Page 1
DTR-6.4 Ref. No. 3776 SERVICE MANUAL SERVICE MANUAL July, 2003 AV RECEIVER RC-534M DTR-6.4 MODEL Disc Audio Sel Muting Angle Subtitle TV / VCR Level Random Audio Adjust Input Selector Pure A Direct Stereo SURR All ST Re-EQ Search Display...
DTR-6.4 Specifications (DTR-6.4) AMPLIFIER SECTION TUNER SECTION Continuous average power output (FTC) 100 W per channel min. RMS at 8 Ω, All channels: Tuning range: 87.5–108.0 MHz (50-kHz steps) 2 channels driven from 20 Hz to 20 Usable sensitivity Ω...
DTR-6.4 SERVICE PROCEDURES 1. Replacing the fuses 3. Safety-check out (U.S.A. model only) After correcting the original service problem, perform the This symbol located near the fuses indicates that the fuse used is fast operating type. For continued protection against following safety check before releasing the set to the customer.
DTR-6.4 Index parts and facilities Here is an explanation of the controls and displays on the front panel of the DTR-6.4/5.4. DTR-6.4 Front panel DTR-5.4 Front panel...
Page 5
100-kHz increments for FM and 10-kHz increments for Standby indicator When FM is selected as the input source, you can hold down either Lights when the DTR-6.4/5.4 is in the standby state and when a the Tuning button and then release it to activate the auto- signal is received from the remote controller.
(Zone 2). When the Zone 2 indicator is The Rec Out and Zone 2 buttons allow you to use the DTR-6.4/5.4 off, then either output to the remote zone is turned off or Rec Out is to output to a remote zone (Zone 2) or to another component for selected.
DTR-6.4 Index parts and facilities Rear panel This illustration shows the DTR-6.4 shipped to the North American area. The number and shape of the terminals may be different depending on the model and shipping area. ANTENNA FM 75 COMPONENT VIDEO...
Page 8
This jack is for connecting a subwoofer with a built-in power ampliÞer. PRE OUT (FRONT/ SURR/ CENTER/ SURR BACK) (DTR-6.4 only) To use the DTR-6.4 as a preampliÞer, connect a power ampliÞer to these jacks. AC INLET This connector is for connecting the supplied power cord.
DTR-6.4 Index parts and facilities Remote controller RC-534M (for DTR-6.4) RC - 534M RCVR button Disc Audio Sel Muting Angle Subtitle TV / VCR Level Random Audio Adjust Input Selector Pure A Direct Stereo SURR All ST Re-EQ + 10...
Page 10
Press to display the Setup Menu on the TV screen and in the Press to set the sleep function. display. Press again to exit the menu. The Sleep button enables you to set the DTR-6.4/5.4 to turn off automatically after a specified time period. / / / , ENTER button...
DTR-6.4 Supplied accessories Check that the following accessories are supplied with the DTR-6.4/5.4. 75/300 antenna adapter AM loop antenna FM indoor antenna (Australian model only) Speaker Cable Remote controller Speaker cable label DTR-6.4: RC-534M Power cord Quick Setup Guide DTR-5.4: RC-517M...
Page 49
DTR-6.4 PRINTED CIRCUIT BOARD VIEW FROM SOLDERING SIDE 5 WHITE BLACK WHITE BLACK BLUE BLACK GREEN BLACK P6803 P6802 BLACK BLACK GREY BLACK BROWN BLACK J16A J15A P6803 C6856 C6840 P6802 P6804 C6846 C6853 C6842 RL6604 C6843 RL6600 C6851 C6852...
Page 51
DTR-6.4 PRINTED CIRCUIT BOARD 6-1 (U.S.A. model) C2092 VIDEO CIRCUIT PC BOARD (NAVD-7988) X201 C C 243 VD-7988 V V D-7988 V V D 7988 VD-7988 D 7988...
Page 52
DTR-6.4 PRINTED CIRCUIT BOARD VIEW 6-1 (U.S.A. model) R2092 R297 C218 C218 C218 VIDEO CIRCUIT PC BOARD (NAVD-7988)
Page 53
DTR-6.4 PRINTED CIRCUIT BOARD 6-1 (U.S.A. model) C2092 VIDEO CIRCUIT PC BOARD (NAVD-7988) C2 2 51 CVD-7988 137988B...
