KTM 660 RALLY 2004 Owner's Manual page 23

1
A
2
3
Fill 0.6 liters (0.16 US gallons) of engine oil into the can and remove the
plug 1 next to the steering head. Introduce the plastic hose into the vent
A
hole , (see page 30) and fill 0.6 liters (0.16 US gallons) of engine oil into
the frame's front tube. Remove plastic hose, start engine, and let it idle
(approx. 20 seconds) until oil escapes at the hole
to leak out, switch off the engine, mount the plug and gasket and tighten
to 25 Nm.
Let the motor run until it warms. Check the oil drain plugs and the fine
screen filter to make sure they are properly sealed. Check the level of the
motor oil. Place the motorcycle on a horizontal surface (main stand) and
wait for 5 minutes.Checking the oil level, he should be between the two
marks on the inspection glass, however, it must never rise above the MAX
mark. Otherwise, engine oil would get into the air filter box by way of the
engine venting system. Add engine oil, if necessary.
!
– I
NSUFFICIENT OIL OR POOR QUALITY OIL RESULTS IN PREMATURE WEAR OF THE
.
ENGINE
– C
HECKING THE ENGINE OIL LEVEL WHEN THE ENGINE IS COLD RESULTS IN A FALSE
READING ON THE OIL DIPSTICK AND THEREFORE AN INCORRECT OIL LEVEL
– D
O NOT OVERFILL THE ENGINE CASE
– D
O NOT UNDERFILL THE ENGINE CASE
Afterwards check the entire oil system and motor to make sure they are
properly sealed.
NOTE: Dispose of used oil properly! Under no circumstances may used oil
be disposed of in the sewage system or in the open countryside. 1 liter
(0.264 US gallons) oil contaminates 1.000.000 liter (264.000 US gallons)
water.
Fuses
2
The main fuse (20 amperes) is easily accessible on the left frame tube.
3
The fuse box for power consumers is located on the right in the cockpit
fairing.
Replace a blown fuse only with an equivalent one. If a new fuse that has
just been set in gets blown again, you are strongly advised to have it
inspected by a KTM dealer.
!
U
NDER NO CIRCUMSTANCES IS A STRONGER FUSE ALLOWED TO BE SET IN OR A FUSE
„ ". A
ALLOWED TO BE REPAIRED
!
ELECTRICAL INSTALLATION
A
. As soon as oil begins
CAUTION
.
.
CAUTION
N INEXPERT TREATMENT COULD DAMAGE THE WHOLE
!
.
23
!