Related Manuals for Sony VAIO PCV-RX950
Summary of Contents for Sony VAIO PCV-RX950
- Page 1 PCV-RX9 __ Series SERVICE MANUAL For American Area US Model Canadian Model Ver 4-2004F Revision History S400 Lineup: PCV-RX950 PCV-RX951 PCV-RX991 PERSONAL COMPUTER VAIO 9-874-373-04...
- Page 2 Information in this document is subject to change without notice. Danger of explosion if battery is incorrectly replaced. Sony, VAIO and CLIE are trademarks or registered trademarks of Sony. Microsoft, Windows, Windows Media, Outlook, Bookshelf Replace only with the same or equivalent type and other Microsoft products are trademarks or registered trademarks recommended by the manufacturer.
-
Page 3: Table Of Contents
TABLE OF CONTENTS DISASSEMBLY FRAME HARNESS • Flow Chart ..............1-1 • Top Panel Section ............. 1-2 • Frame Harness Diagram and Jumper Setting • Left Panel Section ............ 1-2 of Mother Board ............2-1 • Optical Drive ............1-3 REPAIR PARTS LIST •... -
Page 4: Disassembly
SECTION 1 DISASSEMBLY • FLOW CHART PANEL ASS’Y OPTICAL TOP PANEL PANEL ASS’Y RIGHT (UPPER) DRIVE SECTION (LOWER) (U) PANEL (FOR 2 BAY) P1-2 P1-7 P1-8 P1-8 P1-3 CNX-187 BOARD P1-9 LEFT PANEL SWX-66 SECTION BOARD P1-2 P1-9 SWITCHING MEMORY POWER P1-4 P1-11... -
Page 5: Top Panel Section
• TOP PANEL SECTION 2 Remove the top panel section in the direction of arrow A . 1 two claws • LEFT PANEL SECTION 1 Pull thelever. 2 Remove the left panel section in the direction of arrow A . Confidential PCV-RX9__ Series (AM) -
Page 6: Optical Drive
• OPTICAL DRIVE 2 harness (IDE CD/DVD) 1 power connector 5 Remove the CD holder ass’y in the direction of arrow A . 4 harness (IDE CD/DVD) 7 Optical drive (upper side) 3 power connector 9 Remove the drive adaptor in the direction of arrow C . -
Page 7: Switching Power
• SWITCHING POWER 2 Push the lever 7 duct CPU ( * 1) 3 bracket power supply ass’y 8 three screws 6 two claws (No.6-32UNC) 5 two claws 1 screw (No.6-32UNC) 4 Disconnect respective power connectors. 9 switching power * 1: When using CPU 3GHz or more. When attaching the switching power, it takes care so that harness may not be inserted into the chassis. -
Page 8: Hdd
• HDD 3 Push the lever. 5 two screws (SW) (No.6-32UNC) 1 harness (IDE/ATA) 4 HDD bracket ass’y 5 two screws (SW) (No.6-32UNC) 6 HDD 2 power connector • PCI SLOT PANEL 1 screw (SW) (No.6-32UNC) 2 PCI slot panel 4 PCI slot panel 3 screw (SW) (No.6-32UNC) -
Page 9: Vga Card
• VGA CARD 1 screw (SW) (No.6-32UNC) 3 VGA card AGP1 2 Push the clip. Confidential PCV-RX9__ Series (AM) -
Page 10: Modem Card
• MODEM CARD 1 screw (SW) (No.6-32UNC) 2 modem card • PANEL ASS’Y (UPPER) (FOR 2 BAY) 3 two claws 4 panel ass’y (upper) (for 2 bay) 2 two claws 1 Open the door (FDD) ass’y. Confidential PCV-RX9__ Series (AM) -
Page 11: Panel Ass'y (Lower) (U)
• PANEL ASS’Y (LOWER) (U) 3 two claws 4 Remove the front panel ass’y (lower) (U) in the direction of arrow A . 2 two claws 1 two claws • RIGHT PANEL 2 Remove the right panel in the direction of arrow A . 1 two claws Confidential PCV-RX9__ Series (AM) -
Page 12: Cnx-187 Board
• CNX-187 BOARD 4 two screws (SW) (No.6-32UNC) 2 harness (USB2, SCOTT) 1 harness 5 CNX-187 board (1394) 3 Remove the bracket AV ass’y in the direction of arrow A . • SWX-66 BOARD 1 harness (SW/LED) 4 LED shield 2 screws (SW) (No.6-32UNC) 3 SWX-66 board... -
