1. Manuals
  2. Brands
  3. Winnebago Manuals
  4. Motorhomes
  5. Travato 2019
  6. Operator's manual

Winnebago Travato 2019 Operator's Manual

Hide thumbs
Table of Contents

Advertisement

Quick Links

Download this manual
Rev. 1905180719
Part No. 161500-19-002
Copyright 2018 Winnebago Industries, Inc. All rights reserved.

Advertisement

Table of Contents
loading

Related Manuals for Winnebago Travato 2019

Summary of Contents for Winnebago Travato 2019

  • Page 1 Rev. 1905180719 Part No. 161500-19-002 Copyright 2018 Winnebago Industries, Inc. All rights reserved.

  • Page 3: Table Of Contents

    TABLE OF CONTENTS 1 – INTRODUCTION About this Manual ..........................1-1 Safety Messages Used in this Manual ....................1-1 Pre-Delivery Inspection ........................1-2 Before Driving ..........................1-2 Front Axle Tire Alignment ....................... 1-2 Service and Assistance ........................1-2 Reporting Safety Defects ........................1-2 Occupant and Cargo Carrying Capacity Labels ................
  • Page 4 Table Of Contents Radio – In-Dash ..........................3-4 Battery Boost Switch ........................3-4 Engine Cooling System ........................3-5 Lights ..............................3-5 Tires ..............................3-5 Suspension Alignment and Tire Balance ..................3-5 4 – APPLIANCES AND SYSTEMS Refrigerator ............................4-1 Range Top ............................4-1 Microwave Oven ..........................
  • Page 5 Table Of Contents Disinfecting Your Fresh Water System .................... 7-4 Shower Hose Vacuum Breaker ......................7-6 Shower .............................. 7-7 Sink – Lavatory ..........................7-8 Exterior Shower/Wash Station ......................7-9 Toilet ..............................7-9 Waste Water System (Model 59G) ....................7-10 Waste Water System (Model 59K) ....................7-13 Holding Tank Heater ........................
  • Page 6 Table Of Contents Sink – Stainless Steel ........................10-8 Range and Refrigerator ........................10-9 Vinyl Flooring ..........................10-9 Bathroom ............................10-10 Doors and Windows ........................10-10 Vehicle Storage – Preparation ...................... 10-10 Vehicle Storage – Removal ......................10-11 Chassis Service and Maintenance ....................10-12 Motorhome Maintenance Chart ....................

  • Page 7: Introduction

    The instructions included in this manual are intended as a guide, and in no way DANGER indicates a hazardous situation extend the responsibilities of Winnebago which, if not avoided, will result in death or Industries beyond the standard written serious personal injury.

  • Page 8: Pre-Delivery Inspection

    National Highway Traffic Safety Administration delivery inspection of the chassis and all (NHTSA) in addition to notifying Winnebago motorhome components. Industries, Inc. As a part of the pre-delivery inspection...

  • Page 9: Occupant And Cargo Carrying Capacity Labels

    SECTION 1 – INTRODUCTION or go to http://www.safercar.gov or write to: Administrator, NHTSA 1200 New Jersey Avenue S.E. Washington, D.C. 20590 You can also obtain other information about motor vehicle safety at http://www.safercar.gov. OCCUPANT AND CARGO CARRYING CAPACITY LABELS The following labels are affixed on the driver’s door jamb.

  • Page 10: Vehicle Certification Label

    6. Color: Signifies the color code number of the decor used throughout the vehicle. This number is necessary for ordering replacement cushions, curtains, carpet, etc. ® 7. Winnebago model year and series/family name. 8. Model: Lists the Winnebago product model number of your vehicle.

  • Page 11: Specifications And Capacities

    24 gal. Notes: All information is based upon the most recent data available. Visit the Winnebago Industries, Inc. web page – www.winnebagoind.com – for the most current product information. The height of each model is measured to the top of the tallest standard feature and is based on the curb weight of a typically equipped unit.

  • Page 12: Owner And Vehicle Information

    Motorhome Serial Number ___________________________________________________________ Chassis Vehicle Identification No. (VIN) ________________________________________________ Vehicle Mileage at Delivery __________________________________________________________ Selling Dealer Name ________________________________________________________________ Address __________________________________________________________________________ __________________________________________________________________________ ® YOUR WINNEBAGO INDUSTRIES DEALER /SERVICE CENTER Name ____________________________________________________________________________ Address __________________________________________________________________________ __________________________________________________________________________ Contact ____________________________________________Phone ________________________ CHASSIS SERVICE CENTER...

  • Page 13: Safety And Precautions

    SECTION 2 – SAFETY AND PRECAUTIONS GENERAL WARNINGS WA RNING • Only seats equipped with seat belts are to be occupied while the vehicle is moving. • Make sure all passengers have seat belts Operating, servicing and maintaining this fastened. Lap belts should fit low on the hips vehicle can expose you to chemicals and upper thighs.

