TX-23LX60M / TX-23LX60X / TX-23LX60A Design and specifications are subject to change without notice. Weight and Dimensions shown are approximate. CONTENTS Page Page 1 Safety Precautions 10.4. Option Code Setting 1.1. General Guidelines 11 Adjustment 2 Prevention of Electro Static Discharge (ESD) to 11.1.
TX-23LX60M / TX-23LX60X / TX-23LX60A 1 Safety Precautions 1.1. General Guidelines 1. When servicing, observe the original lead dress. If a short circuit is found, replace all parts which have been overheated or damaged by the short circuit. 2. After servicing, see to it that all the protective devices such as insulation barriers, insulation papers shields are properly installed.
TX-23LX60M / TX-23LX60X / TX-23LX60A 8. Minimize bodily motions when handling unpackaged replacement ES devices. (Otherwise hamless motion such as the brushing together of your clothes fabric or the lifting of your foot from a carpeted floor can generate static electricity (ESD) sufficient to damage an ES device).
TX-23LX60M / TX-23LX60X / TX-23LX60A 4 Input signal that can be displayed *Mark: Applicable input signal for Component (Y,P ) and HDMI Signal name Horizontal frequency(kHz) Vertical frequency(Hz) Component HDMI 480i(525)/60Hz 15.73 59.94 480p(525)/60Hz 31.47 59.94 576i(625)/50Hz 15.63 50.00 576p(625)/50Hz 31.25...
TX-23LX60M / TX-23LX60X / TX-23LX60A 5 Self-check function When phenomena like "the power fails from time to time" or "the video/audio fails from time to time" can not be confirmed at the time of servicing, the self-check function can be used to confirm the occurrence and to limit the scope for the defective circuits.
TX-23LX60M / TX-23LX60X / TX-23LX60A 6 Chassis Board Layout Board Name Function A-Board Main (AV connector, AV Switch, Tuner, Audio & Video Processor, MCU, LCD Driver, LVDS) V-Board Remote Receiver, LED, B.A.T.S. K-Board Headphone jack AP-Board Power Supply, Power Regulator...
TX-23LX60M / TX-23LX60X / TX-23LX60A 7 Disassembly for Service 7.1. Pedestal ass’y 1. Lay down the main unit so that the rear cover faces upward. 3. Remove the fixing screws (2 pcs). 2. Remove the fixing screw (2 pcs). 4. Remove the Tuner Cover Ass’y.
TX-23LX60M / TX-23LX60X / TX-23LX60A 7.5. Power Button Bracket Ass’y 1. Remove the rear cover. (See 7.2) 2. Remove the fixing screws (2 pcs). 3. Remove the Power Button Bracket Ass’y. 7.7. Power Supply unit 1. Disconnect the coupler (AP1~CN301).
TX-23LX60M / TX-23LX60X / TX-23LX60A 7.10. K-Board 1. Remove K-Board. 4. Fix the Rubber to IC4001 and the Shield case (top) to A- Board. 2. Disconnect the coupler (K1~A4). Caution: a. Fix carefully Shield case to shield clip (9 pcs).
TX-23LX60M / TX-23LX60X / TX-23LX60A 10 Service Mode Function MPU controls the functions switching for each IC through IIC bus in this chassis. The following setting and adjustment can be adjusted by remote control in Service Mode. 10.1. How to enter SERVICE 1 1.
TX-23LX60M / TX-23LX60X / TX-23LX60A 10.4. Option Code Setting If the memory IC (IC1102) or A-Board is replaced, option code should be re-memorized. Spare part of IC1102 is already memorized all Data. If you use for other model, you should re-memorized the different option code in SERVICE 2 mode.
TX-23LX60M / TX-23LX60X / TX-23LX60A 11 Adjustment 11.1. Voltage chart of A-Board 1. Turn on the main power SW and check that each output voltage of test point is within the specificationa below.( At this time the LED turns green.) 2.
TX-23LX60M / TX-23LX60X / TX-23LX60A 13.2. MAIN BLOCK Diagram POWER CONTROLLER AUDIO VCC 13.5V UNIT MAIN 5V AC IN MAIN 1.8V ST7V RELAY7V CONTROL PANEL UNIT POWER SUPPLY INV_ON INV_SOS KIDO_PWM 3.3V 1.8V ST7V FACT5V AUDIO_VCC BT30V PANEL_5V IC1102 EEPROM...
