Advertisement
Table of Contents
Advertisement
Table of Contents
Related Manuals for Vaillant TURBOmax VUW 242/1E
Summary of Contents for Vaillant TURBOmax VUW 242/1E
- Page 1 .i • ; ~ 57166...
-
Page 2: Guarantee
® Immediate help If your Vaillant boiler develops a fault your first action should be to contact your Installer, as his professional assessment is needed under the terms of our Guarantee. If you are unable to contact your installer, phone Vaillant Service Solutions: 0870 6060 777. -
Page 3: Table Of Contents
Page Guarantee Introduction· Important Notes Initial Checks Before Turning On Domestic Hot Water Operation Heating Operation Indicator Lights . Reset Control Turning the Boiler Off Frost Protection 'are and Maintenance' Function checks Operating Summary .1~. .>... -
Page 4: Introduction
This is quite normal and shows that the boiler is operating correctly. If, after reading these instructions, you have any questions onthe operation of the boiler, please contact either your installer or Vaillant Technical Department. ~ ~ i ;... -
Page 5: Important Notes
, Important notes • Please nate that the TURBOmax must be installed and serviced by a competent person in accordance with the Gas Safety (Installation and Use) Regulations 1994. (In the U.K. "CORGI" registered installers undertake the work to a safe and satisfactory standard). •... -
Page 6: Initial Checks Before Turning On
checks before Initial turning the boiler on Check supply pipes Ensure cold water shut off valve is open (this con be checked by opening hot top and ensuring water flows). Also check that both the flow and return central heating ®... - Page 7 Check water contents Open the lower door by pulling outwards. Check the water contents of the system. The ® white hand on the lower scale of the pressure and temperature gauge should be between 1 and 1.5 bar. j(the hand is below O.B·bar when the system is cold, your installer should be called to refill the system.
-
Page 8: Domestic Hot Water Operation
Domestic .hot water operation Turning on Main On/Off Control With the main aff control in the off position (' 0'), and the central heating .t:" control in the ' position, turn on the electricity supply. Turn main on/off control into the' position, the mains on in~icator will illuminate. - Page 9 Obtaining hot water 'On opening a hot water tap at a supply point (basin, shower, bath, etc.) the boiler will operate automatically to provide hot water. (A short delay may be experienced in obtaining hot water at the tap, depending on the length of pipework and your system layout.
- Page 10 Setting Maximum Domestic Hot Water Control The maximum domestic hot water temperature can be adjusted using the hot water CD.· temperature control Turn the cantrol: Clockwise to Increase (maximum setting Anti-clockwise to Decrease (minimum setting = 1) As a guide, for normal circumstances the maximum hot water temperature should be set to 6 ~:·,:8\ Note: This control adjusts the maximum domestic hot water temperature.
-
Page 11: Heating Operation
Heating operation um,:8 8. 9 Setting the Maximum Radiator Temper'ature Control The maximum radiator temperature control maintains the temperature of water to the central heating circuit at the desired level. This temperature is indicated on the . ® pressure and temperature gauge during heating operation. - Page 12 Setting external controls • <ID Set the room thermostat and/or thermostaticrodiator valves according to the instructions supplied with the control (s). Set the external time control to the desired on and off periods. Note: A room thermostotor room thermostat and therm astatic radiator valves will provide mare accurate and economic control compared ta a heating system without these controls.
- Page 13 Switching on Central Heating Control 'mu: Turn the central heating control position. The boiler will now operate automatically ta provide central heating for the conditions selected on the external controls. (On this setting the TURBOmax will also provide domestic hot water). ®...
-
Page 14: Indicator Lights
Indicator lights illuminates during boiler operation to show that the fan and flue The Vaillant TURBOmax incorporates indicator lights to show the system are functioning correctly. ' operational status of the boiler. When the boiler is operatingcorrectly... - Page 15 nm,:S "'1 (l0'1 ~':8 0/11 86 nm~8...
-
Page 16: Reset Control
If after attempting to light the boiler by turning to the reset position, the ~:··:8 boiler shuts ·,down again or if an indicator light is flashing, consult your service agent or Vaillant Service Solutions. 0"' ~: ,,·:8 ·Note: Particularly when starting up for the first time, or after the boiler has been out of operation for fairly •. -
Page 17: Turning The Boiler Off
boiler off Turning the To turn off the central heating ·only.1 urn the central heating control '.r-' position (Normal position during summer time). To turn off the heating and hot water for short periods of time. 1 the main on/off control to the position. -
Page 18: Are And Maintenance
To ensure regular servicing it is strongly recommended that in the gas or electricity supply or faults in the flue ga~ system. To " arrangements are made with your service' agent or Vaillant Ltd. for a overcome this possibility you can drain" both the central heating" system"... -
Page 19: Function Checks
Check water contents (see page 7) consult your installer. " Check electricity supply is switched on (see page 8) If you ore unable to contact your installer phone Vaillant Service Solutions: Check main on/off control is turned to the on position (0/1) 08706060777. -
Page 20: Operating Summary
Operating summary Cold water shut off valve <IQ) ® Pressure relief valve Heating return service valve Key to Features Water outlet Main on/off control ® Hot water tap Centrol Heating control and lock out reset <ID Room thermostat (if fitted) Maximum Radiator emperoture control Thermostatic rodiator valves (if fitted) . - Page 21 1 ~.