Operation; To The New Operator Or Owner; How The Machine Works - Husky H6000 Operator's Manual

---
4 OPERATION
4.01 TO THE NEW
OPERATOR OR OWNER
Husky Farm Equipment's Liquid
Manure Pumps are designed to efficiently agitate and
pump liquid manure from the storage facility to the
hauling tank, transferring to alternative storage or to
feed a high pressure irrigation pump for Irrigating the
manure. Many of the features incorporated into this
machine are the result of suggestions made by
customers like you. Read this manual carefully to learn
how to operate the machine safely and how to set it to
provide maximum efficiency. The manual will take you
step-by-step through your working day. By following
the operating instructions in conjunction with a good
maintenance program. your Liquid Manure Pump will
provide many years of trouble-free service.
General Information About the
Husky Liquid Manure
H5000/H6000 Pump
Husky Farm Equipment Limited
deSIgns and manufactures all of its products
so
they
can be operated safely. However the responsibility for
safe operation rests with those who use and maintain
these products.
The Husky Liquid Manure Pump
should be operated only by those who have been
trained to do so. and who have read these operating
instructions and operating manual. Failure to follow the
instructions. procedures and safety precautions in this
manual may increase the possibility of an accident or
injury.
The Husky H5000 Liquid Manure
Pump is designed to be driven with a farm tractor with
a 540 RPM PTO (1:1.35 ratio), or the gear box can be
turned over to operate at 1000 RPM (1.35:
I
ratio).
The Husky H6000 Pump is designed just for 1000 RPM
(1:1 ratio). If run at higher RPM's damage to gear box
and drive train could result.
The Husky Liquid Manure Pump
comes in different lengths to suit different pit depths.
make sure the pump you are using is matched with the
pit so that PTO runs reasonably straight. If PTO is run
on too great an angle it will cause vibration and could
shear a pin in the PTO or it could cause the PTO to
break and increase the danger of injury. or it would
wear the bearings in the gear box prematurely.
The H5000 Liquid Manure Pump
takes between 70 and 100 HP tractor to operate
efficiently. The H6000 Liquid Manure Pump takes 150
HP. A smaller tractor will operate the Liquid Manure
Pump satisfactorily to fill tank or transfer but will not
come up to full RPM. putting a larger tractor on the
pump will not damage the pump providing it is run at
proper speed.
4.02 HOW THE MACHINE
WORKS
The Husky Liquid Manure Pump uses
a P.T.O. driven impeller or fan assembly to carry the
manure in a pipe from the pit or storage area to a
manure spreader. remote storage facility. truck or
container of some description. A pipe attached to the
top of the pump called a discharge pipe carries the
manure.
D':.';~~
.-. ".'."
I!I.....
~
.~
= ­
FIG. 1 PRINCIPALS OF OPERATION
Optional equipment includes
1. Hydraulic or manual deflector / crustbuster
2.
Electric drive
3. Hydraulic propeller agitating fan
4.
Two point hitch
PAGE 9