Page 1 MODIFICATION HISTORY MODEL NAME : KDX-46Q005 SERVICE MANUAL PARTS No. : 9-878-325-03 * Blue characters are linking. Ver. DATA CONTENTS 2005. 9 Issued 2005. 12 Addition of REPAIR MANUAL for Centralized Service Center (APPENDIX) 2006. 2 4. EXPLODED VIEWS. Part numbers changed (No.
Page 2: Service Manual
KDX-46Q005 SERVICE MANUAL US Model Canadian Model MBD-Q005 XDM-F4600Q CHASSIS SPECIFICATIONS Panel System LCD Panel Display Resolution 1920 pixels (horizontal) x 1080 pixels (vertical) Antenna 75 ohm external terminal for VHF/UHF Television System NTSC American TV Standard ATSC (8VSB terrestrial)
Page 3 2 supplied for remote control AC Power Cord AC Plug Holder Display Interface Cable Antenna Cable Vertical Installation Stand Vertical Installation Stand Screws 2 Owner’s Guide Quick Setup Guide Warranty Product Registration Card Design and specifications are subject to change without notice. KDX-46Q005 (UC)
Page 4: Warnings And Cautions
Ne les remplacer que par des composants Sony dont le numero de piece est indique dans le present manuel ou dans des supplements publies par Sony. Les reglages de circuit dont l’importance est critique pour la securite du fonctionnement sont identiﬁes dans le present manuel.
Page 5 2. Check the interboard wiring to ensure that no wires are OPERATION. REPLACE THESE COMPONENTS WITH “pinched” or contact high-wattage resistors. SONY PARTS WHOSE PART NUMBERS APPEAR AS 3. Check that all control knobs, shields, covers, ground straps, SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUB- and mounting hardware have been replaced.
Page 6: Table Of Contents
PACKING MATERIALS ........4-12 3. DIAGRAMS 4-3-1. MEDIA RECEIVER UNIT ......4-12 4-3-2. DISPLAY UNIT AND MEDIA 3-1. CIRCUIT BOARDS LOCATION ..... 3-1 RECEIVER UNIT .......... 4-13 3-1-1. DISPLAY UNIT (XDM-F4600Q) ....3-1 3-1-2. MEDIA RECEIVER UNIT (MBD-Q005) ..3-1 KDX-46Q005 (UC)
Page 7: Self Diagnosis Function
• Secondary-side regulator circuit. • PFC converter circuit. • AC-RLY circuit, AC-RYL signal line. • STBY circuit. D OVP 8 times • THRU3.3V circuit. • THRU3.3V, SW_5V, SW_3.3V, SW_2.5V line output (over voltage). PNL ERR 9 times Panel unit. KDX-46Q005 (UC)
Page 8 • PHOTO SENSOR_ERROR: Boards, interface bus, harness disconnection (including communication error). • FAN_ERROR: Fan, fan drive circuit, harness disconnection POWER ERR (PS_PROT) 11 times • P_VCC circuit. • P_VCC (LCD panel power) short-circuit in T-CON board of LCD. KDX-46Q005 (UC) 1-2E...
Page 9: Disassembly
7 Four screws (+FLAT HEAD (M4 GRIP) ) 7 Four screws (+FLAT HEAD (M4 GRIP) ) 8 Rear heatsink assy 2-1-2. SPEAKER REMOVAL 1 Four screws 3 Four screws (+PWH 4x16) (+PWH 4x16) 2 Speaker (R) 4 Speaker (L) KDX-46Q005 (UC)
Page 10: K Board Removal
(+PSW 3x6) (+PSW 4x8) 9 Three screws 3 Stay support assy (+PSW 3x10) 0 Bottom shield (K) 2-1-4. G1B AND G2L BOARDS REMOVAL 3 Four screws (+PSW 3x6) 1 Six screws (+PSW 3x6) 4 G2L board 2 G1B board KDX-46Q005 (UC)
Page 11: F Board Removal
(+PSW 3x6) qa Four screws w; Two screws wd Six screws (+PSW 4x8) (+PSW 4x10) (+PSW 4x10) 8 Bottom shield (DE) wa Earth lead qs Stand holder ws Fan bracket (B) wf One screw (+BVTP 4x12) wg Stay (lower) KDX-46Q005 (UC)
Page 12: Lcd Panel Removal
Earth lead es One screw (+PSW 3x8) eh One screw (+PSW 3x8) ej Earth lead r; Ten screws ra Frame (horizontal) (+BVTP 4x12) rg Frame (vertical) ek One screw (+PSW 3x8) rf Five screws (+BVTP 4x12) el Earth lead KDX-46Q005 (UC)
Page 13: H1D Board Removal
2-1-8. H1D BOARD REMOVAL 1 H1D board 2-1-9. H2D BOARD REMOVAL 1 One screw (+BVTP 3x10) 2 H2D board KDX-46Q005 (UC)
Page 14: Media Receiver Unit (Mbd-Q005)
(GRIP,M2.6 S HEAD EG)) 3 Two screws 4 Four screws (HEX) (+PSW 3X8) 6 Rear panel block assy 5 One screw (+PSW 4X8) 1 Eight screws 4 Four screws (+BVTP 3X12) 7 Two Fan block assy (A) (+PSW 3X8) 8 Fan block assy (B) KDX-46Q005 (UC)
Page 15: Csmu Board Removal
2-2-3. CSMU BOARD REMOVAL 5 Two screws (+RK 3X8) 6 AC inlet 3 Two nuts with washer 4 Antenna switch 1 Two screws (+PSW 3X8) Rear panel 2 CSMU board KDX-46Q005 (UC)
Page 16: Qi, Qmdv And Qt Boards Removal
8 QMDV board 4 Coaxial cable with 6 Coaxial cable with connector (LVDS) connector (LVDS) 5 USB cable 0 Cord with connector qk Four screws (+PSW 3X6) qs QI board ql Bottom ATSC shield (50) qa One screw (+PSW 3X6) KDX-46Q005 (UC)
Page 17: Ddm Block Assy And J1Mu Board Removal
(+PSW 3X5) 4 Two screws 3 One screw (+PSW 3X6) (+PSW 3X10) 9 Four screws (+PSW 3X6) 0 DDM block assy 5 DDM support assy qa J1MU board qs Three screws (+PSW 3X6) qd Base plate assy (A) KDX-46Q005 (UC)
Page 18: Dic3, M1Mu And T1Mj Boards Removal
5 Connector assy (FFC80P) 7 PCMCIA card connector (frame) 4 A1MU board 8 QUMU board 9 Four screws (+PSW 3X6) qs PD board 0 PD shield (top) 3 RF cable qa Four screws (+PSW 3X6) qd PD shield (bottom) KDX-46Q005 (UC) 2-10...
Page 19: Front Block Assy And G1Mu Board Removal
(+PSW 3X6) 3 G1MU board 4 Three screws (+PSW 3X6) 5 Front block assy 2-2-9. H1MU BOARD REMOVAL 3 Four screws (+BVTP 3X12) 4 H1MU board 1 Two screws (+BVTP 3X12) 2 I-LINK cable cover Front block assy KDX-46Q005 (UC) 2-11...
Page 20: Qh Board Removal
2-2-10. QH BOARD REMOVAL 3 Two screws (+BVTP 3X12) 4 QH board Front panel assy 1 Two screws (+BVTP 3X12) 2 HMBF Bracket KDX-46Q005 (UC) 2-12E...
Page 21: Diagrams
F board DE6 board H2D board 3-1-2. MEDIA RECEIVER UNIT (MBD-Q005) PD board QT board T1MJ board A1MU board QMDV board CSMU board G1MU board QUMU board QI board H1MU board J1MU board M1MU board QH board DIC3 board KDX-46Q005 (UC)
Page 22: Block Diagrams
AC_OFF_DET D5109 SWITCHING REG 3.3V_HP G_PROT ERR1 SEL1 OUT1 P_VCC 25-28 IC5909 INV1 PANELON IC5105 INV2 1.8V REG 1.8V_HP POWER OUT2 3.3V REG STBY3.3V ERR3 Q5101 IC8208 +3.3V +1.5V Q5108 1.5V REG D5110 Q8202,8203 LVDS TRANSMITTER, MICRO CONTROLLER KDX-46Q005 (UC)
Page 23: K Board
ERROR(O) RESET X2600 Q2603 24.576MHz CN2600 CKOUT(O) SPDIF- DION(I) IC6101 CN2602 Q6101 Q6102 DE5 BOARD +12V +12V REG AUDIO_VCC CN5105 G2L BOARD CN6207 SUB11V D6101 IC6103 +3.3V +3.3V G2L BOARD CN6206 IC6102 1.8V +1.8V AUDIO PROCESSOR, AUDIO OUTPUT KDX-46Q005 (UC)
Page 24: F And G1B Boards
TH6500 Q6502 PH6501 Q6503 Q6507 PH6500 LATCH Q6504 Q6501 STBY5V Q6500 D6502 D6501 IC6402 PROTECT IC6403 Q6401 VREF Q6403 PFC DRIVE IC6401 DRIVE Q6406 VREF CAOUT Q6402 Q6404 D6402 Q6407,Q6408 RV6400 D6401 LATCH Q6400 Q6405 IC6400 (POWER SUPPLY) KDX-46Q005 (UC)
Page 25: G2L Board
G1B BOARD CN6200 L3001 Q3001 CN6206 L3002 SUB6.5V IC3001 SUB_11V CONVERTER D3006 OUT1 K BOARD CN2600 D3008 INV1 CN6202 Q3004 L3003 Q3002 SUB_11V L3004 BL_ON LC BOARD D3024 PS_PROT OUT2 Q3009 DTC2 INV2 Q3000 PANEL_ON Q3003 (POWER SUPPLY) KDX-46Q005 (UC)
Page 26: Media Receiver Unit (Mbd-Q005)
VIDEO IN TO 2/2 TO 2/2 V2_R RESET PC_L SDA_M PC_L VIDEO TO 2/2 PC_R SCL_M PC_R PD BOARD SW9V ATSC5V ATSC_5V ATSC5V CN9504 D5V(SW_5V) SW5V (MONO) AUDIO A1MU(1/2) J1500 PC IN (VIDEO SW) AUDIO H1MU(1/2) INPUT TERMINAL KDX-46Q005 (UC)
Page 27: A1Mu(2/2) Board
TO 1/2 L701 L702 ATSC9V VOUT VOUT IC009 VOUT IC003 Q008,010 CN004 IC006 VOUT FAN1 DAC0 DRIVE Q700 FAN2,3 OCL+ A1MU(2/2) D007 IC004 Q009,010 FAN_ERR2 IC007 OCL- FAN_ERR3 DAC1 D008 DRIVE AUDIO PROCESSOR FAN_ERR1 SCL_S POWER SUPPLY SDA_S ATSC5V KDX-46Q005 (UC)
Page 28: J1Mu Board
(3) J1MU Board DIC3 BOARD M1MU BOARD CN4000 CN7004 J1MU (RELAY BOARD) A1MU(1/2)BOARD A1MU(1/2)BOARD A1MU(2/2)BOARD CN005 CN003(1/2) CN003(2/2) KDX-46Q005 (UC)
Page 29: Dic3 Board
23-26 MWEB EXTGXBIN7 EXTGXRIN0 29-32, EXTGIN(EXTGXRIN0-7) I_GXRIN 0-7 35-38 Q4009,4012 EXTGXRIN7 CLK_M I2CSSCL2 DAT_M I2CSSDA2 M1MU BOARD M/S_SW GPIO14 CN7553 OSDV_M PC_HPOL GPIO4 PC_VPOL GPIO5 OSDH_M CCPM_MUTE 3.3V GPIO2 I2CMSDA1 DIC3 I2CMSCL1 Q4006, Q4007 (LVDS RECEIVER,FP,CCPX,DRC MF) 3.3V KDX-46Q005 (UC)
Page 30: T1Mj Board
IC9001 3.3V CN9003 STBY 3.3V Q9005 STBY5V 3.3V IC9303 DAC4 SW_5V IC9002 Q9007 RESET Q9006 IC9015 3.3V A1MU(2/2) BOARD SW3.3V CN601 SET_ON 1.8V 1.8V IC9301 Q9008 SET_ON 1.5V 1.5V IC9020 T1MJ SET_ON 3.3V SET_ON_5V 3.3V Q9009 (RECEIVER,TRANSMITTER,PLD) KDX-46Q005 (UC) 3-10...
Page 31: M1Mu And H1Mj(2/2) Boards
O_BUS_SW1 Q7020 CN7002 IC7703 STBY3.3V STBY3.3V MD1.8V TRSTX RESET O_SPWFR_MUTE IC7402 ADC3.3V BUSY3 (NC) SW5V SW3.3V O_OSC X7002 IC7700 10.135MHz I_OSC SCK0 SCLK0 MA1.8V IC7004 IC7001 STBY5V STBY3.3V IO_BDAT IO_BCLK IC7000 Q7019 O_NVM_PR M1MU (MAIN DIN,MPU) STBY2.5V KDX-46Q005 (UC) 3-11...
Page 32: Pd Board
Q9512 54-56 MUTE DSCL1 110-113 TXOUT2+ TX1OUT2+ LEVEL 116-119 C0-C7 SHIFT DSDA1 TXOUT2- TX1OUT2- TXOUT1+ TX1OUT1+ 8,20 DIC3 BOARD 22-24 TXOUT1- TX1OUT1- CN4200 27-28 136-137 TXOUT0+ TX1OUT0+ 140-144 R0-R7 TXOUT0- TX1OUT0- VSYNC HSYNC PWRDOWN ODCK TXCLKIN PD(HDMI) KDX-46Q005 (UC) 3-12...
Page 33: Qi Board
CLK2 AUD_EMPH GPIO_SPARE1 HSDIO_CLK CLK1 SPARE PCM1 DAT1 /RESET_ICES UART1_RX UART1_RX TXD_P43 /RESETARM UART1_TX UART1_TX RXD_P44 IC805 AEMP1 PLL(VCO) IC807 SDRAM APWM DVC_SDRAM_MAO-MA11 VOUT AMCLK44 AKLCK48 DVC_SDRAM_MD0-MD15 X801 27MHz CAS,RAS,WE,CLK 3.3VDD VPWM RESETB /RESET RESET_Z /RESET_ARM RESET_ARMZ KDX-46Q005 (UC) 3-13...
Page 34: Qh And Qmdv (1/2) Boards
/WE,/CAS,CKE /RAS,/CSO ACRESET# RESET_FE ACXTAL_OUT RESET2099 IC7322 SMDATAS HIRQ# DDR SDRAM VCXO_INB HACK QT BOARD D8-D23 VREF TDATA0 FE_SDATA CN7900 A0-A14 TCLKA FE_SCLK /WE,/CAS,CKE TVLDA FE_VAL /RAS,/CSO TSTRTA FE_SYNC I2CA_SDA FE_SDA MEM_VREF VREF I2CA_SCL FE_SCL QMDV(1/2) (AVOUT,POWER,USB,LVDS) KDX-46Q005 (UC) 3-14...
