 250V L602 AYP3165208ZA FILTER CHOKE C803 ECKENA101KBR C 100P 250V L603 ETB50CZ14GAD TRANSFORMER L604 AYP3165208ZA FILTER CHOKE C807 ACDE1R102K7...
Page 186
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R205 ERDS2FJ334 C 330KOHM, J,1/ R404 ER0S2CHF5492 M54.9KOHM, F,1/ R206 ERDS2FJ334 C 330KOHM, J,1/ R405 ARRF2EJR10B METAL GLAZE FIXED RESISTOR R207 ERG12SJ820J...
Page 187
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R651 ERDS2FJ103 C 10KOHM, J,1/4W ZD203 MA4270NMTA ZENER DIODE R652 ERDS2FJ103 C 10KOHM, J,1/4W ZD204 MA4270NMTA ZENER DIODE R653 ERDS2FJ222 C 2.2KOHM, J,1/...