TX-23LX60M / TX-23LX60X / TX-23LX60A 16 Electrical Replacement Parts List 16.1. Replacement Parts List Notes...
Page 49
1 6 . 2 . E l e c t r i c a l R e p l a c e m e n t P a r t s L i s t TX-23LX60A/M/X Ref.No. Part No. Part Name & DescriptionPcs Remarks Ref.No.
Page 50
TX-23LX60A/M/X Ref.No. Part No. Part Name & DescriptionPcs Remarks Ref.No. Part No. Part Name & DescriptionPcs Remarks C2367 EEEHB1C101UP C 100PF, J, 16V C4065 ECJ0EB1H102K C 1000PF, K, 50V C3062 ECJ1VF1A105Z C 1UF, Z, 10V C4066 ECJ0EB1A104K C 0.1UF, K, 10V C3064 EEEHB1A471UP C 470PF, J, 10V...
Page 51
TX-23LX60A/M/X Ref.No. Part No. Part Name & DescriptionPcs Remarks Ref.No. Part No. Part Name & DescriptionPcs Remarks C5007 ECJ1XF1C104Z C 0.1UF, Z, 16V D1818 MA8130M ZENER DIODE C5008 ECJ1XB1C104K C 0.1UF, Z, 16V D1819 MA111 DIODE C5009 F1J0J1060004 C 0.010UF, K, 16V D1820 MA8056-M ZENER DIODE...
Page 54
ERJ3GEYJ101 M 100 OHM,J,1/16W 1 TX-23LX60A R2099 ERJ3GEYJ100 M 10 OHM,J,1/16W 1 TX-23LX60A R3035 D0GB101JA041 M 100 OHM J 1/16W 1 TX-23LX60M/X R2099 D0GB100JA041 M 10 OHM J 1/16W 1 TX-23LX60M/X R3036 ERJ3GEYJ101 M 100 OHM,J,1/16W 1 TX-23LX60A R2100 ERJ3GEYJ100...
Page 55
ERJ6GEY0R00 0 OHM, 1/10W R4050 ERJ3GEYJ101 M 100 OHM,J,1/16W 1 TX-23LX60A R3227 ERJ3GEYJ103 M 10KOHM,J,1/16W R4050 D0GB101JA041 M 100 OHM J 1/16W 1 TX-23LX60M/X R3228 ERJ3GEY0R00 0 OHM, 1/16W R4053 ERJ3GEYJ101 M 100 OHM,J,1/16W 1 TX-23LX60A R3229 ERJ3GEYJ153 M 15KOHM,J,1/16W...
Page 56
ERJ3GEYJ151 M 150 OHM,J,1/16W 1 TX-23LX60A R4221 ERJ3GEYJ102 1KOHM,J,1/16W 1 TX-23LX60A R4117 D0GB151JA041 M 150 OHM J 1/16W 1 TX-23LX60M/X R4221 D0GB102JA041 M 1K OHM J 1/16W 1 TX-23LX60M/X R4118 D0GB471JA041 M 470 OHM J 1/16W R4222 ERJ3GEYJ103 M 10KOHM,J,1/16W...
Page 57
Part No. Part Name & DescriptionPcs Remarks R5009 ERJ3GEYJ2R7 2.7HM,J,1/16W 1 TX-23LX60A R5082 D0GB220JA041 M 22 OHM J 1/16W R5009 D0GB2R7JA040 M 2.7 OHM J 1/16W 1 TX-23LX60M/X R5083 EXB38V220J RESISTOR ARRAY R5010 ERJ3GEYJ2R7 2.7HM,J,1/16W 1 TX-23LX60A R5084 EXB2HV220JV RESISTOR ARRAY R5010 D0GB2R7JA040 M 2.7 OHM J 1/16W...
Page 58
TX-23LX60A/M/X Ref.No. Part No. Part Name & DescriptionPcs Remarks Ref.No. Part No. Part Name & DescriptionPcs Remarks TXN/A10MFM CIRCUIT BOARD A TX-23LX60X ETXMM606M7B P MODULE 1 ...