  • Page 14: Driving Safety

    SECTION 2 – SAFETY AND PRECAUTIONS • Do not operate the cruise control on icy or DRIVING SAFETY extremely wet roads, winding roads, in heavy traffic, or in any other traffic situation where a constant speed cannot be maintained. WA RNING •...
  • Page 15 SECTION 2 – SAFETY AND PRECAUTIONS • Portable fuel-burning equipment, including wood and charcoal grills and stoves shall not WA RNING be used inside the recreational vehicle. The use of this equipment inside the recreational vehicle may cause fires or asphyxiation. Do not fill propane container(s) to more •...

  • Page 16: Propane Gas Leaks

    Replacement When replacing this alarm, we recommend replacing only with the same model, or with one that is also listed for RV application. We recommend obtaining a replacement from your ® Winnebago Industries dealer.

  • Page 17: Carbon Monoxide Warning

    RV application. We Do not run engine in confined areas, such as a recommend obtaining a replacement from your garage, except to move vehicle into or out of the ® Winnebago Industries dealer. area. Further Information CARBON MONOXIDE ALARM...

  • Page 18: Smoke Alarm

    Replacement your motorhome. We recommend obtaining a When replacing this alarm, we recommend replacement only from your Winnebago replacing only with the same model, or with one ® Industries dealer or a reliable RV parts supplier.

  • Page 19: Loading

    SECTION 2 – SAFETY AND PRECAUTIONS • Improper grounding of the vehicle can cause • Do not mix different construction types of personal injury. Do not plug the utility power tires on the vehicle, such as radial, bias, or cord into an outlet which is not grounded and belted tires, as vehicle handling may be do not adapt the plug to connect to a receptacle affected.

  • Page 20: Roof And Ladders

    SECTION 2 – SAFETY AND PRECAUTIONS Before Using the Ladder • Inspect the ladder to make sure it is not damaged. Never use a damaged ladder. • Keep the rungs of the ladder clean and dry while in use. Never use the ladder when it is raining, snowing, or icy.

  • Page 21: Mold, Moisture, And Your Motorhome

    Winnebago organic materials, nutrients, moisture, and proper Industries within the limited warranty period, temperature. Winnebago will clean the affected area(s) and/or replace affected items as it deems necessary. This is the extent of coverage provided by Winnebago...

  • Page 22: Roadside Emergency

    When you have come to a stop, activate your should a problem occur. hazard flashers to warn other motorists, then If Winnebago Industries determines that mold exit the vehicle carefully. is present due to conditions it determines is not a •...

  • Page 23: Jump Starting

    SECTION 2 – SAFETY AND PRECAUTIONS JUMP STARTING If your vehicle will not start from the chassis battery, try using the Battery Boost switch to divert power from the house batteries to the starter. (See “Battery Boost Switch” in Section 3 - Driving Your Motorhome).

  • Page 25: Driving Your Motorhome

    SECTION 3 – DRIVING YOUR MOTORHOME The information in this section refers only to features installed or adapted to the dash and driver compartment area by Winnebago Lumbar ® Industries . It also includes passenger seating in Control the living area of the motorhome.

  • Page 26: Seat Belts

    SECTION 3 – DRIVING YOUR MOTORHOME Armrest Adjustment 1- Insert tab into buckle The armrests may be swung upward out of the slot until it “clicks” and is way for easy exit or access to the front seats. A locked roller on the underside of the front of the armrest also lets you adjust the resting angle for personal comfort, whether the seat is upright or reclined.

  • Page 27: Child Restraints

    SECTION 3 – DRIVING YOUR MOTORHOME Lap/Shoulder Belts 3. Be certain that it is appropriate for the child's height, weight, and development. The Refer to the chassis manual provided in your instructions and/or the regulation label InfoCase for instructions on proper fastening, attached to the restraint typically provides this adjustment, and releasing of lap/shoulder belts.

  • Page 28: Keys

    SECTION 3 – DRIVING YOUR MOTORHOME Further Information Refer to the chassis manual provided in your InfoCase for complete operating instructions on using the Remote Keyless Entry system and for battery replacement information. HAZARD WARNING FLASHERS The hazard warning flashers provide additional safety when the vehicle must be stopped on the side of the roadway and presents a possible hazard to other motorists.

  • Page 29: Engine Cooling System

    SECTION 3 – DRIVING YOUR MOTORHOME Press and Hold the Battery Boost switch in the LIGHTS ON position while turning ignition key for emergency starting power. All exterior lights should be checked for proper operation each time the vehicle is NOTE: The House/Coach Battery Disconnect prepared for a trip.
  • Page 30 SECTION 3 – DRIVING YOUR MOTORHOME Alignment can be affected by worn steering/ suspension parts or by incidents which happen during driving, such as hitting a curb, pothole, or railroad track, etc. Improper alignment can cause tires to roll at an angle and wear unevenly. It may also cause the vehicle to “pull”...

