SECTION 1 PRECAUTIONS SAFETY PRECAUTIONS Prior to shipment from the factory, JVC products are strictly can increase the high voltage value and cause X-ray emis- inspected to conform with the recognized product safety and sion from the cathode ray tube.
Page 3
1.1.2 Safety Check after Servicing Examine the area surrounding the repaired location for damage (4) Leakage current test or deterioration. Observe that screws, parts and wires have been Confirm specified or lower leakage current between earth returned to original positions, Afterwards, perform the following ground/power cord plug prongs and externally exposed tests and confirm the specified values in order to verify accessible parts (RF terminals, antenna terminals, video...
SECTION 2 SPECIFIC SERVICE INSTRUCTIONS DIFFERENCE LIST MODEL GZ-HM30BKR GZ-HM30BUA GZ-HM30BUB COMPONENT CONN. AC CORD KR TYPE IRAM TYPE BRAZIL TYPE BATTERY BN-VG107KR BN-VG107EU BN-VG107EU 1-4 (No.YF365<Rev.001>)
Page 12
Quality point When you assemble the unit, please check the following points for keeping the quality. [1] TOP COVER ASSY [9] OP BLOCK ASSY Fig.3-1-1 Fig.3-1-9 When attaching the TOP COVER, properly Between the CMOS and the MAIN, run the FPC set the rear side.
SECTION 4 ADJUSTMENT PREPARATION • 4.1.1 Precaution Torque Driver Be sure to use to fastening the mechanism and exterior parts This model is specially adjusted by using PC. However, if parts such as the following are replaced, an because those parts must strictly be controlled for tightening adjustment is required.
Page 14
JIG CONNECTOR CABLE CONNECTION Connection procedure Remove the 3 screws (1-3), and then remove the TOP COVER ASSY. TOP COVER ASSY CN9003 CONNECTOR CABLE SERVICE SUPPORT SYSTEM (Software) MENU PC CABLE PERSONAL COMPUTER 1-14 (No.YF365<Rev.001>)
Page 16
<BOARD INTERCONNECTIONS> OPERATION TO LED LIGHT CMOS PWB ZOOM INT MIC CMOS 102 PWB OP BLOCK(A2WN) CMOS 053 PWB SPEAKER SNAP Trigger CN451 CN401 For IMX102 For IMX053 CN9002 CN9006 CN4602 CN9008 CN9007 MAIN PWB TO MAIN PWB CN601 LIT_3.0V PWR_LED ACES_LED REAR...
Page 17
<MAIN(MAIN IF) SCHEMATIC DIAGRAM> Note : The parts numbers in the schematic diagram are for references only. When replacing the parts, refer to the PARTS LIST. TELE,WIDE,PHOTO-KEY,TRIGGER,GND to OPERATION UNIT *CN9006 CN9008 CN9007 CN9002 to CMOS PWB QGF0543F3-06X QGA1001F1-02X QGF0543F3-06X QGF0534F5-06X C9016 1 MAIN(MAIN IF)
Page 18
<MAIN(SUB CPU) SCHEMATIC DIAGRAM> Note : The parts numbers in the schematic diagram are for references only. When replacing the parts, refer to the PARTS LIST. 1 MAIN(SUB CPU) R1014 LIT_3.0V LIT_3.0V AL_2.8V R1063 OPEN AL_2.8V REG_2.8V REG_2.8V R1064 OPEN REG_2.8V C1001 C1002...
Page 19
<MAIN(FELIX) SCHEMATIC DIAGRAM> Note : The parts numbers in the schematic diagram are for references only. When replacing the parts, refer to the PARTS LIST. 1 MAIN(FELIX) R3012 OPEN VDDE_2.8V *R3015 OPEN *R3018 OPEN MENU MENU OPEN VDDE_2.8V C3202 TP_X R3060 TP_X OPEN...
Page 20
<MAIN(NAND) SCHEMATIC DIAGRAM> Note : The parts numbers in the schematic diagram are for references only. When replacing the parts, refer to the PARTS LIST. OPEN OPEN C8003 OPEN OPEN C8011 C8007 C8008 *C8004 1 MAIN(NAND) AH11 AG13 SD2_CMD SD2_CMD AE14 *R8001 AA14...
Page 21
<MAIN(OP DRV) SCHEMATIC DIAGRAM> Note : The parts numbers in the schematic diagram are for references only. When replacing the parts, refer to the PARTS LIST. 1 MAIN(OP DRV) REG_2.8V OPEN C4601 R4606 Z_LED_SUB W/B_E R4680 OPSENS_CTRL TL4601 R4607 F_LED_SUB A2WN FOCUS02_SUB OPDRV_PSX...