Page 35: Qmdv (2/2) Board
SYNC PCIVREF IC7310 HSDI_1_SYNC GPIOA10 447,508 DAC_REF1.8V AVDDQ 1.8V LDO D2.5V VDDR1 CN7300 IC7309 /RESET_ICES ACDATA_IN1 D1.5V 9,10 VDDC 1.5V REG /RESETARM ACDATA_OUT I2S_WS_IN I2SWS_IN D2.5V BOX_RSTIN I2S_SD_IN I2SSD_IN TV_TXD I2S_SCK_IN I2SSCK_IN TV_RXD A1MU(2/2)BOARD CN605 QMDV(2/2) (AVOUT,POWER,USB,LVDS) KDX-46Q005 (UC) 3-15...
Page 36: Qt And Qumu Boards
CN102 TU_SDA Q7902 MPEG_ERR TU_SDA0 Q7906 TU_SCL AGC_M D7902 TU_SCL0 +3.3V FDC_LOCK 9,10,11 FAT_LOCK D7900 AGC_SW IC7905 CN7902 Q7900 2.5V 1.2V REG D1.2V_DEM IC7901 DC_DC +3.3V +3.3V 3.3V A32V_TU CONVERTER +2.5V 2.5V QMDV(2/2)BOARD CN7307 (TUNER,POD INTERFACE CONTROL) KDX-46Q005 (UC) 3-16...
Page 37: G1Mu Board
CN602 CONVERTER Q6206 CN6402 STBY5V PH6200 P_SW(-) AC_RLY IC6500 PH6500 REC_ON PH6201 A1MU(2/2)BOARD CN606 Q6001 IC6501 Q6002 LATCH IC6201 T6601 D6214 D6604 D6002 TH6601 IC6601 CONVERTER D6603 DRAIN DRAIN D6610 START UP PH6601 G1MU (POWER SUPPY) IC6602 KDX-46Q005 (UC) 3-17...
Page 38: Frame Diagrams
M1_A_1.8V M_A_1.8V DV656_CLK DV656_CLK M1_D_1.8V M_D_1.8V SPARE SPARE TX1OUT3+ ADC_3.3V ADC_3.3V SPARE TX1OUT3- SPARE DGND SPARE TX1CLK+ TX1CLK- TABA (N.C.) TABA (N.C.) TABB (N.C.) TABB (N.C.) DGND CN7313 TX1OUT2+ TX1OUT2- FI-E14S-R1500 DGND TX1OUT1+ TX1OUT1- DGND TX1OUT0+ TX1OUT0- KDX-46Q005 (UC) 3-18E...
Page 39: Exploded Views
• Items marked " * " are not stocked since they are seldom required for routine service. Some delay Les composants identifiés par la marque ! should be anticipated when ordering these items. sont critiques pour la sécurité. Ne les remplacer que par une pièce portant le numéro spécifié. KDX-46Q005 (UC)
Page 40: Display Unit (Xdm-F4600Q)
PART No. DESCRIPTIONRE MARK X-2024-816-2 ASSY, REAR FRAME (L) 2-349-259-23 PLATE, DECORATION X-2024-817-2 ASSY, REAR FRAME (R) * X-2102-960-1 ASSY, REAR HEATSINK 7-682-961-01 SCREW +PSW 4X8 2-583-600-01 SCREW + FLAT HEAD TP 4X12 2-583-599-02 SCREW +FLAT HEAD (M4 GRIP) KDX-46Q005 (UC)
Page 41: Chassis-1
* A-1126-006-A K COMPL 7-685-152-19 SCREW +P 3X25 TYPE2 NON-SLIT 8-835-840-01 MOTOR, DC FAN SFF21A/C-NP 7-682-949-01 SCREW +PSW 3X10 7-682-947-09 SCREW +PSW 3X6 1-825-996-11 SPEAKER (L) 7-682-953-09 SCREW +PSW 3X20 1-825-996-21 SPEAKER (R) 4-302-404-11 TAPPING SCREW (+PWH 4X16) KDX-46Q005 (UC)
Page 42: Chassis-2
SCREW +BVTP 4X12 TYPE2 IT-3 7-682-947-01 SCREW +PSW 3X6 2-349-111-01 PLUG HOLDER A 7-682-951-09 SCREW +PSW 3X14 A-1139-545-A DE6 COMPL 7-685-647-79 SCREW +BVTP 3X10 TYPE2 IT-3 4-635-966-01 SCREW (HEX) 4-662-693-21 SCREW M2.6 S-HEAD EG GRIP 2-349-248-02 BRACKET, CONNECTOR KDX-46Q005 (UC)
Page 43: Bezel Assy And Lcd Panel
* A-1077-245-A H2D MOUNT 7-685-647-79 SCREW +BVTP 3X10 TYPE2 IT-3 1-830-100-11 HARNESS WITH CONNECTOR (LVDS) 7-685-648-79 SCREW +BVTP 3X12 TYPE2 IT-3 1-805-757-21 LCD PANEL (46 INCH WUXGA TFT) A-1152-223-A FRAM (HORIZ UPPER) A-1152-224-A FRAM (HORIZ LOWER) A-1152-225-A FRAM (VERT) KDX-46Q005 (UC)
Page 44: Media Receiver Unit (Mbd-Q005)
SCREW +PSW 3X6 4-227-843-11 SCREW (TP), FLAT HEAD 7-682-947-09 SCREW +PSW 3X6 * 2-595-185-01 LABEL,MODEL NAME 7-682-948-09 SCREW +PSW 3X8 2-189-544-02 PANEL, BOTTOM 2-546-967-01 BASE, FOOT 2-546-968-01 CAP, FOOT X-2050-190-1 COVER, TOP ASSY 2-583-599-11 SCREW +FLAT HEAD (M4 GRIP) KDX-46Q005 (UC)
Page 45: Chassis-1
1-500-511-11 CORE, FERRITE 2-592-236-01 COVER ATSC 7-682-961-01 SCREW +PSW 4X8 2-591-879-02 PANEL(UC), REAR 7-682-948-09 SCREW +PSW 3X8 8-597-906-00 ANTENNA SWITCHE RFD-SA801 7-685-648-79 SCREW +BVTP 3X12 TYPE 2,IT-3 * A-1102-244-A CSMU MOUNT 7-682-348-09 SCREW +RK 3X8 1-787-372-11 D.C. FAN KDX-46Q005 (UC)
Page 46: Chassis-2
* A-1119-820-A ATSC BLOCK ASSY 301, 302, 306 1-829-702-11 COAXIAL CABLE WITH F-PLUG * 1-469-778-11 CLAMP, FERRITE 7-682-947-01 SCREW +PSW 3X6 1-910-017-73 CONNECTOR ASSY (FFC 40P) 1-827-805-31 LEAD WIRE WITH CONNECTOR(LVDS) 1-829-590-31 CABLE, USB 1-827-805-91 LEAD WIRE WITH CONNECTOR(LVDS) 1-500-753-21 CLAMP, FERRITE KDX-46Q005 (UC)
Page 47: Chassis-3
* A-1119-821-A DDM BLOCK ASSY 356, 357 7-682-947-01 SCREW +PSW 3X6 2-345-164-11 WIRE SADDLE 7-682-949-01 SCREW +PSW 3X10 2-187-364-01 EDGE HOLDER * A-1102-246-A J1MU MOUNT 1-829-362-21 LEAD WIRE WITH CONNECTOR(LVDS) 3-669-145-02 SCREW * 4-098-165-01 CLAMPER * 4-662-796-01 CLIP, COACHING * 4-098-147-11 CLAMP KDX-46Q005 (UC)
Page 48: Chassis-4
2-633-087-01 SPACER, HEXAGON (M3) 1-818-485-12 PCMCIA CARD CONNECTOR (FRAME) * A-1110-537-A A1MU COMPL 7-682-947-01 SCREW +PSW 3X6 1-830-534-11 RF CABLE * 1-469-778-11 CLAMP, FERRITE * A-1110-745-A PD MOUNT 1-827-805-91 LEAD WIRE WITH CONNECTOR(LVDS) * A-1149-748-A G1MU COMPL KDX-46Q005 (UC) 4-10...
Page 49: Front Panel Assy
SCREW +BVTP 3X12 TYPE2 IT-3 3-736-779-71 MAGNET 7-685-645-79 SCREW +BVTP 3X6 TYPE2 IT-3 3-703-035-11 SHAFT, LID 3-022-410-01 DAMPER 2-547-269-01 COVER, I-LINK CABLE * 3-919-255-01 HOLDER, PC BOARD * A-1108-107-A QH COMPL * A-1110-739-A H1MU MOUNT 1-481-057-11 CORE, FERRITE (CLAMP FILTER) KDX-46Q005 (UC) 4-11...
Page 50: Packing Materials
4-3. PACKING MATERIALS 4-3-1. MEDIA RECEIVER UNIT REF. No. PART No. DESCRIPTIONRE MARK REF. No. PART No. DESCRIPTIONRE MARK 3-704-353-01 SHEET (STANDARD), PROTECTION * 2-514-637-02 * 2-514-636-02 HOLDER * 2-583-597-01 BOTTOM, SPACER KDX-46Q005 (UC) 4-12...
Page 51: Display Unit And Media Receiver Unit
4-3-2. DISPLAY UNIT AND MEDIA RECEIVER UNIT 576 575 572 573 MBD-Q005 PACKING MATERIALS KDX-46Q005 (UC) 4-13...
Page 52 * 2-514-643-01 BOARD, BOTTOM 1-478-305-11 REMOTE COMMANDER (RM-Y1000) * 3-674-673-01 STOPPER (A) * 2-349-119-01 PLUG HOLDER C * 2-514-641-03 TRAY * 4-102-317-01 BAG, PROTECTION 4-052-345-01 SCREW, (3X8) (+K), TAPPING 4-103-587-01 FOOT (B) 1-469-241-11 CORE, FERRITE (RFC-8 BK) KDX-46Q005 (UC) 4-14E...
Page 53 English Sony EMCS Corporation 2006BL08-Data Made in Japan Ichinomiya TEC 9-878-325-03  2006.2 KDX-46Q005 (UC)
Page 54 KDX-46Q005 REPAIR MANUAL US Model Canadian Model for Centralized Service Center MBD-Q005 XDM-F4600Q Note: This manual includes extractions from the service manuals stored in ESI. For this reason, please note that there are some differences in section names, age numbers, etc. in this manuals.
Page 55 TABLE OF CONTENTS • SELF DIAGNOSIS FUNCTION • DIAGRAMS CIRCUIT BOARD LOCATIONAL (1/6) Display Unit (XDM-F4600Q) Media Receiver Unit (MBD-Q005) BLOCK DIAGRAMS Display Unit (XDM-F4600Q) DE6, H1D and H2D Boards K Board F and G1B Boards G2L Board Media Receiver Unit (MBD-Q005) A1MU(1/2), CSMU and H1MU(1/2) Boards A1MU(2/2) Board J1MU Board...
Page 56 • Secondary-side regulator circuit. • PFC converter circuit. • AC-RLY circuit, AC-RYL signal line. • STBY circuit. • THRU3.3V circuit. D OVP 8 times • THRU3.3V, SW_5V, SW_3.3V, SW_2.5V line output (over voltage). PNL ERR 9 times Panel unit. KDX-46Q005 (UC)
Page 57 • PHOTO SENSOR_ERROR: Boards, interface bus, harness disconnection (including communication error). • FAN_ERROR: Fan, fan drive circuit, harness disconnection POWER ERR (PS_PROT) 11 times • P_VCC circuit. • P_VCC (LCD panel power) short-circuit in T-CON board of LCD. KDX-46Q005 (UC) 1-2E...
Page 58 F board DE6 board H2D board 3-1-2. MEDIA RECEIVER UNIT (MBD-Q005) PD board QT board T1MJ board A1MU board QMDV board CSMU board G1MU board QUMU board QI board H1MU board J1MU board M1MU board QH board DIC3 board KDX-46Q005 (UC)
Page 59 AC_OFF_DET D5109 SWITCHING REG 3.3V_HP G_PROT ERR1 SEL1 OUT1 P_VCC 25-28 IC5909 INV1 PANELON IC5105 INV2 1.8V REG 1.8V_HP POWER OUT2 3.3V REG STBY3.3V ERR3 Q5101 IC8208 +3.3V +1.5V Q5108 1.5V REG D5110 Q8202,8203 LVDS TRANSMITTER, MICRO CONTROLLER KDX-46Q005 (UC)
Page 60 ERROR(O) RESET X2600 Q2603 24.576MHz CN2600 CKOUT(O) SPDIF- DION(I) IC6101 CN2602 Q6101 Q6102 DE5 BOARD +12V +12V REG AUDIO_VCC CN5105 G2L BOARD CN6207 SUB11V D6101 IC6103 +3.3V +3.3V G2L BOARD CN6206 IC6102 1.8V +1.8V AUDIO PROCESSOR, AUDIO OUTPUT KDX-46Q005 (UC)
Page 61 TH6500 Q6502 PH6501 Q6503 Q6507 PH6500 LATCH Q6504 Q6501 STBY5V Q6500 D6502 D6501 IC6402 PROTECT IC6403 Q6401 VREF Q6403 PFC DRIVE IC6401 DRIVE Q6406 VREF CAOUT Q6402 Q6404 D6402 Q6407,Q6408 RV6400 D6401 LATCH Q6400 Q6405 IC6400 (POWER SUPPLY) KDX-46Q005 (UC)
Page 62 G1B BOARD CN6200 L3001 Q3001 CN6206 L3002 SUB6.5V IC3001 SUB_11V CONVERTER D3006 OUT1 K BOARD CN2600 D3008 INV1 CN6202 Q3004 L3003 Q3002 SUB_11V L3004 BL_ON LC BOARD D3024 PS_PROT OUT2 Q3009 DTC2 INV2 Q3000 PANEL_ON Q3003 (POWER SUPPLY) KDX-46Q005 (UC)
Page 63 VIDEO IN TO 2/2 TO 2/2 V2_R RESET PC_L SDA_M PC_L VIDEO TO 2/2 PC_R SCL_M PC_R PD BOARD SW9V ATSC5V ATSC_5V ATSC5V CN9504 D5V(SW_5V) SW5V (MONO) AUDIO A1MU(1/2) J1500 PC IN (VIDEO SW) AUDIO H1MU(1/2) INPUT TERMINAL KDX-46Q005 (UC)
Page 64 TO 1/2 L701 L702 ATSC9V VOUT VOUT IC009 VOUT IC003 Q008,010 CN004 IC006 VOUT FAN1 DAC0 DRIVE Q700 FAN2,3 OCL+ A1MU(2/2) D007 IC004 Q009,010 FAN_ERR2 IC007 OCL- FAN_ERR3 DAC1 D008 DRIVE AUDIO PROCESSOR FAN_ERR1 SCL_S POWER SUPPLY SDA_S ATSC5V KDX-46Q005 (UC)
Page 65 (3) J1MU Board DIC3 BOARD M1MU BOARD CN4000 CN7004 J1MU (RELAY BOARD) A1MU(1/2)BOARD A1MU(1/2)BOARD A1MU(2/2)BOARD CN005 CN003(1/2) CN003(2/2) KDX-46Q005 (UC)
Page 66 23-26 MWEB EXTGXBIN7 EXTGXRIN0 29-32, EXTGIN(EXTGXRIN0-7) I_GXRIN 0-7 35-38 Q4009,4012 EXTGXRIN7 CLK_M I2CSSCL2 DAT_M I2CSSDA2 M1MU BOARD M/S_SW GPIO14 CN7553 OSDV_M PC_HPOL GPIO4 PC_VPOL GPIO5 OSDH_M CCPM_MUTE 3.3V GPIO2 I2CMSDA1 DIC3 I2CMSCL1 Q4006, Q4007 (LVDS RECEIVER,FP,CCPX,DRC MF) 3.3V KDX-46Q005 (UC)
Page 67 IC9001 3.3V CN9003 STBY 3.3V Q9005 STBY5V 3.3V IC9303 DAC4 SW_5V IC9002 Q9007 RESET Q9006 IC9015 3.3V A1MU(2/2) BOARD SW3.3V CN601 SET_ON 1.8V 1.8V IC9301 Q9008 SET_ON 1.5V 1.5V IC9020 T1MJ SET_ON 3.3V SET_ON_5V 3.3V Q9009 (RECEIVER,TRANSMITTER,PLD) KDX-46Q005 (UC) 3-10...