  • Page 31: Appliances And Systems

    SECTION 4 – APPLIANCES AND SYSTEMS Further Information The appliances installed in your motorhome are manufactured by reputable RV appliance Refer to the manufacturer’s user guide makers and have been tested by independent provided in your InfoCase for complete operating laboratories to meet all applicable standards and instructions, safety precautions, and maintenance codes set for RV appliances.

  • Page 32: Microwave Oven

    SECTION 4 – APPLIANCES AND SYSTEMS If the appliance has not been operated for a period of time, the surface burner WA RNING may be difficult to light due to air in the gas line. Portable fuel-burning equipment • To extinguish the burner flame, turn desired including wood and charcoal grills and burner knob to OFF.

  • Page 33: Oneplace® Systems Monitor Panel

    SECTION 4 – APPLIANCES AND SYSTEMS Water And Holding Tank Levels Press the Tank Levels switch to show NOTICE approximate levels on the LCD screen. Do not store items in oven. If oven would turn on stored items can ignite resulting in fire and or property damage.

  • Page 34: Solar Charge Panel

    SECTION 4 – APPLIANCES AND SYSTEMS Battery Charge Meter NOTE: Some models may be equipped with a Water Pump switch in the water service Press the Battery Levels switch to check the center on the outside of the motorhome level of charge (voltage) in the chassis and house or within the bathroom area for your batteries.

  • Page 35: Power Control System (Pcs)

    SECTION 4 – APPLIANCES AND SYSTEMS radio station memory circuitry, for example. Although the Solar Charge Panel can help to extend battery life, the motorhome shoreline should be plugged in routinely to “top off” the batteries. We also recommend following regular battery inspection and maintenance, especially in cold weather.

  • Page 36: Heating System - Furnace And Indirect Water Heating

    SECTION 4 – APPLIANCES AND SYSTEMS Further Information Refer to the manufacturer’s user guide provided in your InfoCase for important information on how this system operates under several conditions, whether 20-amp, 30-amp, or generator service. HEATING SYSTEM – FURNACE AND INDIRECT WATER HEATING The heating system in your motorhome is a propane and 110V power unit that provides warm...

  • Page 37: Roof Air Conditioning System

    SECTION 4 – APPLIANCES AND SYSTEMS • Turn clockwise to increase values (+) and • Position the louvers to the desired direction counterclockwise to decrease values (-). the discharge air is to flow. • Tap to save a selected value. During Cooler Nights •...

  • Page 39: Propane Gas

    SECTION 5 – PROPANE GAS PROPANE GAS SUPPLY The propane gas system supplies fuel for the gas range/oven, furnace, and refrigerator (while in gas mode). When used and handled properly, this system is safe and economical and provides • Main modern living conveniences wherever you travel.
  • Page 40 SECTION 5 – PROPANE GAS DANGER All pilot lights, appliances, and their • Main igniters (see operating instructions) shall Tank be turned off before refueling of motor fuel Shutoff Switch tanks and/or propane containers. Can cause ignition of flammable vapors, which can lead to a fire or explosion and result in Main Tank Shutoff Switch death or serious injury.

  • Page 41: Propane Accessory Connection

    SECTION 5 – PROPANE GAS run on propane only, we recommend that you request straight propane only. Butane burns about 30 percent hotter than propane and can overheat some appliances, particularly refrigerators, and cause permanent damage. Other appliances designed to operate on propane can become sooted and lose efficiency by using butane fuel.

  • Page 42: Safe Use Of The Propane Gas System

    SECTION 5 – PROPANE GAS • Never attach a lock or any device requiring a SAFE USE OF THE PROPANE key to the propane compartment door. GAS SYSTEM According to standards set for recreation vehicles, the propane supply valve must be The propane system is designed and built with readily accessible in an emergency.

  • Page 43: Propane Gas Pressure Regulator

    SECTION 5 – PROPANE GAS • All pilot lights must be extinguished and PROPANE GAS PRESSURE appliances and their ignitors turned off while REGULATOR refilling the fuel tank or propane container. • Never smoke while refilling vehicle fuel tank The pressure regulator is protected from the or propane gas container.

  • Page 44: Propane Vaporization In Cold Weather

    SECTION 5 – PROPANE GAS If regulator freeze-up should occur, you may attempt to thaw the regulator using a light bulb. DO NOT USE AN OPEN FLAME OR HEAT LAMP. If moisture begins to cause problems, have your propane gas dealer inject a small amount of dry methyl alcohol in your tank (approximately one ounce to 20 pounds or one pint to 100 gallons) to help guard against regulator freeze-...