Page 22
<MAIN(COMP DRIVER) SCHEMATIC DIAGRAM> Note : The parts numbers in the schematic diagram are for references only. When replacing the parts, refer to the PARTS LIST. 1 MAIN(COMP DRIVER) FROM FELIX IC VIDEO_PS PBIN *L3701 PRIN NQLG13M-100X REG_2.8V BH76061GU-X TO COMP. JACK V_VCC V_GND *IC3701...
Page 23
<MAIN(REG) SCHEMATIC DIAGRAM> Note : The parts numbers in the schematic diagram are for references only. When replacing the parts, refer to the PARTS LIST. 1 MAIN(REG) DONE PEN2 BL_FBI BLLEVEL_CTL REGLCD_CTL REG_1.2V REG_CTL2 REG_1.2V REG_CTL REG_2.8V REG_2.8V REG_CHG_DET REG_DOK REG_CEN REG_PEN1 REG_1.8V...
Page 24
<MAIN(AUDIO(STEREO)) SCHEMATIC DIAGRAM> [STEREO TYPE ONLY] Note : The parts numbers in the schematic diagram are for references only. When replacing the parts, refer to the PARTS LIST. 1 MAIN(AUDIO(STEREO)) To Woflson(IC 2201) *Q2462 2SC5383/F/-X AVDD REG_5.0V REG_2.8V REG_1.8V *L2461 *R2462 4.7k AU_SIG/R...
Page 25
<MAIN(AUDIO(MONO)) SCHEMATIC DIAGRAM> [MONO TYPE ONLY] Note : The parts numbers in the schematic diagram are for references only. When replacing the parts, refer to the PARTS LIST. 1 MAIN(AUDIO(MONO)) from REG REG_2.8V *C2401 *C2402 OPEN OPEN to IF *R2203 *R2802 AU_SIG/R *C2601...
Page 26
<REAR SCHEMATIC DIAGRAM> Note : The parts numbers in the schematic diagram are for references only. When replacing the parts, refer to the PARTS LIST. L601 2 REAR TO MAIN PWB NRSA6AJ-0R0W AV JACK CN601 SONY GYRO V_OUT QGF0528F4-40X QNS0297-001X L602 J601 R601...
Page 27
<JACK SCHEMATIC DIAGRAM> Note : The parts numbers in the schematic diagram are for references only. When replacing the parts, refer to the PARTS LIST. *J201 NNZ0212-001X TO MAIN PWB HDMI *CN201 3 JACK TMDS_D2+ TMDS Data2+ QGF0543F3-18X TMDS_D2- TMDS Data2- TMDS_D1+ TMDS Data1+ TMDS_CLK-...
Page 28
<MONITOR SCHEMATIC DIAGRAM> Note : The parts numbers in the schematic diagram are for references only. When replacing the parts, refer to the PARTS LIST. From Main PWB CN701 QGF0528F4-34X D703 D704 OPEN OPEN 4 MONITOR REG_LED/REG_5.0V REG_LED/REG_5.0V BL_CTL1/BL_FBI REG_2.8V M_RVS D705 LCD_DATA...
Page 29
<CMOS SCHEMATIC DIAGRAM> Notes : 1. The parts number in the schematic diagram are for references only. When replacing the parts, refer to the PARTS LIST. 2. The schematic diagram is only for reference. Avoid replacing individual parts. Replace the entire unit only. When CMOS BOARD ASSEMBLY needs replacement, replace the CMOS FRAME ASSEMBLY in whole because it cannot be replaced alone.
Page 31
<MAIN CIRCUIT BOARD> (Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade)) <01>MAIN LYB10258-001B COMPONENT SIDE(A) C4601 RA1003 C1012 R1030 10258 C1003 R1029 R1031 MAIN R1028 C1002 R1017 R1032 R1018 IC1001 C1004 R1022 R1027 C3015 C3053 X1001...
Page 32
<REAR CIRCUIT BOARD> (Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade)) CAUTION : <02>REAR FOR CONTINUED PROTECTION AGAINST FIRE HAZARD, REPLACE ONLY WITH SAME TYPE AND RATED FUSE(S). ATTENTION : LYB20080-001B POUR UNE PROTECTION PERMANENTE CONTRE LES RISQUE D'INCENDE, REMPLACER LES FUSIBLES PAR UNAAUTRE DE MEME TYPE ET DE MEME TENSION.
Page 33
<MONITOR CIRCUIT BOARD> (Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade)) <04>MONITOR LYB20080-001B FOIL SIDE(B) COMPONENT SIDE(A) R750 R749 R748 R747 R746 R745 R744 R743 IC722 C721 C722 L723 R725 C703 R705 R702 R704 R703 UL MARK...
Page 34
Victor Company of Japan, Limited Imaging Products Business Division 12, 3-chome, Moriya-cho, Kanagawa-ku, Yokohama-city, Kanagawa-prefecture, 221-8528, Japan (No.YF365<Rev.001>) Printed in Japan...