Page 68 O_BUS_SW1 Q7020 CN7002 IC7703 STBY3.3V STBY3.3V MD1.8V TRSTX RESET O_SPWFR_MUTE IC7402 ADC3.3V BUSY3 (NC) SW5V SW3.3V O_OSC X7002 IC7700 10.135MHz I_OSC SCK0 SCLK0 MA1.8V IC7004 IC7001 STBY5V STBY3.3V IO_BDAT IO_BCLK IC7000 Q7019 O_NVM_PR M1MU (MAIN DIN,MPU) STBY2.5V KDX-46Q005 (UC) 3-11...
Page 69 Q9512 54-56 MUTE DSCL1 110-113 TXOUT2+ TX1OUT2+ LEVEL 116-119 C0-C7 SHIFT DSDA1 TXOUT2- TX1OUT2- TXOUT1+ TX1OUT1+ 8,20 DIC3 BOARD 22-24 TXOUT1- TX1OUT1- CN4200 27-28 136-137 TXOUT0+ TX1OUT0+ 140-144 R0-R7 TXOUT0- TX1OUT0- VSYNC HSYNC PWRDOWN ODCK TXCLKIN PD(HDMI) KDX-46Q005 (UC) 3-12...
Page 70 CLK2 AUD_EMPH GPIO_SPARE1 HSDIO_CLK CLK1 SPARE PCM1 DAT1 /RESET_ICES UART1_RX UART1_RX TXD_P43 /RESETARM UART1_TX UART1_TX RXD_P44 IC805 AEMP1 PLL(VCO) IC807 SDRAM APWM DVC_SDRAM_MAO-MA11 VOUT AMCLK44 AKLCK48 DVC_SDRAM_MD0-MD15 X801 27MHz CAS,RAS,WE,CLK 3.3VDD VPWM RESETB /RESET RESET_Z /RESET_ARM RESET_ARMZ KDX-46Q005 (UC) 3-13...
Page 71 /WE,/CAS,CKE /RAS,/CSO ACRESET# RESET_FE ACXTAL_OUT RESET2099 IC7322 SMDATAS HIRQ# DDR SDRAM VCXO_INB HACK QT BOARD D8-D23 VREF TDATA0 FE_SDATA CN7900 A0-A14 TCLKA FE_SCLK /WE,/CAS,CKE TVLDA FE_VAL /RAS,/CSO TSTRTA FE_SYNC I2CA_SDA FE_SDA MEM_VREF VREF I2CA_SCL FE_SCL QMDV(1/2) (AVOUT,POWER,USB,LVDS) KDX-46Q005 (UC) 3-14...
Page 72 SYNC PCIVREF IC7310 HSDI_1_SYNC GPIOA10 447,508 DAC_REF1.8V AVDDQ 1.8V LDO D2.5V VDDR1 CN7300 IC7309 /RESET_ICES ACDATA_IN1 D1.5V 9,10 VDDC 1.5V REG /RESETARM ACDATA_OUT I2S_WS_IN I2SWS_IN D2.5V BOX_RSTIN I2S_SD_IN I2SSD_IN TV_TXD I2S_SCK_IN I2SSCK_IN TV_RXD A1MU(2/2)BOARD CN605 QMDV(2/2) (AVOUT,POWER,USB,LVDS) KDX-46Q005 (UC) 3-15...
Page 73 CN102 TU_SDA Q7902 MPEG_ERR TU_SDA0 Q7906 TU_SCL AGC_M D7902 TU_SCL0 +3.3V FDC_LOCK 9,10,11 FAT_LOCK D7900 AGC_SW IC7905 CN7902 Q7900 2.5V 1.2V REG D1.2V_DEM IC7901 DC_DC +3.3V +3.3V 3.3V A32V_TU CONVERTER +2.5V 2.5V QMDV(2/2)BOARD CN7307 (TUNER,POD INTERFACE CONTROL) KDX-46Q005 (UC) 3-16...
Page 74 CN602 CONVERTER Q6206 CN6402 STBY5V PH6200 P_SW(-) AC_RLY IC6500 PH6500 REC_ON PH6201 A1MU(2/2)BOARD CN606 Q6001 IC6501 Q6002 LATCH IC6201 T6601 D6214 D6604 D6002 TH6601 IC6601 CONVERTER D6603 DRAIN DRAIN D6610 START UP PH6601 G1MU (POWER SUPPY) IC6602 KDX-46Q005 (UC) 3-17...
Page 75 M1_A_1.8V M_A_1.8V DV656_CLK DV656_CLK M1_D_1.8V M_D_1.8V SPARE SPARE TX1OUT3+ ADC_3.3V ADC_3.3V SPARE TX1OUT3- SPARE DGND SPARE TX1CLK+ TX1CLK- TABA (N.C.) TABA (N.C.) TABB (N.C.) TABB (N.C.) DGND CN7313 TX1OUT2+ TX1OUT2- FI-E14S-R1500 DGND TX1OUT1+ TX1OUT1- DGND TX1OUT0+ TX1OUT0- KDX-46Q005 (UC) 3-18...
Page 76: Schematic Diagrams And Printed Wiring Boards
SCHEMATIC DIAGRAMS AND PRINTED WIRING BOARDS Note: Terminal name of semiconductors in silk screen • All capacitors are in µF unless otherwise noted. (pF: µµF) printed circuit ( Capacitors without voltage indication are all 50 V. • Indication of resistance, which does not have one for rating Circuit Device Printed symbol...
Page 77 1-868-046-11 THIS DOCUMENT IS THE PROPRIETARY PROPERTY OF SONY. ITS USE IS AUTHORIZED ONLY FOR RESPONDING TO A REQUEST FOR QUOTATION, OR FOR THE PERFORMANCE OF WORK FOR SONY. ALL QUESTIONS MUST BE REFERRED TO THE LOCAL PURCHASING DEPARTMENT OF SONY.
Page 78 B side B side B side JL5111 JL5112 JL5113 SN74AHC2G66HDCU3 STBY_3.3V IC5104 FB5117 RCLAMP0504F.TCT D5103 SDA2 001:14B;002:10J; 002:11B;002:7C EXT_SDA 002:10K;002:16C; 002:4J BUS_SW0 SCL2 002:7C;002:9B LED_UDM LED_UDP 002:2D EXT_SCL 001:4F;002:16C 001:5F;002:16C R5184 001:14B;002:10K; C5119 002:16C;002:4J; 1/16W 002:9I CHIP R5152 1005 CHIP USB connector CN5102 SSM6N15FU(TE85R)
Page 79 IC5302 IC5302 CXD9816AGG CXD9816AGG OVRED IC5302 CXD9816AGG RB5306 005:2I 3.3V OVRED1[0] AE11 FB5305 OVRED[0] 001:15H JL5385 OVRED1[1] AD12 IFHSYNC IFHSYNC OVRED[1] C5399 001:15G C5334 C5349 C5350 JL5386 RB5322 OVRED1[2] BDDQ[0] RB5326 100p AE12 IFVSYNC IFVSYNC OVRED[2] BDDQ[0] RB5307 6.3V 001:15G R5305 CHIP OVRED2[0] OVRED1[3]...
Page 80 005:16C 005:16E OVBLU OVGRN 005:16F OVRED 3.3V L5405 FL5401 10uH 3.3V C5465 C5464 C5412 C5414 C5416 C5419 C5437 0.01 1000p 100p L5407 10uH FL5402 C5405 C5406 C5420 C5422 1000p 0.01 C5438 100p 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51 OFB1[7] LVDS GND OFB1[8]...
Page 81 SUB6.5V OVGRN PQ1CZ41H2ZPH IC8208 OVGRN1[0-9],OVGRN2[0-9] L8201 003:6C PS8200 4.7uH 2.5A 1.5V JL8207 JL8208 3.3V L8202 L8203 C8233 R8243 10uH 10uH 1000p R8239 1/16W RN-CP 1005 1/16W C8231 R8244 C8235 C8228 CHIP 100p C8230 C8234 R8240 C8232 1/16W C8229 CHIP 3.3V 2012 6.3V 6.3V...
Page 82 DE6 BOARD (A) Text Search CN5407 RB8201 RB8200 RB8205 RB8204 RB8203 RB8202 CN5903 CN5106 RB8208 FL8200 CN5101 C8220 FL8201 C5443 C8204 C5432 L8200 C8202 C5414 C5421 JL8200 C5412 IC8209 C5424 C5419 C5423 C5409 IC8207 C8235 L5901 IC5408 PS5101 C5411 R8225 C5437 C5408 FB8202...
Page 83 DE6 BOARD (B) Text Search C5427 C8223 C8224 C8207 C8236 C5431 C8237 C8203 C8214 R5243 C8226 JL5112 C8216 C8205 Q8201 Q8200 C8212 R8252 FL5401 L5405 C8221 R8230 R8232 R8256 R8208 R5266 C8229 C8232 FL5403 L5404 C8211 R8253 C5147 R8222 C8213 C5124 L5407 C5142...
Page 84 SV-12295(J) THIS DOCUMENT IS THE PROPRIETARY PROPERTY OF SONY. ITS USE IS AUTHORIZED ONLY FOR RESPONDING TO A REQUEST FOR QUOTATION, OR FOR THE PERFORMANCE OF WORK FOR SONY. ALL QUESTIONS MUST BE REFERRED TO THE LOCAL PURCHASING DEPARTMENT OF SONY.
Page 85 L6003 L6005 C6014 R6001 L6002 L6004 FH6001 F6001 FH6002...
Page 87 1-864-481-13 THIS DOCUMENT IS THE PROPRIETARY PROPERTY OF SONY. ITS USE IS AUTHORIZED ONLY FOR RESPONDING TO A REQUEST FOR QUOTATION, OR FOR THE PERFORMANCE OF WORK FOR SONY. ALL QUESTIONS MUST BE REFERRED TO THE LOCAL PURCHASING DEPARTMENT OF SONY.
Page 88 PART NO. THIS DOCUMENT IS THE PROPRIETARY PROPERTY OF SONY. ITS USE IS AUTHORIZED ONLY FOR RESPONDING TO A REQUEST FOR QUOTATION, OR FOR THE PERFORMANCE OF WORK FOR SONY. ALL QUESTIONS MUST BE REFERRED TO THE LOCAL PURCHASING DEPARTMENT OF SONY.
Page 89 IC6203 C6427 C6430 C6507 C6619 CN6200 IC6400 Q6506 Q6209 D6116 R6171 L6600 C6617 R6466 C6426 R6475 R6170 R6281 Q6306 D6211 C6110 R6470 Q6211 R6294 C6250 R6463 C6409 C6401 C6221 R6483 R6293 IC6403 IC6601 R6268 C6423 R6277 IC6200 C6230 C6451 Q6203 R6245 C6422 R6462...
Page 90 R6515 R6427 R6477 R6291 R6460 R6479 R6476 C6509 C6246 Q6210 Q6400 R6428 R6474 R6518 Q6408 Q6100 R6611 R6610 R6609 R6317 Q6507 Q6208 R6478 C6308 R6473 R6236 IC6402 R6516 R6607 R6316 R6244 C6618 R6608 C6508 R6606 C6244 Q6205 R6464 Q6405 R6501 C6228 R6481 R6480...
Page 91 PART NO. THIS DOCUMENT IS THE PROPRIETARY PROPERTY OF SONY. ITS USE IS AUTHORIZED ONLY FOR RESPONDING TO A REQUEST FOR QUOTATION, OR FOR THE PERFORMANCE OF WORK FOR SONY. ALL QUESTIONS MUST BE REFERRED TO THE LOCAL PURCHASING DEPARTMENT OF SONY.
Page 93 R6725 R6819 D6700 R6804 D6702 C6401 R3010 D6710 D6704 R6714 C6705 R6805 C6405 C3034 R6713 C6719 R6718 R6721 R6720 R6722 C6720 C6408 R3091 C6407 R3120...
Page 94 PART NO. THIS DOCUMENT IS THE PROPRIETARY PROPERTY OF SONY. ITS USE IS AUTHORIZED ONLY FOR RESPONDING TO A REQUEST FOR QUOTATION, OR FOR THE PERFORMANCE OF WORK FOR SONY. ALL QUESTIONS MUST BE REFERRED TO THE LOCAL PURCHASING DEPARTMENT OF SONY.
Page 95 CN1002 CN1001 A1003 D1003 A1002 D1002 D1001 A1001...
Page 96 Q1001 Q1004 Q1002 Q1005 R1012 C1014 R1003 R1004 C1012 R1005 R1011 C1011...
Page 97 PART NO. THIS DOCUMENT IS THE PROPRIETARY PROPERTY OF SONY. ITS USE IS AUTHORIZED ONLY FOR RESPONDING TO A REQUEST FOR QUOTATION, OR FOR THE PERFORMANCE OF WORK FOR SONY. ALL QUESTIONS MUST BE REFERRED TO THE LOCAL PURCHASING DEPARTMENT OF SONY.
Page 100 RN-CP THIS DOCUMENT IS THE PROPRIETARY PROPERTY OF SONY. ITS USE IS AUTHORIZED ONLY FOR RESPONDING TO A REQUEST FOR QUOTATION, OR FOR THE PERFORMANCE OF WORK FOR SONY. ALL QUESTIONS MUST BE REFERRED TO THE LOCAL PURCHASING DEPARTMENT OF SONY.
Page 102 R6108 R6103 R6220 R6222 R6221 R6223 R6122 R6224 R2817 C2734 R2816 C2736 R2625 D2617 C2758 R2763 R2728 R6209 D2616 C2716 R2734 R2746 C2724 R2747 R2735 R2745 C2735 R2793 C2725 C2714 R2744 C2728 C2713 R2610 C2762 R2607 R2697 C2764 R6210 C2751 C2750 C2658 R2784...
Page 103 PART NO. THIS DOCUMENT IS THE PROPRIETARY PROPERTY OF SONY. ITS USE IS AUTHORIZED ONLY FOR RESPONDING TO A REQUEST FOR QUOTATION, OR FOR THE PERFORMANCE OF WORK FOR SONY. ALL QUESTIONS MUST BE REFERRED TO THE LOCAL PURCHASING DEPARTMENT OF SONY.