  • Page 45: Electrical

    SECTION 6 – ELECTRICAL Your motorhome is equipped with an when the auxiliary electric generator is running, electrical system consisting of two separate the power converter automatically changes a voltages: portion of the 120-volt current to 12-volt DC current. All equipment in the motorhome that is •...

  • Page 46: Inverter Unit - 1000W

    SECTION 6 – ELECTRICAL WA RNING Service inlet access must be closed when utility connections are not in use. Park Fuses or Breakers 30 Amp Receptacle Most campgrounds are equipped with a fuse or circuit breaker at the receptacle (which we recommend shutting off before engaging or WA RNING disengaging the power cord.) This protects the...

  • Page 47: Power Center

    SECTION 6 – ELECTRICAL Inverter Control Panel (Located near monitor panel) -Typical View Inverter Unit When the inverter is not being used, it should (Located inside an interior cabinet) be shut off at the control panel. The inverter -Typical View could drain the house batteries if the shoreline is not connected to external power and the House/ Coach Battery Disconnect switch is on.

  • Page 48: Circuit Breakers - House 120-Volt Ac

    SECTION 6 – ELECTRICAL overheating. A portion of the house 12-volt load (lights or motors or both) should be turned off to NOTICE reduce total load. Also, inspect the power converter to make sure ventilation is not obstructed. Do not block the converter cover vents in any way.

  • Page 49: Electrical Outlets - House 120-Volt Ac

    SECTION 6 – ELECTRICAL ELECTRICAL OUTLETS – HOUSE 120-VOLT AC WA RNING A number of standard household electrical outlets are provided throughout the motorhome The GFCI will not completely eliminate for connecting small appliances such as the risk of electrical shock. Infants and televisions, radios, toasters, etc.

  • Page 50: Electrical System - House 12-Volt Dc

    SECTION 6 – ELECTRICAL Operation Warnings and Cautions WA RNING The exhaust of all internal combustion engines contains carbon monoxide (CO). This poisonous gas is colorless, odorless, tasteless, and lighter than air. The exhaust systems of both your motorhome Generator Start/Stop Buttons engine and your generator engine have (Located on monitor panel) been installed with your safety in mind.

  • Page 51: House/Coach Battery Disconnect Switch

    SECTION 6 – ELECTRICAL Converter electrical items that are hooked directly to the house batteries, such as clock displays and radio See “Converter” previously in this section. memories, etc. Chassis Battery Always leave this switch ON while using the motorhome. The chassis battery is used to operate the engine starter and automotive accessories and NOTE: Some electronic displays and memory...

  • Page 52: Battery Care

    SECTION 6 – ELECTRICAL reservoir, not an electrical source. As soon as energy is removed from the battery, it should be replaced by the engine alternator or the motorhome converter system. If a battery sits unused for 30 days or more, especially during warm weather, it can develop a deposit of sulfate crystals on the metal plates inside the battery.
  • Page 53 SECTION 6 – ELECTRICAL WA RNING WA RNING California Proposition 65 Warning: Before removing any battery cables or Battery posts, terminals, and related battery, make sure all 12-volt equipment accessories contain lead and lead in the motorhome is off and the power compounds, chemicals known to the cord has been disconnected.

  • Page 54: Circuit Breakers And Fuses

    SECTION 6 – ELECTRICAL Chassis Battery If your motorhome is going to be unoccupied ® for two weeks or more, Winnebago Industries recommends disconnecting the chassis battery in your motorhome to avoid battery discharge. CIRCUIT BREAKERS AND Functional Non-Functional FUSES...

  • Page 55: Plumbing

    SECTION 7 – PLUMBING Always fill the fresh water tank at an approved FRESH WATER SYSTEM potable water filling facility or a known purified drinking water source. The Fresh Water System provides water to the galley sink, shower, bathroom lavatory, toilet, The tank is filled through the Tank Fill Inlet and water heater.

  • Page 56: Water Pump

    SECTION 7 – PLUMBING Method 2 - Filling the Fresh Water Using Tank Water (Gravity Fill) Tank Through Gravity Fill • Turn Water Pump switch ON. While the switch is on, the water pump will automatically supply tank water as needed. WA RNING Connecting City Water Supply Potable water only.
  • Page 57 SECTION 7 – PLUMBING as the faucet is open. When you close the faucet, • Insert the strainer screen back into the bowl, the line pressure backs up to the pump, and it then screw the bowl back onto the strainer shuts itself off.

  • Page 58: Cold Water Filter

    SECTION 7 – PLUMBING Water Pump • Model 59G: Remove lower drawer in Cold Water Filter Assembly galley to access. (Located inside lower galley cabinet) NOTE: Hot waterline is not filtered. • Model 59K: Remove access door under left twin bed. *Model 59G shown Replacing the Cold Water Filter Cartridge...
  • Page 59 SECTION 7 – PLUMBING Disinfecting with Gravity Fill 1. Prepare a chlorine solution using 1 gallon of water and 1/4 cup of household chlorine bleach (sodium hypochlorite solution). With tank empty, pour chlorine solution into the tank through the gravity fill port. Use 1 gallon solution for each 15 gallons of tank capacity.

