SERVICE MANUAL Issue 2014-12-10 Rev. Model: WS49GDB FZ1412S025V3 Contents Table of Contents ················································································································ 2 1. General Information ······································································································ 3 1-1. General guideline ···································································································· 3 1-2. Insurance Test ········································································································· 3 1-3. How to read this Service Manual ············································································· 4 2. Product Feature ············································································································ 5 2-1.
SERVICE MANUAL Issue 2014-12-10 Rev. Model: WS49GDB FZ1412S025V3 Chapter 1 General Information 1-1. General Guidelines When servicing, observe the original lead dress. If a short circuit is found, replace all parts which have been overheated or damaged by the short circuit. After servicing, see to it that all the protective devices such as insulation barriers, insulation papers shields are properly installed.
SERVICE MANUAL Issue 2014-12-10 Rev. Model: WS49GDB FZ1412S025V3 12. In the case of leakage of inflammable gases like carbon monoxide, open the door and windows. Don’t pull out or insert the plugs of the appliance. 13. Don’t touch the refrigeration surface of the freezing compartment when the refrigerator is in operation, especially when our hand is wet, else we may be glued to the surface.
SERVICE MANUAL Issue 2014-12-10 Rev. Model: WS49GDB FZ1412S025V3 Chapter 3 Installation, adjustments and maintenance 3-1. Installation Do not install the wine cellar in any location not properly insulated or heated e.g. garage etc, the wine cellar was not designed to operate in temperature settings below 6 ℃。...
Page 9
SERVICE MANUAL Issue 2014-12-10 Rev. Model: WS49GDB FZ1412S025V3 3-3Maintenance 3-3-1. Defrosting and cleaning the Wine cellar Defrost whenever the frost becomes 1/4” thick. Never use a sharp or metallic instrument to remove the frost as it may damage the cooling coils. (A punctured coil will void the warranty) Unplug the power pin, then take out stored wine and place in a safety place.
SERVICE MANUAL Issue 2014-12-10 Rev. Model: WS49GDB FZ1412S025V3 Chapter 4 Disassembly 4-1. Door assembly (Door, hinge, hinge cover) a. Remove the hinge cover b. Remove the screws fixed the up hinge and lift the door. 4-2. Control panel a. Firstly, pick out all wine supports. Then remove b.
Page 11
SERVICE MANUAL Issue 2014-12-10 Rev. Model: WS49GDB FZ1412S025V3 c. invert the middle structure. d. Disassemble the light cover e. loosen the screws fixed the light. f. The display panel is fixed on the plastic panel with three Philip screws, pick out he connected wire then loose the screw.
Page 12
SERVICE MANUAL Issue 2014-12-10 Rev. Model: WS49GDB FZ1412S025V3 4-3. Heater a. Firstly, pick out all wine supports. Then remove b. Pick out the middle separate structure Fan baffle ,loosen the Philip screws on the two sides of the middle separate structure c.
SERVICE MANUAL Issue 2014-12-10 Rev. Model: WS49GDB FZ1412S025V3 4-3. Ballast ab a.Take the Philip screw apart from the b.Then take out the compartment cover , compartment cover. Take the philip screw apart from the box of Main control panel c. Pick out Main control panel d.
Page 14
SERVICE MANUAL Issue 2014-12-10 Rev. Model: WS49GDB FZ1412S025V3 4-4. Change sensor 1. First, use a screwdriver to remove the sensor cover 2. Then remove the sensor and remove the sensor from the wire harness; 3. Take the need to replace the sensor line, in the distance sensor...
Page 15
SERVICE MANUAL Issue 2014-12-10 Rev. Model: WS49GDB FZ1412S025V3 4. Connect the new sensor with the box body sensor wire; 5. The sensor will connect a good card in sensor...
Page 16
SERVICE MANUAL Issue 2014-12-10 Rev. Model: WS49GDB FZ1412S025V3 shield 6. The sensor cover card in the box;...
SERVICE MANUAL Issue 2014-12-10 Rev. Model: WS49GDB FZ1412S025V3 Chapter 5 Control and display system 5-1. Control panel and display Brief description of control panel principle: 1. Temperature Adjustment (up) 2.Temperature Adjustment (down)
Page 18
SERVICE MANUAL Issue 2014-12-10 Rev. Model: WS49GDB FZ1412S025V3 3.Red Wine Indicator 4. White Wine Indicator 5.Upper Compartment Indicator 6.LED Temperature Display -Upper Compartment 7.Lower Compartment Indicator 8.LED Temperature Display –lower Compartment 9.Temperature Set Button 10.Interion Light Button 1. Adjustable temperature display: While entering the temperature by pressing the temperature buttons about 3 second ,the set temperature will flash on the display.
SERVICE MANUAL Issue 2014-12-10 Rev. Model: WS49GDB FZ1412S025V3 Normally, when you open the door ,the LED light is on and when you close the door ,the LED light is off .If you want to keep the LED light is on after you close the door ,you can open the door and press the “light”...
SERVICE MANUAL Issue 2014-12-10 Rev. Model: WS49GDB FZ1412S025V3 1. If the wine cellar has been placed in a horizontal or tilted position for any period of time wait 24 hours before plugging the unit in. 2. The alarm will sound when the appliance is switched on for the first time and when the appliance is warm.
SERVICE MANUAL Issue 2014-12-10 Rev. Model: WS49GDB FZ1412S025V3 8-1. Abnormal phenomena Problems Reasons Removing methods 1. Fuse is broken 1. Check if there is short circuit and 2. The contact of plug, socket, and cable is not solve it, if not, change capable fuse good.
Page 24
SERVICE MANUAL Issue 2014-12-10 Rev. Model: WS49GDB FZ1412S025V3 1. Supplement a stabilizer, adjust to Compressor 1. Voltage is too low. rated value. buzzes and 2. Starting relay out of order. 2. Change starting relay. cannot be 3. The starting coil of starting motor is 3.
SERVICE MANUAL Issue 2014-12-10 Rev. Model: WS49GDB FZ1412S025V3 2、The reason maybe the fan is broken or be plugged or Refrigerant leakage or The compressor refrigeration 8-2. Abnormal phenomena 8-2-1. Compressor doesn’t start...
SERVICE MANUAL Issue 2014-12-10 Rev. Model: WS49GDB FZ1412S025V3 8-2-2.Poor cooling...
Page 27
SERVICE MANUAL Issue 2014-12-10 Rev. Model: WS49GDB FZ1412S025V3...
Page 28
8-2-3. The condition of everypart working,blow as...
Page 29
SERVICE MANUAL Issue 2014-12-10 Rev. Model: WS49GDB FZ1412S025V3 So if the temperature is too low ,the reason maybe : 1.connection between valve and Eva is wrong,need to check the color 2.the sensor is broken ,change the sensor 3.the valve maybe is not working ,change the valve...
Page 30
SERVICE MANUAL Issue 2014-12-10 Rev. Model: WS49GDB FZ1412S025V3 Error code Part Fault Rrepair 1 Check the point of sensor, and move it to original place. 2. Change the temperature controller. 3. Put the wine cellar to suitable Temperature sensor failure...