Page 104 HDMI CN101 TO PD BOARD JL103 SUB-TUNER JL136 R100 R106 FL100 R323 SW_9V 1/10W 1/10W 1/10W VDR102 VDR108 JL135 JL133 JL134 BTF-PA403Z JL104 R101 R107 R324 TU100 1/10W 1/10W 1/10W HDMI_RST VDR103 VDR109 R209 R211 R217 001:7J 1/10W JL105 COMP 1 C211 R102 A_5V...
Page 105 C456 220p 1608 R480 3.3k 1/10W R474 RN-CP 4.7k C459 R487 1/10W RN-CP 1/10W RN-CP SW_9V C468 L403 1608 IC409 NJM4558V-TE2 R466 4.7k 1/10W RN-CP L404 C430 10uH R475 4.7k R489 1/10W RN-CP R444 1/10W C452 R484 RN-CP 3.3k 1/10W 1/10W RN-CP R448...
Page 106 SUB_11V L700 10uH C700 C701 R726 R724 R722 1/10W 1/10W 1/10W RN-CP RN-CP RN-CP GND_2 GND_2 0.5% 0.5% R716 CHIP R727 C706 100k C708 1000p 1/10W C703 RN-CP TO:QM 001:6J 1608 JL623 1608 IFP_H IFP_H 1608 R717 001:6J JL624 CHIP IFP_V IFP_V R683...
Page 107 CN606 CN603 R682 R686 C660 R701 A600 CN605 CN001 FL605 CN003 CN005 FB601 R086 R087 CN601 D009 A601 C659 C662 TP600 C003 C011 CN602 C654 C004 R709 L602 L701 FB101 FB102 L607 C020 C019 C601 PS600 C007 L005 R667 C022 L702 R675 C647...
Page 108 R690 R702 R678 R680 R681 Q003 R007 D001 Q004 R712 R019 R016 Q001 R013 Q006 C655 R038 R037 FB100 D704 R617 D601 R040 R039 D702 R070 Q602 R723 C023 R618 R628 D703 R616 R672 R072 R067 R635 C626 R638 R715 C014 R043 R058...
Page 109 PART NO. THIS DOCUMENT IS THE PROPRIETARY PROPERTY OF SONY. ITS USE IS AUTHORIZED ONLY FOR RESPONDING TO A REQUEST FOR QUOTATION, OR FOR THE PERFORMANCE OF WORK FOR SONY. ALL QUESTIONS MUST BE REFERRED TO THE LOCAL PURCHASING DEPARTMENT OF SONY.
Page 110 A1802 CN1800 VD1806 D1800 J1800 D1801 VD1807 A1801 J1801...
Page 112 PART NO. THIS DOCUMENT IS THE PROPRIETARY PROPERTY OF SONY. ITS USE IS AUTHORIZED ONLY FOR RESPONDING TO A REQUEST FOR QUOTATION, OR FOR THE PERFORMANCE OF WORK FOR SONY. ALL QUESTIONS MUST BE REFERRED TO THE LOCAL PURCHASING DEPARTMENT OF SONY.
Page 113 RB4226 RB4225 RB4224 2004/12/14 13:13 [ MODEL ] 3.3V Others Others C4231 C4232 C4233 C4234 R4250 C4201 R4228 001:11I;001:13C; L4202 1/16W 001:3B;005:8B 6.3V 1005 CHIP 2012 I2CMSCL1 CLK_W R4252 C4202 I2CMSDA1 DAT_W 1005 R4251 6.3V 001:11I;001:13C; 1/16W 2012 R4253 001:3B;005:12E CHIP 3.3V C4203...
Page 114 C4327 R4319 4.7k 1/16W 3.3V 1MAIN_CCPYUV 1005 RN-CP SDRAM DAAVD_M 003:12B;003:13E; 004:1B;005:2B R4317 FL4302 003:2J;003:8L 1/16W JL4301 RN-CP IC4304 L4313 R4434 R4312 IC4301 C4372 MT48LC4M16A2P-75-Y14W-G R4318 C4365 4.7k PQ070XZ01ZPH 1/16W CHIP CHIP 1/16W RN-CP RB4300 RB4301 RB4302 RB4303 1005 MAIN_D2IN C4378 DQ15 2.5V...
Page 115 3.3V CHIP 003:1A;005:2B R4570 3.3V 1MAIN_CCPYUV 1005 1005 1005 1005 1005 1005 1005 10uH 1005 1005 1005 L4503 0.01 0.01 0.01 1005 0.01 0.01 0.01 0.01 C4522 0.01 10uH C4514 C4519 1005 0.01 C4511 C4512 C4513 C4516 C4521 C4526 C4531 L4501 C4581 0.01...
Page 116 3.3V 1.2V 002:9I IFPOUT2 FB4607 C4712 005:10B 005:6B R4612 L4602 X4601 L4600 FB4610 2.5V 10uH 005:11G TMC1 R4671 CHIP FL4603 R4670 006:2B A{21:0} CONT 005:8J TMC2 006:2B D{7:0} 3.3V CONT C4682 XDRC 004:14G C4693 RB4600 006:1D DDRIF C4658 R4619 1.2V R4613 C4660 FB4602...
Page 117 3.3V 1.25V C4835 C4836 C4837 FB4800 R4837 CHIP 1005 1005 1005 1.25V REG D{7:0} A{21:0} 005:2A 005:2A 1.25V 2.5V 3.3V IC4803 IC4801 MAX1809EEE+TG068 C4874 RB4804 A17_F A17_F MBM29DL32TF70TN-WE1 6.3V R4831 R4809 C4880 C4881 C4882 A16_F A16_F C4838 C4839 C4879 FB4808 FB4809 1/16W 0.01...
Page 118 Others Others C4041 CN4200 FB4014 FB4015 1005 IC4004 SN74LVC1G32DCKR C4201 IC4200 THC63LVD104 6.3V IC4201 THC63LVD104 2012 IC4202 PST3629NR C4202 L4200 10uH L4201 10uH 6.3V Q4200 DTC114TUA-T106 2012 R4036 C4203 1005 R4037 1005 C4204 1005 R4074 1005 1005 C4205 0.01 R4136 1005 1005 R4137...
Page 119 DIC3 BOARD (A) Text Search R4842 R4840 JL4802 R4843 R4839 CN4800 R4818 JL4801 JL4606 JL4804 CN4202 R4817 R4816 FB4800 R4815 R4846 R4808 IC4801 JL4605 RB4605 C4800 RB4242 RB4243 RB4244 R4807 IC4609 R4814 R4838 JL4607 R4813 R4841 JL4800 JL4803 RB4813 RB4806 RB4804 R4812 RB4201...
Page 120 DIC3 BOARD (B) Text Search R4122 R4119 R4128 R4125 C4027 C4030 C4029 C4032 C4031 L4007 L4006 L4009 L4008 D4601 C4230 R4124 R4121 R4130 R4127 R4719 R4123 R4120 R4129 R4126 IC4202 C4212 R4132 R4131 R4134 R4133 Q4601 C4211 C4210 R4246 R4227 C4707 C4218 C4209...
Page 121 *-11 THIS DOCUMENT IS THE PROPRIETARY PROPERTY OF SONY. ITS USE IS AUTHORIZED ONLY FOR RESPONDING TO A REQUEST FOR QUOTATION, OR FOR THE PERFORMANCE OF WORK FOR SONY. ALL QUESTIONS MUST BE REFERRED TO THE LOCAL PURCHASING DEPARTMENT OF SONY.
Page 122 R6234 R6006 C6426 IC6201 VD6001 R6238 IC6200 RY6000 C6108 R6204 C6212 C6002 D6202 D6203 D6207 R6218 D6206 C6008 Q6204 D6209 A6007 R6113 R6117 Q6500 L6003 D6208 D6100 C6009 C6214 Q6205 A6008 A6006 C6103 R6124 Q6100 D6102 R6250 SG6002 IC6501 C6250 R6115 FB6201 D6505...
Page 123 R6229 R6229 R6232 R6232 C6223 C6223 Q6000 Q6000 R6215 R6215 R6236 R6236 C6221 C6221 C6210 C6210 R6413 R6413 R6417 R6417 R6121 R6121 R6251 R6251 Q6501 Q6501 R6120 R6120 C6251 C6251 IC6100 IC6100 C6100 C6100 R6100 R6100 C6114 C6114 C6509 C6509 R6527 R6527 R6412...
Page 124 *-11 THIS DOCUMENT IS THE PROPRIETARY PROPERTY OF SONY. ITS USE IS AUTHORIZED ONLY FOR RESPONDING TO A REQUEST FOR QUOTATION, OR FOR THE PERFORMANCE OF WORK FOR SONY. ALL QUESTIONS MUST BE REFERRED TO THE LOCAL PURCHASING DEPARTMENT OF SONY.
Page 125 D1511 D1512 D1510 C1506 S1515 C1526 R1538 R1533 R1529 D1505 D1504 R1594 C1508 Q1502 C1512 R1540 R1536 Q1507 R1606 R1605 R1599 R1603 R1601 R1602 R1604 R1600 C1528 VD1511 A1500 CN1500 CN1505 R1543 IC1500 C1505 PS1500 C1520 R1577 R1582 R1528 R1578 R1580 R1511 R1509...
Page 127 PART NO. THIS DOCUMENT IS THE PROPRIETARY PROPERTY OF SONY. ITS USE IS AUTHORIZED ONLY FOR RESPONDING TO A REQUEST FOR QUOTATION, OR FOR THE PERFORMANCE OF WORK FOR SONY. ALL QUESTIONS MUST BE REFERRED TO THE LOCAL PURCHASING DEPARTMENT OF SONY.
Page 130 0-000-000-00 THIS DOCUMENT IS THE PROPRIETARY PROPERTY OF SONY. ITS USE IS AUTHORIZED ONLY FOR RESPONDING TO A REQUEST FOR QUOTATION, OR FOR THE PERFORMANCE OF WORK FOR SONY. ALL QUESTIONS MUST BE REFERRED TO THE LOCAL PURCHASING DEPARTMENT OF SONY.
Page 131 PQ070XZ01ZPH SW_5V IC7402 ADC_3.3V FB7411 ANALOG PC INPUT R7498 CN7400 R7496 R7425 C7419 R7421 JL7403 1/16W RN-CP 1/10W 1/10W RN-CP R7499 RN-CP SW_3.3V R7497 2012 1/16W 1/16W PC_R RN-CP CHIP D7405 R7500 HN1D03FU-TE85R L7400 1.2k JL7404 1/16W PC_G RN-CP C7447 R7422 R7426 C7420...
Page 132 CN7552 R7582 0 CHIP I_IFPVSOUT R7581 0 CHIP I_IGXHSOUT I_IGXCKOUT R7580 10 CHIP IPC_BE7 IPC_BE6 OPC_CK IPC_BE5 O_GXYCCKIN RB7563 OPC_HS IPC_BE4 O_GXYCHSIN OPC_VS IPC_BE3 O_GXYCVSIN COAST IPC_BE2 I_PCCOSOUT IPC_BE1 OGPX_B7 RB7564 SW_3.3V OSD_B7 OGPX_B7 RB7576 IGPX0_B7 IPC_BE0 OGPX_B6 OSD_B6 RB7550 IGPX1_B7 OGPX_B6 OPC_GE0...
Page 133 003:4F SW_3.3V R7657 1/16W CHIP L7650 10uH R7656 1/16W CHIP C7654 6.3V C7658 C7662 1005 FB7650 FB7651 FB7652 C7655 6.3V C7659 0.01 1608 1005 1005 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 C7661 R7650 C7650...
Page 134 I2C_3.3 001:17J SW_3.3V DAAVD_S R7723 R7725 R7719 1/16W 4.7k 005:13E;005:3K; RN-CP 1/16W 005:9L RN-CP 1/16W CHIP R7724 4.7k L7950 M_A_1.8V 1/16W 10uH RN-CP C7732 C7733 JL7700 R7954 FB7950 1005 1005 CHIP CONT RB7718 S_D1B0 C7954 R7958 C7957 S_D1B1 0.01 X7950 79.99188313MHz 1/16W CHIP...
Page 135 M1MU BOARD (A) Text Search R7781 R7775 L7700 Q7713 Q7708 L7701 C7714 CN7553 CN7552 L7703 JL7554 JL7552 Q7408 Q7406 R7244 R7243 R7415 C7568 C7700 Q7415 RB7403 RB7402 RB7401 RB7400 C7468 R7462 C7459 C7731 C7702 C7706 C7458 R7731 R7710 R7737 C7457 IC7701 R7738 R7473...
Page 136 M1MU BOARD (B) Text Search R7758 R7586 R7762 R7753 FL7700 C7756 Q7413 L7709 C7965 RB7702 RB7703 RB7700 RB7701 R7432 R7804 R7429 Q7414 R7817 R7764 R7798 C7763 R7828 R7824 R7448 R7794 R7790 R7816 R7822 C7747 C7737 C7746 C7745 C7768 R7410 C7773 C7736 R7428 C7769...
Page 137 THIS DOCUMENT IS THE PROPRIETARY PROPERTY OF SONY. ITS USE IS AU THORIZE0 ONLY FOR RESPONDING TO A REQUEST FOR QUOTATION, OR FOR THE PERFORMANCE OF WORK FOR SONY. ALL QUESTIONS MUST BE REFERRED TO THE LOCAL PURCHASING DEPARTMENT OF SONY. ISSUED...
Page 139 CN9502 R9623 R9575 C9825 R9723 R9595 R9624 C9824 R9724 R9506 R9552 C9826 R9625 R9611 R9560 R9564 R9566 C9836 C9601 FB9509 R9572 IC9501 C9600 C9831 C9545 C9513 C9517 R9578 R9535 R9547 R9626 C9637 C9537 R9803 C9853 C9648 R9520 R9519 C9852 C9635 R9521 R9509 R9508...
Page 140 THIS DOCUMENT IS THE PROPRIETARY PROPERTY OF SONY. ITS USE IS AUTHORIZED ONLY FOR RESPONDING TO A REQUEST FOR QUOTATION, OR FOR THE PERFORMANCE OF WORK FOR SONY. ALL QUESTIONS MUST BE RE FERRED TO THE LOCAL PURCHASING DEPARTMENT OF SONY.
Page 141 FB7203 IC7202 R7223 CN7206 R7208 CN7205 CN7202...
Page 142 R7227 C7226 R7233 C7224 R7222 R7234 R7202 C7222 R7209 R7211 R7215 C7223 R7232 Q7202 Q7201 C7214 R7229 C7218 C7225 R7218 R7216 D7201 R7221 R7204 R7205 D7212 C7213 C7220 C7221 CN7207 IC7201 CN7201...
Page 143 THIS DOCUMENT IS THE PROPRIETARY PROPERTY OF SONY. ITS USE IS AU THORIZE0 ONLY FOR RESPONDING TO A REQUEST FOR QUOTATION, OR FOR THE PERFORMANCE OF WORK FOR SONY. ALL QUESTIONS MUST BE REFERRED TO THE LOCAL PURCHASING DEPARTMENT OF SONY. ISSUED...