  • Page 60: Shower Hose Vacuum Breaker

    SECTION 7 – PLUMBING NOTE: If you do not have an in-line cartridge with clean water. You may also want to turn filter, see City Water Hose/Tank the water heater off until this is done to avoid Disinfection following this procedure for wasting energy trying to heat “unused”...

  • Page 61: Shower

    SECTION 7 – PLUMBING and allows water remaining in the hose to drain down. This is a normal function of the shower valve assembly and is not a leak or defect. If items are placed into the shower tub before shower valve vacuum release is complete, they may become wet.

  • Page 62: Sink - Lavatory

    SECTION 7 – PLUMBING Shower Pump Filter Screen The shower pump (located beneath galley cabinet access panel) also has a filter screen that should be inspected periodically and cleaned if necessary. Shower Filter Screen (Located beneath galley cabinet access panel) -Typical View Shower Valve Pressure Bleed-Off Shower Pump...

  • Page 63: Exterior Shower/Wash Station

    SECTION 7 – PLUMBING EXTERIOR SHOWER/WASH STATION The exterior wash station feature allows you to do things such as rinse off sand or salt after a swim, rinse off muddy boots, or bathe your pet outside the motorhome. Some models may have a water pump switch located in the service center for convenience.

  • Page 64: Waste Water System (Model 59G)

    SECTION 7 – PLUMBING Waste Pump (Model 59G) The 12-volt Waste Pump transfers gray holding tank waste through a small diameter sewer hose to the main dump valve. To access the Waste Pump, use a screwdriver to remove the black plug shown in the following photo.
  • Page 65 SECTION 7 – PLUMBING NOTE: If Waste Pump stalls, check breaker in 3. Place the outlet end of sewage drain hose into the load center. If problem persists, disposal opening. remove black plug and motor shaft NOTE: Black and Gray Waste Tank Drain valve access plate;...
  • Page 66 SECTION 7 – PLUMBING 3. Attach a garden hose from a city water hydrant to the Black Waste Tank Flush Inlet fitting on the right sidewall. (This inlet is clearly marked separate from the City Water inlet). Waste Pump Switch (Located beneath motorhome near sewage drain outlet) -Typical View...

  • Page 67: Waste Water System (Model 59K)

    SECTION 7 – PLUMBING miles to dislodge the solids. A few starts and stops will aid in the process. Then reconnect the hose and drain in the normal manner. NOTE: Always keep sewage drain outlet capped while sewage connection is not in use. Holding Tank Level Indicators See “Systems Monitor Panel”...
  • Page 68 SECTION 7 – PLUMBING • 1st - Pull Black Waste Tank Drain valve to drain black water (sewage) tank, then close. CAUTION Do not use the tank flush valve unless the fullway termination valve is in the open position. Can result in an unsanitary condition leading to illness or personal injury.

  • Page 69: Holding Tank Heater

    SECTION 7 – PLUMBING WA RNING Service inlet access must be closed when utility connections are not in use. When using a sewer hook-up, keep the dump valves closed until a tank becomes full or when preparing to leave the site. This keeps the solids in suspension, allowing them to be carried out with the liquids when the dump valve is opened.

  • Page 70: Water Heater Bypass Valve

    SECTION 7 – PLUMBING Waterline Drain Valves *Model 59K shown (See “Water System Drain Valve Locations” Water Heater Bypass Valve chart at the end of this section for location (See “Water System Drain Valve Locations” on your model) chart at the end of this section for location on your model) *Model 59G Water Tank Drain Valve...

  • Page 71: Winterizing Procedure

    SECTION 7 – PLUMBING CAUTION Leave bypass valve handle in NORMAL FLOW position if draining water and blowing out waterlines. Place in BYPASS position ONLY when using antifreeze solution in waterlines. WINTERIZING PROCEDURE Certain areas of your water system require Water Heater Drain (Yellow) Valve additional attention and disconnecting or •...
  • Page 72 A “blow-out” plug can be purchased at any model). ® 15. Turn air pressure off. Disconnect blow-out Winnebago Industries dealer. plug. After Disconnecting Air Pressure City Water 16. Close all waterline and tank drain valves, and...
  • Page 73 SECTION 7 – PLUMBING WA RNING NEVER use automotive antifreeze/ coolant in your RV water system. Automotive coolant/antifreeze contains ethylene glycol which, if ingested, can cause blindness and can be fatal. Your motorhome is equipped with a manually operated waterline winterization system for your Black Waste Tank Flush Inlet convenience in winterizing fresh waterlines.
  • Page 74 SECTION 7 – PLUMBING 25. Turn “Winterization Valve 2” to the Replace city fill inlet filter. Recap the city “Winterize” position. water inlet to avoid contamination by dirt or insects. 31. Winterize the Waste Pump and Shower Drain Pump (Model 59G only) If your motorhome is not equipped with a waste pump or shower drain pump, resume to the next numbered step.