Page 35
PARTS LIST CAMCORDER GZ-HM30BKR GZ-HM30BUA GZ-HM30BUB (No.YF365<Rev.001>)1/12...
Page 36
■ PRECAUTIONS ON SCHEMATIC DIAGRAMS Due to the improvement in performance, some part numbers shown in the circuit diagrams may not agree with those indicated in the Parts List. The parts numbers, values and rated voltage etc. in the Schematic Diagrams are for reference only.
Page 37
FINAL ASSEMBLY<M1> The instruction manual to be provided with this product will differ according to the destination. MODEL MARK GZ-HM30BKR GZ-HM30BUA GZ-HM30BUB 210B 210A No.YF365 created date:2011-02-10 (No.YF365<Rev.001>)3/12...
Page 38
FINAL ASSEMBLY<M1> The instruction manual to be provided with this product will differ according to the destination. MODEL MARK GZ-HM30BKR GZ-HM30BUA GZ-HM30BUB FRONT ASSEMBLY REAR BOARD ASSEMBLY <02> MAIN BOARD ASSEMBLY <01> BASE UPPER ASSEMBLY CMOS BOARD ASSEMBLY <05> OP BLOCK No.YF365...
Page 39
FINAL ASSEMBLY<M1> The instruction manual to be provided with this product will differ according to the destination. MODEL MARK GZ-HM30BKR GZ-HM30BUA GZ-HM30BUB UPPER ASSEMBLY MONI. BOARD ASSEMBLY <04> JACK BOARD ASSEMBLY <03> No.YF365 created date:2011-02-10 (No.YF365<Rev.001>)5/12...
Page 40
MODEL MARK MODEL MARK MODEL MARK GZ-HM30BKR GZ-HM30BUA GZ-HM30BUB Safe Symbol No. Parts No. Parts Name Description Local FINAL ASSEMBLY <M1MM> LY37600-001C TOP COVER ASSY ------------ STICKER ------------ STICKER LY37969-032A RATING LABEL A LY37776-003A RATING LABEL A-LP LY37778-003A RATING LABEL...
Page 41
PACKING AND ACCESSORY ASSEMBLY <M5> MODEL MARK GZ-HM30BKR GZ-HM30BUA GZ-HM30BUB FINAL ASSEMBLY <M1> No.YF365 created date:2011-02-10 (No.YF365<Rev.001>)7/12...
Page 42
MODEL MARK MODEL MARK MODEL MARK GZ-HM30BKR GZ-HM30BUA GZ-HM30BUB Safe Symbol No. Parts No. Parts Name Description Local PACKING AND ACCESSORY ASSEMBLY <M5MM> ------------ POLY BAG FOR JMM ------------ POLY BAG ------------ PACKING CASE PRODUCTION ------------ PACKING CASE A-LP ------------...
Page 43
MODEL MARK MODEL MARK MODEL MARK GZ-HM30BKR GZ-HM30BUA GZ-HM30BUB Safe Symbol No. Parts No. Parts Name Description Local C3024 NCBA1AK-104W C CAPACITOR 0.1uF 10V K C3026 NCBA1AK-104W C CAPACITOR 0.1uF 10V K C3028 NCB20JK-106X C CAPACITOR 10uF 6.3V K C3032...
Page 44
MODEL MARK MODEL MARK MODEL MARK GZ-HM30BKR GZ-HM30BUA GZ-HM30BUB Safe Symbol No. Parts No. Parts Name Description Local R2404 NRSA6AJ-100W MG RESISTOR 10Ω 1/16W J R2462 NRSA6AJ-472W MG RESISTOR 4.7kΩ 1/16W J R2463 NRSA6AJ-183W MG RESISTOR 18kΩ 1/16W J R2801...
Page 45
MODEL MARK MODEL MARK MODEL MARK GZ-HM30BKR GZ-HM30BUA GZ-HM30BUB Safe Symbol No. Parts No. Parts Name Description Local R6922 NRSA6AJ-105W MG RESISTOR 1MΩ 1/16W J R9001 NRSA6AJ-682W MG RESISTOR 6.8kΩ 1/16W J R9002 NRSA6AJ-223W MG RESISTOR 22kΩ 1/16W J R9003...
Page 46
MODEL MARK MODEL MARK MODEL MARK GZ-HM30BKR GZ-HM30BUA GZ-HM30BUB Safe Symbol No. Parts No. Parts Name Description Local C904 NCBA1EK-472W C CAPACITOR 4700pF 25V K C906 NCB31EK-473X C CAPACITOR 0.047uF 25V K C907 NCJ20JM-226X-A C CAPACITOR 22uF 6.3V M C908...