Page 144 SDRAM PINS: 1, 3, 9, 14, 27, 43, 49 3.3VDD C702 C703 C704 C705 C706 C707 C708 F:1608 F:1608 F:1608 F:1608 F:1608 F:1608 F:1608 IC601(5/7) CXD9740AZ EXT_MEM_DATA15 EXT_MEM_DATA15 EXT_MEM_DATA14 EXT_MEM_DATA14 3.3VDD EXT_MEM_DATA13 EXT_MEM_DATA13 EXT_MEM_DATA12 EXT_MEM_DATA12 EXT_MEM_DATA11 PLACE CLOSE TO SDRAM EXT_MEM_DATA11 EXT_MEM_DATA10 EXT_MEM_DATA10...
Page 145 Keep VCO close to DV CODEC Noise sensitive! 3.3VDD 3.3VDD L801 DV CODEC PINS: 5, 31, 52, 63, 78, 95, 127, 140, 166, 187 DV CODEC PINS: 14, 67, 118, 170, 198, 199 2.2µH C832 FB801 1000p IC805 C823 3.3VDD 2.5VDD 0.001 BU2374FV...
Page 148 THIS DOCUMENT IS THE PROPRIETARY PROPERTY OF SONY. ITS USE IS AU THORIZE0 ONLY FOR RESPONDING TO A REQUEST FOR QUOTATION, OR FOR THE PERFORMANCE OF WORK FOR SONY. ALL QUESTIONS MUST BE REFERRED TO THE LOCAL PURCHASING DEPARTMENT OF SONY. ISSUED...
Page 149 THIS DOCUMENT IS THE PROPRIETARY PROPERTY OF SONY. ITS USE IS AU THORIZE0 ONLY FOR RESPONDING TO A REQUEST FOR QUOTATION, OR FOR THE PERFORMANCE OF WORK FOR SONY. ALL QUESTIONS MUST BE REFERRED TO THE LOCAL PURCHASING DEPARTMENT OF SONY. ISSUED...
Page 150 THIS DOCUMENT IS THE PROPRIETARY PROPERTY OF SONY. ITS USE IS AU THORIZE0 ONLY FOR RESPONDING TO A REQUEST FOR QUOTATION, OR FOR THE PERFORMANCE OF WORK FOR SONY. ALL QUESTIONS MUST BE REFERRED TO THE LOCAL PURCHASING DEPARTMENT OF SONY. ISSUED...
Page 151 THIS DOCUMENT IS THE PROPRIETARY PROPERTY OF SONY. ITS USE IS AU THORIZE0 ONLY FOR RESPONDING TO A REQUEST FOR QUOTATION, OR FOR THE PERFORMANCE OF WORK FOR SONY. ALL QUESTIONS MUST BE REFERRED TO THE LOCAL PURCHASING DEPARTMENT OF SONY. ISSUED...
Page 152 THIS DOCUMENT IS THE PROPRIETARY PROPERTY OF SONY. ITS USE IS AU THORIZE0 ONLY FOR RESPONDING TO A REQUEST FOR QUOTATION, OR FOR THE PERFORMANCE OF WORK FOR SONY. ALL QUESTIONS MUST BE REFERRED TO THE LOCAL PURCHASING DEPARTMENT OF SONY. ISSUED...
Page 155 THIS DOCUMENT IS THE PROPRIETARY PROPERTY OF SONY. ITS USE IS AU THORIZE0 ONLY FOR RESPONDING TO A REQUEST FOR QUOTATION, OR FOR THE PERFORMANCE OF WORK FOR SONY. ALL QUESTIONS MUST BE REFERRED TO THE LOCAL PURCHASING DEPARTMENT OF SONY. ISSUED...
Page 156 Place close to IC7900 pins 20, 45, 64, 84 3.3V C7905 C7906 C7907 C7908 F:CHIP F:CHIP F:CHIP F:CHIP FE-TS CN7903(1/2) 80-PIN FFC V-TYPE T-D 141001180W 80PIN_FFC/FPC_CN RB7903 3.3V TO_PCMCIA_CARD PODVCC R7997 1/10W :CHIP R7919 1.0k 3.3V 1/10W RB7904 CD1# :CHIP JL7953 MDO3 R7989...
Page 159 PART NO. THIS DOCUMENT IS THE PROPRIETARY PROPERTY OF SONY. ITS USE IS AUTHORIZED ONLY FOR RESPONDING TO A REQUEST FOR QUOTATION, OR FOR THE PERFORMANCE OF WORK FOR SONY. ALL QUESTIONS MUST BE REFERRED TO THE LOCAL PURCHASING DEPARTMENT OF SONY.
Page 160 CN5553 C5551 CN5552...
Page 162 PART NO. THIS DOCUMENT IS THE PROPRIETARY PROPERTY OF SONY. ITS USE IS AUTHORIZED ONLY FOR RESPONDING TO A REQUEST FOR QUOTATION, OR FOR THE PERFORMANCE OF WORK FOR SONY. ALL QUESTIONS MUST BE REFERRED TO THE LOCAL PURCHASING DEPARTMENT OF SONY.
Page 163 R9172 CN9005 C9116 TO PANEL MDR_SCL FIELD_DET MDR_SDA CH_STATUS SET_ON SET_ON POWER_ON BINT BINT CABLE_DET STBY3.3V SIRCS+ R9057 RESERVE1 SPDIF+ SIRCS- SPDIF- STBY3.3V L9007 SIRCS+ SPDIF+ SIRCS- RESERVE2 SET_ON_3.3V SET_ON_3.3V D9007 R9066 VOL_DET1 R9058 HN1D03FU-TE85R 1/16W C9040 IC9012 IC9013 CHIP STBY3.3V SPDIF- 0.01...
Page 164 SET_ON_3.3V FB9302 C9317 C9315 6.3V SET_ON_3.3V R9317 1608 JL9305 C9301 ASDIO JL9306 FB9300 R9318 1608 JL9307 R9319 XX DATA0 JL9308 C9300 R9320 XX CHIP 6.3V CHIP 1/16W JL9309 1/16W R9321 XX NCONFIG R9304 JL9310 FB9304 R9300 3.3V R9313 R9310 1/16W CONF_DONE EPCS1SI8-T1 1/16W...
Page 165 SET_ON_3.3V SET_ON_3.3V SET_ON_3.3V SET_ON_1.8V L9011 10uH L9012 L9013 L9014 10uH 10uH 10uH FB9016 C9154 C9155 C9156 FB9017 FB9018 FB9019 1005 1005 C9153 1005 1005 C9092 C9093 C9100 C9101 C9106 C9107 C9109 C9111 6.3V 6.3V 6.3V 6.3V 1608 1608 1608 1608 CSDA CSCL C9094...
Page 166 C9119 R9175 IC9023 R9161 R9162 C9337 CN9300 FB9309 R9169 X9301 C9335 L9301 FB9310 C9336 D9013 R9164 R9165 C9054 R9310 R9313 R9349 R9300 C9053 R9190 R9358 RB9300 RB9301 R9021 IC9021 R9189 R9234 IC9300 L9010 R9348 R9163 R9158 PS9000 FB9002 R9304 R9181 L9003 R9182 R9183...
Page 168: Electrical Parts List
Les composants identifiés par la marque ! • F : nonflammable sont critiques pour la sécurité. Ne les remplacer que par une pièce portant le numéro spécifié. When indicating parts by reference number, please include the board name. KDX-46Q005 (UC)
Page 169 100UF CAPACITOR C6306 1-162-970-11 CERAMIC CHIP 0.01UF 10.00% 25V CAPACITOR C6307 1-162-970-11 CERAMIC CHIP 0.01UF 10.00% 25V CAPACITOR C6400 1-104-760-11 CERAMIC CHIP 0.047UF 10.00% 50V CAPACITOR C6401 1-107-903-11 ELECT 2.2UF CAPACITOR C6403 1-115-339-11 CERAMIC CHIP 0.1UF 10.00% 50V KDX-46Q005 (UC)
Page 170 8-719-081-97 DIODE MMDL914T1 DIODE D6116 8-719-081-97 DIODE MMDL914T1 DIODE D6119 8-719-081-97 DIODE MMDL914T1 DIODE D6200 8-719-304-63 DIODE RM11C DIODE D6201 8-719-054-89 DIODE D15XB60 DIODE D6202 8-719-304-63 DIODE RM11C DIODE D6203 8-719-041-97 DIODE MA113-(TX) DIODE D6204 8-719-041-97 DIODE MA113-(TX) KDX-46Q005 (UC)
Page 171 PHOTO COUPLER PH6301 6-600-187-01 PHOTO COUPLER PC123Y22JOOF PHOTO COUPLER PH6500 6-600-187-01 PHOTO COUPLER PC123Y22JOOF PHOTO COUPLER PH6501 6-600-187-01 PHOTO COUPLER PC123Y22JOOF PHOTO COUPLER PH6600 6-600-187-01 PHOTO COUPLER PC123Y22JOOF TRANSISTOR Q6100 8-729-023-22 TRANSISTOR 2SD2114K TRANSISTOR Q6200 6-550-372-01 TRANSISTOR SPA20N60C3E8152 KDX-46Q005 (UC)
Page 172 1-218-877-11 METAL CHIP 18K 0.5% 1/10W RESISTOR R6231 1-208-830-11 METAL CHIP 100K 0.5% 1/10W RESISTOR R6232 1-208-830-11 METAL CHIP 100K 0.5% 1/10W RESISTOR R6233 1-208-830-11 METAL CHIP 100K 0.5% 1/10W RESISTOR R6234 1-216-825-11 METAL CHIP 2.2K 5% 1/10W KDX-46Q005 (UC)
Page 173 1-216-833-11 METAL CHIP 10K 5% 1/10W RESISTOR R6308 1-216-833-11 METAL CHIP 10K 5% 1/10W RESISTOR R6309 1-216-841-11 METAL CHIP 47K 5% 1/10W RESISTOR R6310 1-216-833-11 METAL CHIP 10K 5% 1/10W RESISTOR R6311 1-216-841-11 METAL CHIP 47K 5% 1/10W KDX-46Q005 (UC)
Page 174 RESISTOR R6450 1-216-833-11 METAL CHIP 10K 5% 1/10W RESISTOR R6451 1-216-821-11 METAL CHIP 1/10W RESISTOR R6452 1-216-841-11 METAL CHIP 47K 5% 1/10W RESISTOR R6453 1-216-833-11 METAL CHIP 10K 5% 1/10W RESISTOR R6454 1-216-833-11 METAL CHIP 10K 5% 1/10W KDX-46Q005 (UC)
Page 175 1-208-830-11 METAL CHIP 100K 0.5% 1/10W RESISTOR R6527 1-208-830-11 METAL CHIP 100K 0.5% 1/10W RESISTOR R6528 1-208-830-11 METAL CHIP 100K 0.5% 1/10W RESISTOR R6529 1-208-830-11 METAL CHIP 100K 0.5% 1/10W RESISTOR R6530 1-208-828-11 METAL CHIP 82K 0.5% 1/10W KDX-46Q005 (UC)
Page 176 CAPACITOR C3062 1-107-823-11 CERAMIC CHIP 0.47UF 10.00% 16V CAPACITOR C6470 1-162-970-11 CERAMIC CHIP 0.01UF 10.00% 25V CAPACITOR C6471 1-162-970-11 CERAMIC CHIP 0.01UF 10.00% 25V CAPACITOR C6700 1-137-639-21 MYLAR 0.47UF 450V CAPACITOR C6701 1-162-970-11 CERAMIC CHIP 0.01UF 10.00% 25V KDX-46Q005 (UC)
Page 177 IC BD9851EFV-E2 IC3004 6-706-862-01 IC NJM2387DL2-TE1 IC3005 8-759-581-11 IC NJM2125F(TE2) IC6700 6-706-852-01 IC CXD9841M IC6800 8-759-682-42 IC MM1431ATT COIL L3000 1-424-922-21 INDUCTOR 10UH COIL L3001 1-456-857-11 INDUCTOR 10UH COIL L3002 1-456-857-11 INDUCTOR 10UH COIL L3003 1-456-857-11 INDUCTOR 10UH KDX-46Q005 (UC) 6-10...
Page 178 SHORT CHIP RESISTOR R6475 1-216-829-11 METAL CHIP 4.7K 5% 1/10W RESISTOR R6476 1-216-821-11 METAL CHIP 1/10W RESISTOR R6477 1-216-837-11 METAL CHIP 22K 5% 1/10W RESISTOR R6478 1-216-864-11 SHORT CHIP RESISTOR R6480 1-216-833-11 METAL CHIP 10K 5% 1/10W KDX-46Q005 (UC) 6-11...
Page 179 10.00% 25V CAPACITOR C2645 1-126-205-11 ELECT CHIP 47UF 20.00% 6.3V CAPACITOR C2646 1-162-923-11 CERAMIC CHIP 47PF 5.00% 50V CAPACITOR C2647 1-125-827-91 CERAMIC CHIP 1UF 10.00% 25V CAPACITOR C2648 1-128-643-11 CERAMIC CHIP 4.7UF CAPACITOR C2649 1-128-643-11 CERAMIC CHIP 4.7UF KDX-46Q005 (UC) 6-12...
Page 180 CERAMIC CHIP 0.1UF 10.00% 16V CAPACITOR C2727 1-107-826-11 CERAMIC CHIP 0.1UF 10.00% 16V CAPACITOR C2728 1-125-827-91 CERAMIC CHIP 1UF 10.00% 25V CAPACITOR C2729 1-162-923-11 CERAMIC CHIP 47PF 5.00% 50V CAPACITOR C2730 1-100-566-91 CERAMIC CHIP 0.1UF 10.00% 25V KDX-46Q005 (UC) 6-13...
Page 181 TERMINAL BOARD EB2600 1-537-771-21 TERMINAL BOARD, GROUND FERRITE BEAD FB2600 1-414-228-11 FERRITE FERRITE BEAD FB2601 1-414-228-11 FERRITE FERRITE BEAD FB2602 1-414-228-11 FERRITE FERRITE BEAD FB2603 1-414-228-11 FERRITE FERRITE BEAD FB2604 1-414-228-11 FERRITE FERRITE BEAD FB2605 1-414-228-11 FERRITE KDX-46Q005 (UC) 6-14...
Page 182 1/10W 1033 RESISTOR R2624 1-216-809-11 METAL CHIP 100 5% 1/10W 1034 RESISTOR R2625 1-216-833-11 METAL CHIP 10K 5% 1/10W 1035 RESISTOR R2626 1-216-809-11 METAL CHIP 100 5% 1/10W 1036 RESISTOR R2627 1-216-809-11 METAL CHIP 100 5% 1/10W KDX-46Q005 (UC) 6-15...
Page 183 R2713 1-218-708-11 METAL CHIP 4.7K 0.5% 1/10W 1107 RESISTOR R2715 1-218-708-11 METAL CHIP 4.7K 0.5% 1/10W 1108 RESISTOR R2716 1-218-708-11 METAL CHIP 4.7K 0.5% 1/10W 1109 RESISTOR R2717 1-216-864-11 SHORT CHIP 1110 RESISTOR R2718 1-216-864-11 SHORT CHIP KDX-46Q005 (UC) 6-16...