Page 54
DTR-6.4 PRINTED CIRCUIT BOARD 6-1 (U.S.A. model) R2092 R2092 R270 VIDEO CIRCUIT PC BOARD (NAVD-7988)
Page 55
DTR-6.4 PRINTED CIRCUIT BOARD VIEW 6-2 (Australian model) C297 7 C2 2 97 C2 2 34 Q224 VIDEO CIRCUIT PC BOARD Q205 (NAVD-7953) COMPONENT VIDEO PC BOARD 2 2 2 NCVD-7 NCVD NCVD-7 251379 251379 251379 (NAVD-7953)
Page 56
DTR-6.4 PRINTED CIRCUIT BOARD VIEW 7 C2227 7 C2227 R R 2 C225 5 C C 22 R226 6 R R 22 C2232 2232...
Page 57
DTR-6.4 PRINTED CIRCUIT BOARD VIEW 6-2 (Australian model) R2092 R2092 C297 34 4 Q224 Q224 VIDEO CIRCUIT PC BOARD C290 Q205 (NAVD-7953) C2092 COMPONENT VIDEO PC BOARD NCVD-7953 NCVD-7953 25137953 25137953 25137953 5 3 953 (NAVD-7953) C291 C291...
Page 59
DTR-6.4 PRINTED CIRCUIT BOARD VIEW FROM SOLDERING SIDE 8 7982 2 82 2 MAIN CONNECTOR PC BOARD (NAETC-7982) NCETC-79 L2821 2821 25137955 R2824 P2822 RS232 TERMINAL RS232 TERMINAL PC BOARD PC BOARD (NAETC-7955) (NAETC-7955)
Page 60
DTR-6.4 IC BLOCK DIAGRAMS AND DESCRIPTIONS TC74VHC74FT(Dual D-FF with preset and clear) INPUTS OUTPUTS FUNCTION 1CLR 2CLR CK D CLEAR PRESET CK D NO CHANGE X: Don't care TC74VHCT00AFT(2-input NAND gate) 74HC04F/TC74VHCU04FT(Hex Inverters) Truth table (TOP VIEW) TC7WU04F(3 Inverters) Truth Table...
Page 61
TX-SR501/E IC BLOCK DIAGRAMS AND DESCRIPTIONS BD3812F(Audio Sound Processor) OUT1 1ch input 1ch output AGND1 OUT2 Analog ground 2ch output 2ch input Serial data select AGND2 DGND Analog ground Comparator ground MUTE (-)Power supply Mute AGND3 LOGIC Analog ground Serial data (+)Power supply Serial clock CS5333(24-Bit, 96 kHz Stereo A/D Converter)
Page 62
DTR-6.4 IC BLOCK DIAGRAMS AND DESCRIPTIONS BD3811K1(6ch Volume with 8ch input selector) No. Terminal Description INDSPSL DSP surround Lch input terminal INDSPC DSP center input terminal INDSPSW DSP sub woofer input terminal I N 3 1 T N F 2...
Page 63
DTR-6.4 IC BLOCK DIAGRAMS AND DESCIRPIONS CS5333(24-Bit, 96 kHz Stereo A/D Converter) Interface Power Reset Master Clock MCLK Quiescent Voltage Serial Clock SCLK AINL Left Channel Analog Input Serial Data Output SDATA AINR Right Channel Analog Input Analog Power REF-GND...
Page 65
DTR-6.4 IC BLOCK DIAGRAMS AND DESCRIPTIONS LC74763-9836(On-screen and controller) 8 BITS SERIAL LATCH PARALLEL COMMAND CONVERSION DECODER INDICATOR HORIZONTAL HORIZONTAL VERTICAL ON/OFF RAM WRITE VERTICAL SCLK CHARACTER INDICATION INDICATION INVERSION CHARACTER CONTROL ADDRESS POSITION POSITION CONTROL SIZE SIZE REGISTER REGISTER...
