Installation Standard Work Checklist - Monessen Hearth AVFL60NIP Installation Manual

Installation Standard Work Checklist

This standard work checklist is to be used by the installer in conjunction with, not instead of, the instructions contained in this
installation manual.
Customer:
Lot/Address:
Model
(circle one):
AVFL60NIP, AVFL60PIP
WARNING! Risk of Fire or Explosion! Failure to install appliance according to these instructions could
lead to a fire or explosion.
Appliance Install Sections 2 and 4 (Pg. 5 & 12)
Verified that the chase is insulated and sealed.
Required non-combustible board is installed.
Verifi ed clearances to combustibles.
Fireplace is level ed and secured.
Adequate provisions for combustion and ventilation air have been verified.
Gas Section 5 (Pg 14)
Proper appliance for fuel type.
Leak check performed and inlet pressure verified.
Verified proper air shutter setting for installation type.
Electrical Section 6 (Pg 19)
Unswitched power (110-120 VAC) provided to the appliance.
Switch wires properly installed.
Glass & Stone Section 7 (Pg 22-25)
All packaging and protective materials removed (inside & outside of appliance).
Media installed correctly.
Glass assembly installed and secured.
Accessories installed properly.
Finishing Section 8 (Pg 27)
Combustible materials not installed in non-combustible areas.
Verifi ed all clearances meet installation manual requirements.
Finishing done correctly using inside fit or overlap fit method.
Bottom finishing template and finishing guards removed.
Mantels and wall projections comply with installation manual requirements.
Manual bag and all of its contents are removed from inside/under
the appliance and given to party responsible for use and operation.
Started appliance and veri ed no gas leaks exist.
Lights work in all switched positions (if so equipped).
Hearth & Home Technologies recommends the following:
• Photographing the installation and copying this checklist for your file.
• That this checklist remain visible at all times on the appliance until the installation is complete.
Comments: Further description of the issues, who is responsible (Installer/ Builder/ Other Trades, etc) and corrective
action needed _____________________________________________________________________________________
Comments Communicated to party responsible ____________________ by ______________________on ___________
 = Contains updated information.
ATTENTION INSTALLER:
Follow this Standard Work Checklist
(Builder / Gen. Contractor/) (Installer)
Monessen • AVFL60 Installation Manual • 4605-901 Rev. A • 05/17
Date Installed:
Location of Fireplace:
Installer:
Dealer/Distributor Phone #
Serial #:
Y E S F I N O
___________________________
___________________________
___________________________
___________________________
___________________________
___________________________
___________________________
___________________________
___________________________
___________________________
___________________________
___________________________
___________________________
___________________________
___________________________
___________________________
___________________________
___________________________
___________________________
___________________________
___________________________
___________________________
, W H Y ?
(Date)
4605-902A 05/17
3