Page 184 1180 RESISTOR R2805 1-216-864-11 SHORT CHIP 1181 RESISTOR R2806 1-216-805-11 METAL CHIP 1/10W 1182 RESISTOR R2807 1-216-864-11 SHORT CHIP 1183 RESISTOR R2809 1-220-283-91 METAL CHIP 6.8K 5% 1/4W 1184 RESISTOR R2810 1-220-283-91 METAL CHIP 6.8K 5% 1/4W KDX-46Q005 (UC) 6-17...
Page 185 1/10W 1255 RESISTOR R1011 1-216-833-11 METAL CHIP 10K 5% 1/10W 1256 RESISTOR R1012 1-216-833-11 METAL CHIP 10K 5% 1/10W 1257 RESISTOR R1013 1-216-833-11 METAL CHIP 10K 5% 1/10W 1258 CAPACITOR C1101 1-126-205-11 ELECT CHIP 47UF 20.00% 6.3V KDX-46Q005 (UC) 6-18...
Page 186 CERAMIC CHIP 0.1UF 1328 CAPACITOR C5309 1-100-907-11 CERAMIC CHIP 0.1UF 1329 CAPACITOR C5310 1-100-907-11 CERAMIC CHIP 0.1UF 1330 CAPACITOR C5311 1-100-907-11 CERAMIC CHIP 0.1UF 1331 CAPACITOR C5312 1-100-907-11 CERAMIC CHIP 0.1UF 1332 CAPACITOR C5313 1-100-907-11 CERAMIC CHIP 0.1UF KDX-46Q005 (UC) 6-19...
Page 187 C5426 1-125-777-11 CERAMIC CHIP 0.1UF 10.00% 10V 1403 CAPACITOR C5427 1-125-777-11 CERAMIC CHIP 0.1UF 10.00% 10V 1404 CAPACITOR C5428 1-100-907-11 CERAMIC CHIP 0.1UF 1405 CAPACITOR C5429 1-100-567-81 CERAMIC CHIP 10000PF 1406 CAPACITOR C5430 1-100-567-81 CERAMIC CHIP 10000PF KDX-46Q005 (UC) 6-20...
Page 188 CERAMIC CHIP 0.1UF 1476 CAPACITOR C5955 1-100-907-11 CERAMIC CHIP 0.1UF 1477 CAPACITOR C5956 1-100-907-11 CERAMIC CHIP 0.1UF 1478 CAPACITOR C5957 1-100-907-11 CERAMIC CHIP 0.1UF 1479 CAPACITOR C5958 1-100-907-11 CERAMIC CHIP 0.1UF 1480 CAPACITOR C5959 1-100-907-11 CERAMIC CHIP 0.1UF KDX-46Q005 (UC) 6-21...
Page 189 DIODE BAS316-115 1549 DIODE D5102 8-719-800-76 DIODE 1SS226 1550 DIODE D5103 6-501-130-01 DIODE RCLAMP0504F.TCT 1551 DIODE D5104 8-719-069-29 DIODE RB520S-30TE61 1552 DIODE D5105 8-719-078-04 DIODE EC31QS03L-TE12L 1553 DIODE D5106 8-719-078-04 DIODE EC31QS03L-TE12L 1554 DIODE D5107 6-500-294-01 DIODE PTZ-TE25-3.9B KDX-46Q005 (UC) 6-22...
Page 190 FERRITE 1623 FERRITE BEAD FB5137 1-469-082-21 FERRITE 1624 FERRITE BEAD FB5138 1-469-082-21 FERRITE 1625 FERRITE BEAD FB5139 1-469-082-21 FERRITE 1626 FERRITE BEAD FB5140 1-469-082-21 FERRITE 1627 FERRITE BEAD FB5302 1-469-855-21 FERRITE 1628 FERRITE BEAD FB5304 1-469-855-21 FERRITE KDX-46Q005 (UC) 6-23...
Page 191 4.7UH 1697 COIL L5301 1-469-967-21 INDUCTOR 10UH 1698 COIL L5404 1-469-555-21 INDUCTOR 10UH 1699 COIL L5405 1-469-555-21 INDUCTOR 10UH 1700 COIL L5407 1-469-555-21 INDUCTOR 10UH 1701 COIL L5901 1-419-630-21 INDUCTOR 4.7UH 1702 COIL L5902 1-469-555-21 INDUCTOR 10UH KDX-46Q005 (UC) 6-24...
Page 192 1-218-973-11 RES-CHIP 47K 5% 1/16W 1773 RESISTOR R5148 1-218-941-81 RES-CHIP 100 5% 1/16W 1774 RESISTOR R5149 1-218-965-11 RES-CHIP 10K 5% 1/16W 1775 RESISTOR R5150 1-218-955-11 RES-CHIP 1.5K 5% 1/16W 1776 RESISTOR R5151 1-218-965-11 RES-CHIP 10K 5% 1/16W KDX-46Q005 (UC) 6-25...
Page 193 1/16W 1846 RESISTOR R5234 1-218-961-11 RES-CHIP 4.7K 5% 1/16W 1847 RESISTOR R5235 1-218-961-11 RES-CHIP 4.7K 5% 1/16W 1848 RESISTOR R5236 1-218-933-11 RES-CHIP 1/16W 1849 RESISTOR R5237 1-218-933-11 RES-CHIP 1/16W 1850 RESISTOR R5238 1-218-985-11 RES-CHIP 470K 5% 1/16W KDX-46Q005 (UC) 6-26...
Page 194 1/16W 1919 RESISTOR R5409 1-218-990-81 SHORT CHIP 1920 RESISTOR R5412 1-218-990-81 SHORT CHIP 1921 RESISTOR R5414 1-218-953-11 RES-CHIP 1/16W 1922 RESISTOR R5901 1-218-990-81 SHORT CHIP 1923 RESISTOR R5902 1-218-953-11 RES-CHIP 1/16W 1924 RESISTOR R5903 1-218-990-81 SHORT CHIP KDX-46Q005 (UC) 6-27...
Page 195 1-218-965-11 RES-CHIP 10K 5% 1/16W 1995 RESISTOR R5987 1-218-965-11 RES-CHIP 10K 5% 1/16W 1996 RESISTOR R5988 1-218-961-11 RES-CHIP 4.7K 5% 1/16W 1997 RESISTOR R5989 1-218-961-11 RES-CHIP 4.7K 5% 1/16W 1998 RESISTOR R5990 1-218-965-11 RES-CHIP 10K 5% 1/16W KDX-46Q005 (UC) 6-28...
Page 196 1-234-702-11 RES, NETWORK 68 (1005X4) 2069 NETWORK RB5330 1-234-371-21 RES, NETWORK 47 (1005X4) 2070 NETWORK RB5331 1-234-371-21 RES, NETWORK 47 (1005X4) 2071 NETWORK RB5332 1-234-371-21 RES, NETWORK 47 (1005X4) 2072 NETWORK RB5333 1-234-371-21 RES, NETWORK 47 (1005X4) KDX-46Q005 (UC) 6-29...
Page 197 ELECT CHIP 10UF 2143 A1MU CAPACITOR C127 1-162-970-11 CERAMIC CHIP 0.01UF 10.00% 25V 2144 A1MU CAPACITOR C128 1-100-766-21 ELECT CHIP 47UF 2145 A1MU CAPACITOR C129 1-100-765-21 ELECT CHIP 10UF 2146 A1MU CAPACITOR C130 1-107-826-11 CERAMIC CHIP 0.1UF 10.00% 16V KDX-46Q005 (UC) 6-30...
Page 198 ELECT CHIP 10UF 2217 A1MU CAPACITOR C207 1-100-765-21 ELECT CHIP 10UF 2218 A1MU CAPACITOR C208 1-107-826-11 CERAMIC CHIP 0.1UF 10.00% 16V 2219 A1MU CAPACITOR C209 1-162-970-11 CERAMIC CHIP 0.01UF 10.00% 25V 2220 A1MU CAPACITOR C210 1-100-765-21 ELECT CHIP 10UF KDX-46Q005 (UC) 6-31...
Page 199 CAPACITOR C465 1-107-826-11 CERAMIC CHIP 0.1UF 10.00% 16V 2292 A1MU CAPACITOR C467 1-125-837-91 CERAMIC CHIP 1UF 6.3V 2293 A1MU CAPACITOR C468 1-107-826-11 CERAMIC CHIP 0.1UF 10.00% 16V 2294 A1MU CAPACITOR C469 1-107-826-11 CERAMIC CHIP 0.1UF 10.00% 16V KDX-46Q005 (UC) 6-32...
Page 200 ELECT CHIP 56UF 2365 A1MU CAPACITOR C702 1-164-245-11 CERAMIC CHIP 0.015UF 10.00% 25V 2366 A1MU CAPACITOR C703 1-107-826-11 CERAMIC CHIP 0.1UF 10.00% 16V 2367 A1MU CAPACITOR C704 1-127-573-11 CERAMIC CHIP 1UF 2368 A1MU CAPACITOR C705 1-165-908-11 CERAMIC CHIP 1UF KDX-46Q005 (UC) 6-33...
Page 201 DIODE RD5.6SB-T1 2438 A1MU DIODE D616 8-719-081-97 DIODE MMDL914T1 2439 A1MU DIODE D617 8-719-081-97 DIODE MMDL914T1 2440 A1MU DIODE D700 8-719-056-85 DIODE UDZ-TE-17-8.2B 2441 A1MU DIODE D701 8-719-081-97 DIODE MMDL914T1 2442 A1MU DIODE D702 8-719-081-67 DIODE M1FM3 KDX-46Q005 (UC) 6-34...
Page 202 INDUCTOR 10UH 2512 A1MU COIL L101 1-412-058-11 INDUCTOR 10UH 2513 A1MU COIL L102 1-412-058-11 INDUCTOR 10UH 2514 A1MU COIL L103 1-412-058-11 INDUCTOR 10UH 2515 A1MU COIL L104 1-412-058-11 INDUCTOR 10UH 2516 A1MU COIL L105 1-412-058-11 INDUCTOR 10UH KDX-46Q005 (UC) 6-35...
Page 203 TRANSISTOR 2SD601A-Q-TX 2586 A1MU TRANSISTOR Q407 8-729-422-33 TRANSISTOR 2SD601A-Q-TX 2587 A1MU TRANSISTOR Q408 8-729-422-33 TRANSISTOR 2SD601A-Q-TX 2588 A1MU TRANSISTOR Q410 6-550-586-01 TRANSISTOR 2PA1576R-115 2589 A1MU TRANSISTOR Q411 8-729-422-33 TRANSISTOR 2SD601A-Q-TX 2590 A1MU TRANSISTOR Q412 6-550-586-01 TRANSISTOR 2PA1576R-115 KDX-46Q005 (UC) 6-36...
Page 204 R100 1-216-813-11 METAL CHIP 220 5% 1/10W 2662 A1MU RESISTOR R101 1-216-813-11 METAL CHIP 220 5% 1/10W 2663 A1MU RESISTOR R102 1-216-813-11 METAL CHIP 220 5% 1/10W 2664 A1MU RESISTOR R103 1-216-813-11 METAL CHIP 220 5% 1/10W KDX-46Q005 (UC) 6-37...
Page 205 R176 1-216-815-11 METAL CHIP 330 5% 1/10W 2736 A1MU RESISTOR R177 1-216-809-11 METAL CHIP 100 5% 1/10W 2737 A1MU RESISTOR R178 1-216-809-11 METAL CHIP 100 5% 1/10W 2738 A1MU RESISTOR R179 1-216-815-11 METAL CHIP 330 5% 1/10W KDX-46Q005 (UC) 6-38...
Page 206 A1MU RESISTOR R260 1-216-829-11 METAL CHIP 4.7K 5% 1/10W 2810 A1MU RESISTOR R261 1-216-829-11 METAL CHIP 4.7K 5% 1/10W 2811 A1MU RESISTOR R262 1-216-801-11 METAL CHIP 1/10W 2812 A1MU RESISTOR R263 1-216-833-11 METAL CHIP 10K 5% 1/10W KDX-46Q005 (UC) 6-39...
Page 207 A1MU RESISTOR R412 1-216-833-11 METAL CHIP 10K 5% 1/10W 2884 A1MU RESISTOR R413 1-216-833-11 METAL CHIP 10K 5% 1/10W 2885 A1MU RESISTOR R415 1-216-833-11 METAL CHIP 10K 5% 1/10W 2886 A1MU RESISTOR R416 1-216-805-11 METAL CHIP 1/10W KDX-46Q005 (UC) 6-40...
Page 208 R494 1-216-825-11 METAL CHIP 2.2K 5% 1/10W 2958 A1MU RESISTOR R495 1-216-837-11 METAL CHIP 22K 5% 1/10W 2959 A1MU RESISTOR R496 1-216-825-11 METAL CHIP 2.2K 5% 1/10W 2960 A1MU RESISTOR R497 1-216-829-11 METAL CHIP 4.7K 5% 1/10W KDX-46Q005 (UC) 6-41...
Page 209 A1MU RESISTOR R673 1-216-821-11 METAL CHIP 1/10W 3032 A1MU RESISTOR R678 1-216-833-11 METAL CHIP 10K 5% 1/10W 3033 A1MU RESISTOR R679 1-216-833-11 METAL CHIP 10K 5% 1/10W 3034 A1MU RESISTOR R680 1-216-825-11 METAL CHIP 2.2K 5% 1/10W KDX-46Q005 (UC) 6-42...
Page 210 CAPACITOR C6108 1-164-143-11 CERAMIC 0.001UF 10.00% 1KV 3106 G1MU CAPACITOR C6110 1-162-964-11 CERAMIC CHIP 0.001UF 10.00% 50V 3107 G1MU CAPACITOR C6111 1-162-970-11 CERAMIC CHIP 0.01UF 10.00% 25V 3108 G1MU CAPACITOR C6112 1-162-959-11 CERAMIC CHIP 330PF 5.00% 50V KDX-46Q005 (UC) 6-43...
Page 211 DIODE M1FS4-4063 3178 G1MU DIODE D6207 6-501-043-01 DIODE UMZ16NT106 3179 G1MU DIODE D6208 6-501-043-01 DIODE UMZ16NT106 3180 G1MU DIODE D6210 8-719-080-69 DIODE M1FS4-4063 3181 G1MU DIODE D6214 6-500-567-31 DIODE 10ERB20-TB3 3182 G1MU DIODE D6216 8-719-081-97 DIODE MMDL914T1 KDX-46Q005 (UC) 6-44...
Page 212 R6104 1-218-760-11 METAL CHIP 220K 0.5% 1/10W 3254 G1MU RESISTOR R6105 1-208-830-11 METAL CHIP 100K 0.5% 1/10W 3255 G1MU RESISTOR R6106 1-218-869-11 METAL CHIP 8.2K 0.5% 1/10W 3256 G1MU RESISTOR R6107 1-218-867-11 METAL CHIP 6.8K 0.5% 1/10W KDX-46Q005 (UC) 6-45...