  • Page 75: Water System Drain Valve Locations

    SECTION 7 – PLUMBING WATER SYSTEM DRAIN VALVE LOCATIONS Model System Drain Valve Locations Waterline Drain • Two (2) drain valves in galley cabinet under range at Valves floor level next to water pump. Remove lower drawer to access. • Open exterior shower faucet and lay shower head on ground.

  • Page 77: Entertainment

    SECTION 8 – ENTERTAINMENT To Swivel TV TV – (SWING-OUT) 1. Pull the black strap (located on back side of –If Equipped TV) straight DOWN to release the TV from (Typical View - your motorhome may the mounting bracket. vary in appearance) Your motorhome may be equipped with a TV swing-out mechanism, which allows you to angle the TV to best suit your viewing needs.

  • Page 78: Dvd Player With Deluxe Sound

    SECTION 8 – ENTERTAINMENT • When the main menu screen DVD PLAYER WITH DELUXE appears, press the ENTER SOUND button on the DVD player remote or PLAY/PAUSE –If Equipped button on DVD player to begin playing the main feature. Use the arrow buttons on the DVD remote to select another feature to play.

  • Page 79: Tv Antenna - Digital

    SECTION 8 – ENTERTAINMENT Exterior Speaker Digital Antenna Power Switch (Located below patio awning) (Located in an overhead cabinet or -Typical View mounted on a wall near the TV) 2. Turn ON the Signal Meter Power switch To connect the exterior speaker system with (located on the side of the Signal Meter).

  • Page 80: Tv Signal Amplifier

    SECTION 8 – ENTERTAINMENT 6. Rotate antenna to illuminate the last flickering LED light. 7. Repeat Steps 5 and 6 to pinpoint signal reception. NOTE: Refer to television manufacturer’s instructions to scan for available channels. Further Information See the antenna manufacturer’s user guide provided in your InfoCase for complete operating and maintenance information.
  • Page 81 SECTION 8 – ENTERTAINMENT Composite Connection • Model 59G: Located in cabinet behind TV. • Model 59K: Located in overhead cabinet above TV. -Typical View...

  • Page 83: Furniture And Softgoods

    SECTION 9 – FURNITURE AND SOFTGOODS SLEEPING FACILITIES WA RNING Sleeping facilities are not intended for use while vehicle is in motion. For safety, passengers must use safety belted seating positions while vehicle is in motion. DINETTE/BED CONVERSION Reverse steps to store table. (Model 59G) Dinette to Bed (Typical View –...
  • Page 84 SECTION 9 – FURNITURE AND SOFTGOODS 5. Lower dinette table to the floor. Then lower 9. Remove wood block from side facing dinette dinette seat cushion. seat base. 6. Cover dinette table with front facing dinette 10. Remove support bar from underside of back cushion.

  • Page 85: Bed - Deluxe Sleep System

    SECTION 9 – FURNITURE AND SOFTGOODS BED – DELUXE SLEEP SYSTEM (Model 59K) (Typical View – Your motorhome may differ in appearance) Adjustable Head Rest • Pull up to desired angle of comfort (you will hear a “click”). 11. Align velcro on cushion and support bar. Push down to attach.
  • Page 86 SECTION 9 – FURNITURE AND SOFTGOODS 3. Remove one (1) bed extension support bar from beneath passenger side twin bed cabinet. Attach support bar to the notches on the bed cabinet as shown. Bed Conversion 1. Remove dining table from storage location (attached by latch on passenger side twin bed cabinet.

  • Page 87: Window Shades/Screens

    SECTION 9 – FURNITURE AND SOFTGOODS 4. Place dining table securely onto the pedestal leg. 6. Reverse steps to convert bed back into twin bed position. 5. Reverse steps to store dining table and Dining Conversion pedestal legs. 1. Remove dining table from storage location WINDOW SHADES/SCREENS (attached by latch on passenger side twin bed cabinet.

  • Page 88: Wood Furniture And Cabinetry

    To lower translucent screen, pull the bottom of No matter which species you chose for your the screen straight down until the bottom latch new Winnebago Industries motorhome “clicks” into position. cabinetry, please keep in mind that no two pieces of wood are exactly the same.

  • Page 89: Maintenance And Storage

    • Have the sealant replaced if you notice any of vehicle can cause damaging rust or corrosion on the above. Your local Winnebago Industries steel or aluminum parts and can add needless dealer has the correct and necessary parts and weight to the vehicle.