Page 13: Fdd
• FDD 4 Push the lever. 5 Remove the FDD 2 power bracket ass’y in the connector direction of arrow A . 1 harness (FDD) 3 harness (MS, SIO) 6 two screws (PWH3 × 5) 7 FDD • CNX-169 BOARD 1 two screws (SW) (No.6-32UNC) 3 CNX-169 board... -
Page 14: Memory
• MEMORY 2 memory Note 1: In opening the clips, hold lightly the top of the memories with your fingers to prevent a drop. Note 2: In removing the memories, always start from the one having largest bank number. 1 Open clip. 1 Open clip. -
Page 15: Dc Fan (With Heat Sink)
• DC FAN (WITH HEAT SINK) 1 clip 2 clip 3 DC fan (with heat sink) 2 clip 3 DC fan (with heat sink) 1 harness Confidential 1-12 PCV-RX9__ Series (AM) -
Page 16: Cpu
• CPU 2 CPU 1 Elect the lever in the direction of arrow A . Note : When heat sink is removed from CPU, install new ones after thermal diffusion grease is wiped off and silicon compound is applied to the place shown in the figure. Thermal diffusion grease : silicon compound (G-765) 90G Amount to apply : 0.5 g (as the same size as the tip of a match) (Pentium 4) -
Page 17: Mother Board
• MOTHER BOARD 1 two screws 1 three screws (SW) (No.6-32UNC) (SW) (No.6-32UNC) 1 three screws (SW) (No.6-32UNC) 5 mother board The cautions when installing the VGA card in the set Before attaching the mother board, the VGA cap is inserted in the IO bracket, and it pushes and fixes by the mother board. -
Page 18: Frame Harness
SECTION 2 FRAME HARNESS • FRAME HARNESS DIAGRAM AND JUMPER SETTING OF MOTHER BOARD Rear i.LINK Rear Panel VGA CARD MONITOR S400 4 pin USB MOUSE MOTHER BOARD (WA) CNX-187 BOARD KEYBOARD CN11 SOCKET P4S533-VL (Front Connector) MONITOR Harness (1394) PRINTER MOTHER BOARD (WA) i. -
Page 19: Repair Parts List
SECTION 3 REPAIR PARTS LIST 3-1. EXPLODED VIEW RX950/RX951 RX991 Confidential PCV-RX9__ Series (AM) -
Page 20: Accessories
3-2. ACCESSORIES 3-3. PARTS LIST NOTE: KETBOARD (1) DC CORD (for PCVA-SP3A) (1) • The parts listed here are for service, and therefore they may be different The components identified by from the parts shown in circuit diagrams or used in the set. mark 0 or dotted line with mark 0 are critical for safety. -
Page 21: Compatible Parts List
3-4. COMPATIBLE PARTS LIST Ref.No. Part No. Description Ref.No. Part No. Description 4-648-912-41 PANEL, LEFT 2 A-8114-081-A CPU (P4/2.66G/6S3) ASSY (S) 4-648-911-41 PANEL, TOP 6-600-192-01 DDR 512MB (HYS64D64320GU-6-B) x2 4-648-911-61 PANEL, TOP 6-600-192-01 DDR 512MB (HYS64D64320GU-6-B) 4-648-910-42 PANEL, LIGHT 6-600-196-01 DDR 512MB (V826664K24SATG-C0) x2 74 A-8110-751-B PANEL ASSY (UPPER) (2BAY) (MS) 6-600-196-01 DDR 512MB (V826664K24SATG-C0) 75 A-8025-918-A PANEL ASSY (LOWER) (U) -
Page 22: Pcv-Rx9
PCV-RX9__ Series (AM) This manual and the constituent data may not be replicated, copied nor reprinted in whole or in part without prior written authorization of Sony Corporation. Sony Corporation English 2004F0500-4 © 2004Sony Corporation – 26 – 9-874-373-04 Published by Sony EMCS VAIO-GSC [C]... - Page 23 Revision History Suffix Contents QM No. Ver. Date First Ver. 1 2003.1.10 Edition Ver. 2 2003.3.13 Model Lineup FIT-D2003_033 QUICK MEMO Ver. 3 2004.1.15 (FIT-D2003_039,FIT-D2003_060) FIT-D2003_201 reflection QUICK MEMO Ver.4 2004.6.21 (FIT-D2003_201,FIT-D2004_092) FIT-D2004_147 reflection < Remarks > [Confidential] PCV-RX9__Series(AM)