Page 213 R6520 1-208-836-11 METAL CHIP 180K 0.5% 1/10W 3328 G1MU RESISTOR R6521 1-208-836-11 METAL CHIP 180K 0.5% 1/10W 3329 G1MU RESISTOR R6522 1-216-833-11 METAL CHIP 10K 5% 1/10W 3330 G1MU RESISTOR R6523 1-216-833-11 METAL CHIP 10K 5% 1/10W KDX-46Q005 (UC) 6-46...
Page 214 10.00% 25V 3401 CAPACITOR C9575 1-162-970-11 CERAMIC CHIP 0.01UF 10.00% 25V 3402 CAPACITOR C9576 1-126-394-11 ELECT CHIP 10UF 20.00% 16V 3403 CAPACITOR C9578 1-162-916-11 CERAMIC CHIP 12PF 5.00% 50V 3404 CAPACITOR C9579 1-162-916-11 CERAMIC CHIP 12PF 5.00% 50V KDX-46Q005 (UC) 6-47...
Page 215 0.50PF 50V 3475 CAPACITOR C9881 1-162-915-11 CERAMIC CHIP 10PF 0.50PF 50V 3476 CAPACITOR C9882 1-162-970-11 CERAMIC CHIP 0.01UF 10.00% 25V 3477 CAPACITOR C9883 1-162-970-11 CERAMIC CHIP 0.01UF 10.00% 25V 3478 CAPACITOR C9884 1-107-826-11 CERAMIC CHIP 0.1UF 10.00% 16V KDX-46Q005 (UC) 6-48...
Page 216 RESISTOR R9505 1-216-864-11 SHORT CHIP 3549 RESISTOR R9506 1-216-809-11 METAL CHIP 100 5% 1/10W 3550 RESISTOR R9510 1-218-672-11 METAL CHIP 150 0.5% 1/10W 3551 RESISTOR R9511 1-216-864-11 SHORT CHIP 3552 RESISTOR R9512 1-218-665-11 METAL CHIP 0.5% 1/10W KDX-46Q005 (UC) 6-49...
Page 217 METAL CHIP 100K 5% 1/10W 3623 RESISTOR R9625 1-216-845-11 METAL CHIP 100K 5% 1/10W 3624 RESISTOR R9626 1-216-833-11 METAL CHIP 10K 5% 1/10W 3625 RESISTOR R9627 1-216-809-11 METAL CHIP 100 5% 1/10W 3626 RESISTOR R9700 1-218-929-11 RES-CHIP 1/16W KDX-46Q005 (UC) 6-50...
Page 218 RB9805 1-234-524-21 RES, CHIP NETWORK 33 (3216) 3696 VARISTOR VD9500 6-500-701-01 DIODE PGB1010603NR 3697 VARISTOR VD9501 6-500-701-01 DIODE PGB1010603NR 3698 VARISTOR VD9502 6-500-701-01 DIODE PGB1010603NR 3699 VARISTOR VD9503 6-500-701-01 DIODE PGB1010603NR 3700 VARISTOR VD9504 6-500-701-01 DIODE PGB1010603NR KDX-46Q005 (UC) 6-51...
Page 219 R1505 1-216-849-11 METAL CHIP 220K 5% 1/10W 3772 H1MU RESISTOR R1506 1-216-849-11 METAL CHIP 220K 5% 1/10W 3773 H1MU RESISTOR R1515 1-216-833-11 METAL CHIP 10K 5% 1/10W 3774 H1MU RESISTOR R1518 1-216-833-11 METAL CHIP 10K 5% 1/10W KDX-46Q005 (UC) 6-52...
Page 220 CONNECTOR CN7205 1-569-775-21 PIN, CONNECTOR (SMD) 5P 3844 CONNECTOR CN7207 1-785-125-21 CONNECTOR 6P 3845 DIODE D7202 8-719-083-58 DIODE UDZSTE-173.9B 3846 DIODE D7203 8-719-081-97 DIODE MMDL914T1 3847 DIODE D7210 6-500-182-01 DIODE L-1503CB/1ID-F01 3848 DIODE D7212 8-719-083-58 DIODE UDZSTE-173.9B KDX-46Q005 (UC) 6-53...
Page 221 6.3V 3919 T1MJ CAPACITOR C9040 1-100-567-81 CERAMIC CHIP 10000PF 3920 T1MJ CAPACITOR C9048 1-107-826-11 CERAMIC CHIP 0.1UF 10.00% 16V 3921 T1MJ CAPACITOR C9049 1-128-995-21 ELECT CHIP 100UF 3922 T1MJ CAPACITOR C9051 1-107-826-11 CERAMIC CHIP 0.1UF 10.00% 16V KDX-46Q005 (UC) 6-54...
Page 222 C9322 1-125-777-11 CERAMIC CHIP 0.1UF 10.00% 10V 3994 T1MJ CAPACITOR C9323 1-126-205-11 ELECT CHIP 47UF 20.00% 6.3V 3995 T1MJ CAPACITOR C9324 1-107-826-11 CERAMIC CHIP 0.1UF 10.00% 16V 3996 T1MJ CAPACITOR C9325 1-125-777-11 CERAMIC CHIP 0.1UF 10.00% 10V KDX-46Q005 (UC) 6-55...
Page 223 L9001 1-419-630-21 INDUCTOR 4.7UH 4066 T1MJ COIL L9002 1-419-630-21 INDUCTOR 4.7UH 4067 T1MJ COIL L9003 1-416-606-11 INDUCTOR 47UH 4068 T1MJ COIL L9005 1-424-922-21 INDUCTOR 10UH 4069 T1MJ COIL L9007 1-419-370-21 INDUCTOR 4070 T1MJ COIL L9008 1-419-370-21 INDUCTOR KDX-46Q005 (UC) 6-56...
Page 224 1/16W 4141 T1MJ RESISTOR R9055 1-218-959-11 RES-CHIP 3.3K 5% 1/16W 4142 T1MJ RESISTOR R9061 1-218-959-11 RES-CHIP 3.3K 5% 1/16W 4143 T1MJ RESISTOR R9062 1-218-965-11 RES-CHIP 10K 5% 1/16W 4144 T1MJ RESISTOR R9063 1-218-965-11 RES-CHIP 10K 5% 1/16W KDX-46Q005 (UC) 6-57...
Page 225 0.5% 1/16W 4214 T1MJ RESISTOR R9304 1-218-953-11 RES-CHIP 1/16W 4215 T1MJ RESISTOR R9306 1-218-990-81 SHORT CHIP 4216 T1MJ RESISTOR R9307 1-218-990-81 SHORT CHIP 4217 T1MJ RESISTOR R9308 1-218-990-81 SHORT CHIP 4218 T1MJ RESISTOR R9309 1-218-933-11 RES-CHIP 1/16W KDX-46Q005 (UC) 6-58...
Page 226 10.00% 10V 4289 M1MU CAPACITOR C7003 1-128-993-21 ELECT CHIP 22UF 4290 M1MU CAPACITOR C7004 1-125-777-11 CERAMIC CHIP 0.1UF 10.00% 10V 4291 M1MU CAPACITOR C7005 1-164-943-81 CERAMIC CHIP 0.01UF 10.00% 16V 4292 M1MU CAPACITOR C7006 1-128-993-21 ELECT CHIP 22UF KDX-46Q005 (UC) 6-59...
Page 227 ELECT CHIP 4.7UF 20.00% 35V 4363 M1MU CAPACITOR C7414 1-107-820-11 CERAMIC CHIP 0.1UF 4364 M1MU CAPACITOR C7415 1-164-505-11 CERAMIC CHIP 2.2UF 4365 M1MU CAPACITOR C7416 1-137-987-81 CERAMIC CHIP 0.068UF 4366 M1MU CAPACITOR C7418 1-104-601-11 ELECT CHIP 10UF 20.00% 10V KDX-46Q005 (UC) 6-60...
Page 228 CAPACITOR C7653 1-164-943-81 CERAMIC CHIP 0.01UF 10.00% 16V 4438 M1MU CAPACITOR C7654 1-165-870-21 ELECT CHIP 100UF 6.3V 4439 M1MU CAPACITOR C7655 1-125-777-11 CERAMIC CHIP 0.1UF 10.00% 10V 4440 M1MU CAPACITOR C7656 1-125-777-11 CERAMIC CHIP 0.1UF 10.00% 10V KDX-46Q005 (UC) 6-61...
Page 229 C7770 1-164-937-11 CERAMIC CHIP 0.001UF 10.00% 50V 4512 M1MU CAPACITOR C7771 1-126-391-11 ELECT CHIP 47UF 20.00% 6.3V 4513 M1MU CAPACITOR C7954 1-125-777-11 CERAMIC CHIP 0.1UF 10.00% 10V 4514 M1MU CAPACITOR C7957 1-164-943-81 CERAMIC CHIP 0.01UF 10.00% 16V KDX-46Q005 (UC) 6-62...
Page 230 1-469-082-21 FERRITE 4584 M1MU FERRITE BEAD FB7046 1-469-082-21 FERRITE 4585 M1MU FERRITE BEAD FB7047 1-469-082-21 FERRITE 4586 M1MU FERRITE BEAD FB7048 1-469-082-21 FERRITE 4587 M1MU FERRITE BEAD FB7050 1-469-082-21 FERRITE 4588 M1MU FERRITE BEAD FB7051 1-469-082-21 FERRITE KDX-46Q005 (UC) 6-63...
Page 231 TRANSISTOR DTC144EUA-T106 4658 M1MU TRANSISTOR Q7003 8-729-907-00 TRANSISTOR DTC114EU 4659 M1MU TRANSISTOR Q7004 6-550-585-01 TRANSISTOR 2PC4081R-115 4660 M1MU TRANSISTOR Q7005 8-729-901-47 TRANSISTOR DTA143EK 4661 M1MU TRANSISTOR Q7006 6-550-585-01 TRANSISTOR 2PC4081R-115 4662 M1MU TRANSISTOR Q7007 6-550-585-01 TRANSISTOR 2PC4081R-115 KDX-46Q005 (UC) 6-64...
Page 232 1-218-941-81 RES-CHIP 100 5% 1/16W 4733 M1MU RESISTOR R7043 1-218-937-11 RES-CHIP 1/16W 4734 M1MU RESISTOR R7045 1-218-941-81 RES-CHIP 100 5% 1/16W 4735 M1MU RESISTOR R7046 1-218-937-11 RES-CHIP 1/16W 4736 M1MU RESISTOR R7047 1-218-965-11 RES-CHIP 10K 5% 1/16W KDX-46Q005 (UC) 6-65...
Page 233 47K 5% 1/16W 4807 M1MU RESISTOR R7138 1-218-965-11 RES-CHIP 10K 5% 1/16W 4808 M1MU RESISTOR R7139 1-218-973-11 RES-CHIP 47K 5% 1/16W 4809 M1MU RESISTOR R7141 1-218-990-81 SHORT CHIP 4810 M1MU RESISTOR R7142 1-218-956-11 RES-CHIP 1.8K 5% 1/16W KDX-46Q005 (UC) 6-66...
Page 234 RESISTOR R7242 1-218-990-81 SHORT CHIP 4881 M1MU RESISTOR R7243 1-218-933-11 RES-CHIP 1/16W 4882 M1MU RESISTOR R7245 1-218-959-11 RES-CHIP 3.3K 5% 1/16W 4883 M1MU RESISTOR R7246 1-218-959-11 RES-CHIP 3.3K 5% 1/16W 4884 M1MU RESISTOR R7247 1-218-990-81 SHORT CHIP KDX-46Q005 (UC) 6-67...
Page 235 4954 M1MU RESISTOR R7478 1-218-990-81 SHORT CHIP 4955 M1MU RESISTOR R7479 1-218-990-81 SHORT CHIP 4956 M1MU RESISTOR R7481 1-218-990-81 SHORT CHIP 4957 M1MU RESISTOR R7482 1-218-990-81 SHORT CHIP 4958 M1MU RESISTOR R7483 1-208-643-11 METAL CHIP 0.5% 1/16W KDX-46Q005 (UC) 6-68...
Page 236 1-218-965-11 RES-CHIP 10K 5% 1/16W 5029 M1MU RESISTOR R7712 1-218-958-11 RES-CHIP 2.7K 5% 1/16W 5030 M1MU RESISTOR R7713 1-218-971-11 RES-CHIP 33K 5% 1/16W 5031 M1MU RESISTOR R7714 1-218-990-81 SHORT CHIP 5032 M1MU RESISTOR R7716 1-218-990-81 SHORT CHIP KDX-46Q005 (UC) 6-69...
Page 237 680 0.5% 1/16W 5103 M1MU RESISTOR R7796 1-208-893-11 METAL CHIP 1.8K 0.5% 1/16W 5104 M1MU RESISTOR R7797 1-218-990-81 SHORT CHIP 5105 M1MU RESISTOR R7798 1-218-955-11 RES-CHIP 1.5K 5% 1/16W 5106 M1MU RESISTOR R7802 1-218-955-11 RES-CHIP 1.5K 5% 1/16W KDX-46Q005 (UC) 6-70...
Page 238 (1005X4) 5177 M1MU NETWORK RB7713 1-234-378-21 RES, NETWORK 10K (1005X4) 5178 M1MU NETWORK RB7714 1-234-378-21 RES, NETWORK 10K (1005X4) 5179 M1MU NETWORK RB7715 1-234-378-21 RES, NETWORK 10K (1005X4) 5180 M1MU NETWORK RB7716 1-234-378-21 RES, NETWORK 10K (1005X4) KDX-46Q005 (UC) 6-71...
Page 239 CERAMIC CHIP 0.1UF 10.00% 10V 5251 DIC3 CAPACITOR C4230 1-100-581-81 CERAMIC CHIP 4700PF 5252 DIC3 CAPACITOR C4246 1-125-777-11 CERAMIC CHIP 0.1UF 10.00% 10V 5253 DIC3 CAPACITOR C4300 1-131-661-21 ELECT CHIP 100UF 5254 DIC3 CAPACITOR C4301 1-131-661-21 ELECT CHIP 100UF KDX-46Q005 (UC) 6-72...
Page 240 DIC3 CAPACITOR C4380 1-125-777-11 CERAMIC CHIP 0.1UF 10.00% 10V 5326 DIC3 CAPACITOR C4381 1-125-777-11 CERAMIC CHIP 0.1UF 10.00% 10V 5327 DIC3 CAPACITOR C4382 1-125-777-11 CERAMIC CHIP 0.1UF 10.00% 10V 5328 DIC3 CAPACITOR C4384 1-165-908-11 CERAMIC CHIP 1UF KDX-46Q005 (UC) 6-73...
Page 241 CERAMIC CHIP 0.1UF 10.00% 10V 5399 DIC3 CAPACITOR C4552 1-100-567-81 CERAMIC CHIP 10000PF 5400 DIC3 CAPACITOR C4553 1-100-567-81 CERAMIC CHIP 10000PF 5401 DIC3 CAPACITOR C4554 1-100-567-81 CERAMIC CHIP 10000PF 5402 DIC3 CAPACITOR C4555 1-100-567-81 CERAMIC CHIP 10000PF KDX-46Q005 (UC) 6-74...