  • Page 90: Exterior Automotive Paint Finish

    SECTION 10 – MAINTENANCE AND STORAGE undercarriage regularly with water, especially thaws out, it may be possible to remove them horizontal surfaces, cavities, and other areas by hand waxing with a silicone-free liquid where mud and other deposits may collect. wax.
  • Page 91 SECTION 10 – MAINTENANCE AND STORAGE undercarriage and the body of your • Rinse washed area before soap evaporates. motorhome after exposure to these types • Dry the rinsed area before the water of conditions. evaporates. NOTE: Avoid aiming water flow from a hose or Washing spray from high-pressure washing •...

  • Page 92: Exterior Graphic Care

    SECTION 10 – MAINTENANCE AND STORAGE Protective Film • We recommend a silicone-free polish with an orbital machine and terry cloth applicator. –If Equipped • Liquid waxes are easier to apply and bring to Your motorhome may be equipped with a a gloss with fewer residues.

  • Page 93: Plastic Parts - Cleaning

    Use the following EXTERIOR LIGHTS cautionary lists as a guide when selecting cleaning products to use on plastic parts. ® Most Winnebago Industries vehicles have polycarbonate lenses on exterior lamps, which are very sensitive to a variety of chemical NOTICE solvents and cleaners.
  • Page 94 SECTION 10 – MAINTENANCE AND STORAGE fading. Always test any cleaning product on a • Saddle soaps, oils, abrasives, cleaners hidden area of fabric before using on visible containing detergent (such as dishwashing areas. For best results, fabric cleaning should be liquids).

  • Page 95: Cabinetry - Cleaning

    SECTION 10 – MAINTENANCE AND STORAGE CABINETRY – CLEANING UltraLeather Cleaning Chart Wooden items may be cleaned with a soft Detergent/ Cleaner/ cloth and a good quality wood finish cleaning Type of Stain Water Degreaser product.  Coffee, Tea Vinyl simulated wood panels may be cleaned ...

  • Page 96: Solid Surface Countertop - Corian

    SECTION 10 – MAINTENANCE AND STORAGE surface material is extremely heat resistant, but SOLID SURFACE sudden contact by a very hot material with a cold ® COUNTERTOP – CORIAN countertop surface could cause a crack that would need to be repaired. Likewise, Care and Maintenance concentrated high heat sources in a small area, such as a crock pot or an electric griddle may...

  • Page 97: Range And Refrigerator

    SECTION 10 – MAINTENANCE AND STORAGE • Do not use rubber mats in the sink bowl. • Burning cigarettes and matches can cause Material trapped under mats can complicate damage to the flooring. cleaning. • Use doormats (that do not contain bitumen) to keep out most of the dirt and dust.

  • Page 98: Bathroom

    SECTION 10 – MAINTENANCE AND STORAGE Pet stains: For Glass Windows: Use care when removing ice or frost from the windows. Always • Treat with lukewarm water. If stain remains use a plastic ice scraper, never one made of visible, clean with a soft nylon pad and non- metal.

  • Page 99: Vehicle Storage - Removal

    SECTION 10 – MAINTENANCE AND STORAGE 6. After charging batteries, turn the House/ 5. Close all faucets and drain valves that are Coach Battery Disconnect switch off to open. disconnect the batteries and avoid parasitic* 6. Add a few gallons of water to the fresh water drain.

  • Page 100: Chassis Service And Maintenance

    SECTION 10 – MAINTENANCE AND STORAGE See the Sealants – Recommended Application page in the Supplement Manual provided in your InfoCase. Also inspect weather seals around doors, etc., and if necessary, have a dealer replace immediately. CHASSIS SERVICE AND MAINTENANCE Consult the appropriate sections in the chassis manual for specific information regarding operating safety, service recommendations, and...

  • Page 101: Motorhome Maintenance Chart

    SECTION 10 – MAINTENANCE AND STORAGE MOTORHOME MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Propane Gas System ...
  • Page 102 SECTION 10 – MAINTENANCE AND STORAGE MOTORHOME MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Safety Equipment Check operation of the following items: ...
  • Page 103 SECTION 10 – MAINTENANCE AND STORAGE MOTORHOME MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Sealants ...

  • Page 105: Miscellaneous

    SECTION 11 – MISCELLANEOUS NOTE: We recommend that you dump all LOADING THE VEHICLE holding tanks before traveling to avoid carrying unnecessary weight. NOTE: Your motorhome’s load capacity is designated by weight, not by volume, so you cannot necessarily use all available space when loading your motorhome.
  • Page 106 SECTION 11 – MISCELLANEOUS Weighing not exceed the corresponding Axle Weight Rating specified on the Vehicle Certification There is typically a scale operator to direct Label. you, but the basic routine is to take three separate weights - front axle, whole vehicle, and rear axle. Corner Weighing (Side-to-Side) You will first drive only your front wheels The most accurate method of weighing a...