Page 242 C4637 1-100-567-81 CERAMIC CHIP 10000PF 5473 DIC3 CAPACITOR C4638 1-100-567-81 CERAMIC CHIP 10000PF 5474 DIC3 CAPACITOR C4639 1-100-567-81 CERAMIC CHIP 10000PF 5475 DIC3 CAPACITOR C4640 1-100-567-81 CERAMIC CHIP 10000PF 5476 DIC3 CAPACITOR C4641 1-100-567-81 CERAMIC CHIP 10000PF KDX-46Q005 (UC) 6-75...
Page 243 DIC3 CAPACITOR C4810 1-125-777-11 CERAMIC CHIP 0.1UF 10.00% 10V 5548 DIC3 CAPACITOR C4811 1-100-567-81 CERAMIC CHIP 10000PF 5549 DIC3 CAPACITOR C4812 1-125-777-11 CERAMIC CHIP 0.1UF 10.00% 10V 5550 DIC3 CAPACITOR C4813 1-125-777-11 CERAMIC CHIP 0.1UF 10.00% 10V KDX-46Q005 (UC) 6-76...
Page 244 DIODE PTZ-TE25-3.9B 5620 DIC3 DIODE D4004 8-719-050-38 DIODE M1MA152WK-T1 5621 DIC3 DIODE D4005 8-719-050-37 DIODE M1MA152WA-T1 5622 DIC3 DIODE D4013 6-500-619-01 DIODE RB520S-40TE61 5623 DIC3 FERRITE BEAD FB4002 1-414-228-11 FERRITE 5624 DIC3 FERRITE BEAD FB4003 1-414-228-11 FERRITE KDX-46Q005 (UC) 6-77...
Page 245 1-424-918-21 INDUCTOR 10UH 5694 DIC3 COIL L4003 1-424-918-21 INDUCTOR 10UH 5695 DIC3 COIL L4200 1-469-555-21 INDUCTOR 10UH 5696 DIC3 COIL L4201 1-469-555-21 INDUCTOR 10UH 5697 DIC3 COIL L4300 1-469-549-21 INDUCTOR 5698 DIC3 COIL L4301 1-469-555-21 INDUCTOR 10UH KDX-46Q005 (UC) 6-78...
Page 246 68K 0.5% 1/16W 5769 DIC3 RESISTOR R4041 1-208-893-11 METAL CHIP 1.8K 0.5% 1/16W 5770 DIC3 RESISTOR R4042 1-218-969-11 RES-CHIP 22K 5% 1/16W 5771 DIC3 RESISTOR R4043 1-218-929-11 RES-CHIP 1/16W 5772 DIC3 RESISTOR R4044 1-218-969-11 RES-CHIP 22K 5% 1/16W KDX-46Q005 (UC) 6-79...
Page 247 RES-CHIP 1/16W 5842 DIC3 RESISTOR R4229 1-218-935-11 RES-CHIP 1/16W 5843 DIC3 RESISTOR R4230 1-218-935-11 RES-CHIP 1/16W 5844 DIC3 RESISTOR R4231 1-218-935-11 RES-CHIP 1/16W 5845 DIC3 RESISTOR R4232 1-218-935-11 RES-CHIP 1/16W 5846 DIC3 RESISTOR R4236 1-218-990-81 SHORT CHIP KDX-46Q005 (UC) 6-80...
Page 248 RESISTOR R4377 1-208-661-11 METAL CHIP 120 0.5% 1/16W 5918 DIC3 RESISTOR R4378 1-218-945-11 METAL CHIP 220 5% 1/16W 5919 DIC3 RESISTOR R4379 1-208-855-81 METAL CHIP 0.5% 1/16W 5920 DIC3 RESISTOR R4380 1-208-661-11 METAL CHIP 120 0.5% 1/16W KDX-46Q005 (UC) 6-81...
Page 249 RESISTOR R4476 1-208-695-11 METAL CHIP 3.3K 0.5% 1/16W 5992 DIC3 RESISTOR R4477 1-218-849-11 METAL CHIP 1.2K 0.5% 1/10W 5993 DIC3 RESISTOR R4478 1-218-957-11 RES-CHIP 2.2K 5% 1/16W 5994 DIC3 RESISTOR R4479 1-208-893-11 METAL CHIP 1.8K 0.5% 1/16W KDX-46Q005 (UC) 6-82...
Page 250 1-218-935-11 RES-CHIP 1/16W 6065 DIC3 RESISTOR R4614 1-208-893-11 METAL CHIP 1.8K 0.5% 1/16W 6066 DIC3 RESISTOR R4615 1-218-849-11 METAL CHIP 1.2K 0.5% 1/10W 6067 DIC3 RESISTOR R4616 1-218-990-81 SHORT CHIP 6068 DIC3 RESISTOR R4617 1-218-990-81 SHORT CHIP KDX-46Q005 (UC) 6-83...
Page 251 RES-CHIP 1/16W 6138 DIC3 RESISTOR R4813 1-218-953-11 RES-CHIP 1/16W 6139 DIC3 RESISTOR R4814 1-218-953-11 RES-CHIP 1/16W 6140 DIC3 RESISTOR R4815 1-218-953-11 RES-CHIP 1/16W 6141 DIC3 RESISTOR R4816 1-218-953-11 RES-CHIP 1/16W 6142 DIC3 RESISTOR R4817 1-218-953-11 RES-CHIP 1/16W KDX-46Q005 (UC) 6-84...
Page 252 (1005X4) 6213 DIC3 NETWORK RB4222 1-242-963-21 RES, NETWORK 33 (1005X4) 6214 DIC3 NETWORK RB4223 1-242-963-21 RES, NETWORK 33 (1005X4) 6215 DIC3 NETWORK RB4231 1-234-795-21 RES, NETWORK 0X4 (2010) 6216 DIC3 NETWORK RB4232 1-234-795-21 RES, NETWORK 0X4 (2010) KDX-46Q005 (UC) 6-85...
Page 253 (1005X4) 6287 DIC3 NETWORK RB4605 1-234-378-21 RES, NETWORK 10K (1005X4) 6288 DIC3 NETWORK RB4606 1-234-378-21 RES, NETWORK 10K (1005X4) 6289 DIC3 NETWORK RB4607 1-234-378-21 RES, NETWORK 10K (1005X4) 6290 DIC3 NETWORK RB4608 1-234-378-21 RES, NETWORK 10K (1005X4) KDX-46Q005 (UC) 6-86...
Page 254 6360 CAPACITOR C7906 1-164-156-11 CERAMIC CHIP 0.1UF 6361 CAPACITOR C7907 1-164-156-11 CERAMIC CHIP 0.1UF 6362 CAPACITOR C7908 1-164-156-11 CERAMIC CHIP 0.1UF 6363 CAPACITOR C7909 1-126-395-11 ELECT CHIP 22UF 20.00% 16V 6364 CAPACITOR C7910 1-162-995-11 CERAMIC CHIP 0.022UF KDX-46Q005 (UC) 6-87...
Page 255 22UH 6433 COIL L7907 1-414-754-11 INDUCTOR 10UH 6434 COIL L7908 1-414-754-11 INDUCTOR 10UH 6435 COIL L7910 1-414-752-11 INDUCTOR 2.2UH 6436 COIL L7911 1-414-752-11 INDUCTOR 2.2UH 6437 COIL L7912 1-414-754-11 INDUCTOR 10UH 6438 TRANSISTOR Q7900 8-729-037-52 TRANSISTOR 2SD2216J-QR(TX).SO KDX-46Q005 (UC) 6-88...
Page 256 6508 RESISTOR R7969 1-216-809-11 METAL CHIP 100 5% 1/10W 6509 RESISTOR R7970 1-216-821-11 METAL CHIP 1/10W 6510 RESISTOR R7971 1-216-817-11 METAL CHIP 470 5% 1/10W 6511 RESISTOR R7972 1-216-864-11 SHORT CHIP 6512 RESISTOR R7976 1-216-864-11 SHORT CHIP KDX-46Q005 (UC) 6-89...
Page 257 CERAMIC CHIP 0.1UF 6583 QMDV CAPACITOR C7363 1-100-597-91 CERAMIC CHIP 0.1UF 6584 QMDV CAPACITOR C7364 1-100-597-91 CERAMIC CHIP 0.1UF 6585 QMDV CAPACITOR C7365 1-125-837-91 CERAMIC CHIP 1UF 6.3V 6586 QMDV CAPACITOR C7366 1-125-837-91 CERAMIC CHIP 1UF 6.3V KDX-46Q005 (UC) 6-90...
Page 258 CERAMIC CHIP 0.1UF 6657 QMDV CAPACITOR C7437 1-100-597-91 CERAMIC CHIP 0.1UF 6658 QMDV CAPACITOR C7438 1-100-597-91 CERAMIC CHIP 0.1UF 6659 QMDV CAPACITOR C7439 1-127-692-11 CERAMIC CHIP 10UF 6660 QMDV CAPACITOR C7440 1-126-206-11 ELECT CHIP 100UF 20.00% 6.3V KDX-46Q005 (UC) 6-91...
Page 259 C7540 1-100-597-91 CERAMIC CHIP 0.1UF 6731 QMDV CAPACITOR C7541 1-100-597-91 CERAMIC CHIP 0.1UF 6732 QMDV CAPACITOR C7543 1-100-597-91 CERAMIC CHIP 0.1UF 6733 QMDV CAPACITOR C7544 1-100-597-91 CERAMIC CHIP 0.1UF 6734 QMDV CAPACITOR C7547 1-100-597-91 CERAMIC CHIP 0.1UF KDX-46Q005 (UC) 6-92...
Page 260 1-400-180-21 INDUCTOR 6804 QMDV FERRITE BEAD FB7314 1-400-180-21 INDUCTOR 6805 QMDV FERRITE BEAD FB7315 1-414-229-11 FERRITE 6806 QMDV FERRITE BEAD FB7316 1-414-229-11 FERRITE 6807 QMDV FERRITE BEAD FB7317 1-400-089-21 FERRITE 6808 QMDV FERRITE BEAD FB7318 1-400-089-21 FERRITE KDX-46Q005 (UC) 6-93...
Page 261 27K 0.5% 1/10W 6879 QMDV RESISTOR R7314 1-218-726-11 METAL CHIP 27K 0.5% 1/10W 6880 QMDV RESISTOR R7315 1-216-864-11 SHORT CHIP 6881 QMDV RESISTOR R7316 1-216-864-11 SHORT CHIP 6882 QMDV RESISTOR R7318 1-216-837-11 METAL CHIP 22K 5% 1/10W KDX-46Q005 (UC) 6-94...
Page 262 METAL CHIP 1/10W 6953 QMDV RESISTOR R7419 1-216-806-11 METAL CHIP 1/10W 6954 QMDV RESISTOR R7420 1-216-806-11 METAL CHIP 1/10W 6955 QMDV RESISTOR R7421 1-216-821-11 METAL CHIP 1/10W 6956 QMDV RESISTOR R7422 1-216-825-11 METAL CHIP 2.2K 5% 1/10W KDX-46Q005 (UC) 6-95...
Page 263 QMDV RESISTOR R7505 1-216-833-11 METAL CHIP 10K 5% 1/10W 7028 QMDV RESISTOR R7506 1-216-845-11 METAL CHIP 100K 5% 1/10W 7029 QMDV RESISTOR R7511 1-216-845-11 METAL CHIP 100K 5% 1/10W 7030 QMDV RESISTOR R7512 1-216-806-11 METAL CHIP 1/10W KDX-46Q005 (UC) 6-96...
Page 264 (1005X4) 7101 QMDV NETWORK RB7318 1-234-370-21 RES, NETWORK 22 (1005X4) 7102 QMDV NETWORK RB7319 1-234-370-21 RES, NETWORK 22 (1005X4) 7103 QMDV NETWORK RB7320 1-234-370-21 RES, NETWORK 22 (1005X4) 7104 QMDV NETWORK RB7321 1-234-370-21 RES, NETWORK 22 (1005X4) KDX-46Q005 (UC) 6-97...
Page 265 CERAMIC CHIP 0.1UF 7174 CAPACITOR C618 1-164-156-11 CERAMIC CHIP 0.1UF 7175 CAPACITOR C619 1-164-156-11 CERAMIC CHIP 0.1UF 7176 CAPACITOR C620 1-164-156-11 CERAMIC CHIP 0.1UF 7177 CAPACITOR C621 1-165-989-11 CERAMIC CHIP 10UF 6.3V 7178 CAPACITOR C702 1-164-156-11 CERAMIC CHIP 0.1UF KDX-46Q005 (UC) 6-98...
Page 266 CAPACITOR C824 1-125-837-91 CERAMIC CHIP 1UF 6.3V 7249 CAPACITOR C825 1-164-156-11 CERAMIC CHIP 0.1UF 7250 CAPACITOR C826 1-164-156-11 CERAMIC CHIP 0.1UF 7251 CAPACITOR C828 1-164-156-11 CERAMIC CHIP 0.1UF 7252 CAPACITOR C829 1-162-927-11 CERAMIC CHIP 100PF 5.00% 50V KDX-46Q005 (UC) 6-99...
Page 267 R708 1-218-672-11 METAL CHIP 150 0.5% 1/10W 7323 RESISTOR R709 1-216-801-11 METAL CHIP 1/10W 7324 RESISTOR R710 1-218-711-11 METAL CHIP 6.2K 0.5% 1/10W 7325 RESISTOR R711 1-216-801-11 METAL CHIP 1/10W 7326 RESISTOR R712 1-216-801-11 METAL CHIP 1/10W KDX-46Q005 (UC) 6-100...
Page 268 1-234-378-21 RES, NETWORK 10K (1005X4) 7397 NETWORK RB707 1-234-378-21 RES, NETWORK 10K (1005X4) 7398 NETWORK RB708 1-234-378-21 RES, NETWORK 10K (1005X4) 7399 NETWORK RB709 1-234-702-11 RES, NETWORK 68 (1005X4) 7400 NETWORK RB710 1-234-702-11 RES, NETWORK 68 (1005X4) KDX-46Q005 (UC) 6-101...
Page 269 PCMCIA CONNECTOR (SMD) 7448 QUMU CONNECTOR CN5553 1-818-484-11 FFC/FPC CONNECTOR (ZIF) 80P 7449 QUMU CHIP CHCKER TP5550 1-694-766-21 TERMINAL (ONBOARD CONTACT) 7450 QUMU CHIP CHCKER TP5551 1-694-766-21 TERMINAL (ONBOARD CONTACT) 7451 QUMU CHIP CHCKER TP5552 1-694-766-21 TERMINAL (ONBOARD CONTACT) KDX-46Q005 (UC) 6-102E...
Page 270 English Sony EMCS Corporation 2005LL08-Data Made in Japan Ichinomiya TEC  2005. 12 KDX-46Q005 (UC)

This manual is also suitable for:

Mbd-q005

Sony KDX-46Q005 Service Manual

1 Self Diagnosis Function

2 Disassembly

3 Diagrams

4 Exploded Views

Quick Links

Related Manuals for Sony KDX-46Q005

Summary of Contents for Sony KDX-46Q005

This manual is also suitable for:

Table of Contents