  • Page 107: Car Or Trailer Towing

    SECTION 11 – MISCELLANEOUS The load on each wheel or dual-wheel set See preceding items “Loading the Vehicle” and should not exceed one-half of the corresponding “Weighing Your Loaded Vehicle” for GAWR. For example, if the GAWR for the rear explanation of weight ratings.

  • Page 108: Trailer Wiring Connector

    SECTION 11 – MISCELLANEOUS of the towed vehicle. In other words, the more TRAILER WIRING force applied to the motorhome brakes, the more CONNECTOR force will be applied to the rear vehicle’s braking system. Your motorhome is pre-wired for trailer or car We do not recommend the usage of a “surge- towing lights with a 4-pin and 7-pin wiring style”...

  • Page 109: Windows

    (GCWR) label limiting vertical tongue load to 350 This is the maximum allowable weight of the lbs. Some Winnebago Industries models motorhome and loaded trailer, including the equipped with a Class IV hitch have a items noted in GVWR above. For purposes of label limiting vertical tongue load to 500 this definition, the “trailer”...

  • Page 110: Power Roof Ventilator

    SECTION 11 – MISCELLANEOUS Closing the Windows NOTE: In Auto Mode the fan direction is automatically positioned to Exhaust, but To close window, extend all the way out (past may be overridden and changed to the third notch setting) and the window will Intake by depressing the button.

  • Page 111: Step (Entry) - Electric

    SECTION 11 – MISCELLANEOUS To Operate Ceiling Ventilator 1. To open the ventilator dome, push upwards on the Fan Lift Bar. 2. Press the Fan Power Switch to operate. 3. When finished using the roof ventilator, press the Fan Power Switch to stop operation. 4.

  • Page 112: Awning - Power

    SECTION 11 – MISCELLANEOUS Accent LED Light Strips (Located on driver side running board) Power Awning Switch and Awning Light Switch -Typical View (if equipped) (Located at front of galley or shower wall) -Typical View The Front AUX switch (located near the sliding door) operates the LED Light Strips.

  • Page 113: Screen Door

    SECTION 11 – MISCELLANEOUS will only extend when the vehicle ignition key is 2. Release bike rack retention brackets by in the Off position. The Awning can retract pulling outward. Lower the bike rack. anytime regardless of the ignition key position. 3.

  • Page 114: Ladder

    SECTION 11 – MISCELLANEOUS • Make sure you are physically capable to LADDER safely use the ladder. Strength, flexibility and stability are required. –If Equipped • Be aware that the vehicle may sway as you climb the ladder. Do not use the ladder in high winds.

  • Page 115: Luggage Rack

    SECTION 11 – MISCELLANEOUS • Maximum Capacity of Luggage Rack: 200 lbs. evenly distributed over all roof rails. Each roof rail will support 40 lbs. of weight. WA RNING STAY OFF ROOF. Surface may be slippery. Falling could result in death or serious injury.
  • Page 116 SECTION 11 – MISCELLANEOUS Humidity and Condensation Moisture condensing on the inside of windows is a visible indication that there is too much humidity inside the motorhome. Excessive moisture can cause water stains or mildew, which can damage interior items such as upholstery and cabinets.
  • Page 117 INDEX About this Manual ..........................1-1 Accent LED Running Board Lights ...................... 11-7 Air Conditioner Filter ..........................4-7 Air Conditioner/Heater – Automotive (Dash) ..................3-4 Audio/Video System Basic Operation ....................8-1 Audio/Video System Connection ......................8-4 Awning – Power ........................... 11-8 Bathroom ............................
  • Page 118 Index Exterior Graphic Care ........................... 10-4 Exterior Lights ............................10-5 Exterior Shower/Wash Station ........................ 7-9 Exterior Speakers ............................ 8-2 Fire Extinguisher ............................. 2-6 Formaldehyde Information ........................2-8 Fresh Water System ..........................7-1 Front Axle Tire Alignment ........................1-2 Fuel and Propane Gas ..........................2-2 General Warnings ...........................
  • Page 119 Index Propane Vaporization in Cold Weather ....................5-6 Radio – In-Dash ............................3-4 Range and Refrigerator ......................... 10-9 Range Top ............................... 4-1 Refrigerator ............................. 4-1 Remote Keyless Entry ..........................3-4 Reporting Safety Defects ........................1-2 Roadside Emergency ..........................2-10 Roof ..............................10-1 Roof Air Conditioning System .......................
  • Page 120 Index Waste Water System (Model 59K) ....................... 7-13 Water Heater Bypass Valve ........................7-16 Water Pump ............................7-2 Water System Drain Valve Locations ....................7-21 Waterline and Tank Drain Valves ......................7-15 Weighing Your Loaded Vehicle ......................11-1 Window Shades/Screens ......................... 9-5 Windows ...............................

Table of Contents