Page 67
DTR-6.4 IC BLOCK DIAGRAMS AND DESCRIPTIONS MM1512(Y-C mixer circuit) TK15420(Operation amplifier) OUT A Bias OUT B -IN A 12dB Clamp -IN B +IN A -6dB +IN B TC90A69F(Comb Filter IC) PLL DET VCO I CBUS 4fsc 8fsc 8fsc CORING V-ENHANCER CORING Ped.
DTR-6.4 IC BLOCK DIAGRAMS AND DESCRIPTIONS TA1270BF(PAL/NTSC Video Chroma and Sync. Processing system for PIP/POP/PAP) DAC2 Y OFFSET PEDESTAL I C BUS PEDESTAL CLAMP TEST CONTROL CLAMP DAC1 SW GND DAC1 SUB- Y DL CONTRAST OFFSET HI:2CH/LOW:24h Y IN ADRS SW...
Page 69
DTR-6.4 IC BLOCK DIAGRAMS AND DESCRIPTIONS TC9164AF(Function switch) COM1 COM1 COM2 COM2 COM3 COM3 DATA SHIFT REGISTER Symbol Pin No. Function Negative power supply Ground Positive power supply 2,3,4,6,7,8,10,11 S1~S8 Input/output terminals 27,26,25,23,22,21,19,18 S1~S8 Input/output terminals 5,9,12 COM1 ~ COM3...
Page 70
DTR-6.4 MAIN MICROPROCESSOR CONNECTION DIAGRAM Q2253,4 TUNER PACK Q2272,3 FRONT/CENTER/SURROUND ZONE 2 MUTE BACK/SUBWOOFER CH. RL901 PREOUT PREOUT Q 9 2 1 P O W E R R E L A Y Q9503 Q5063,4,5073,4 Q400,3 -12V Q9504 ZONE 2 OUTPUT...
Page 71
DTR-6.4 MAIN MICROPROCESSOR Q5068,9 Q5078,9 ZONE 2 MUTE CONNECTION DIAGRAM PREOUT TRIGGER Q205 Q2203 VIDEO PAL/NTSC Q2005 CONTROL TRIGGER TWO INPUT COM FILTER SWITCH ONE OUTPUT TC90A69F TC9164AF YUV SWITCH 12V TRIGGER LC74763 ZONE 2 Q204 ON SCREEN VIDEO DEMODULATOR...
Page 73
DTR-6.4 MAIN MICROPROCESSOR TERMINAL DESCRIPTION Symbol I/O Description HPRL O Headphone relay control output pin YCSEPCLK O Not used. OSDCS O Serial communication chip select output pin for OSD IC Q204. OSDDA O Serial communication data output pin for OSD IC.
Page 74
DTR-6.4 MAIN MICROPROCESSOR TERMINAL DESCRIPTION Symbol Description DSP1BST Boot strap output pin for first DSP IC. ~DSP1HCS Serial communication clock output pin for Q302 and Q310. ~DSP1HACN Acknowledge input pin for first DSP IC. DSP1GP8 PCM information output pin for first DSP IC.
Page 75
DTR-6.4 TERMINAL DESCRIPTION SUB MICROPROCESSOR Pin No. Symbol I/O Description Pin No. Symbol I/O Description Power supply terminal. Connect to 5V. Segment output terminal of P22. Ground terminal. Segment output terminal of P21. Ceramic oscillator connection terminals for main system.
DTR-6.4 ADJUSTMENT AND CONFIRMATION PROCEDURES 1 Idling current adjustment Before Idling adjustment, turn the trimming resistors R6040 to R6045 to counter clockwise. Connect the DC voltmeter to sockets P6080 to P6085. After turn POWER to ON, adjust the trimming resistors R6040, R6041 and R6042 so that the reading of voltmeter becomes 2.5 mV.
DTR-6.4 ADJUSTMENT AND CONFIRMATION PROCEDURES 2 3. Confirmation of Current detection circuit Set the unit to "Test-1-00". Connect the differentiating circuit and apply the 50Hz square signal to DVD INPUT terminal of each channel. Adjust the attenuator or Volume so that the output level becomes 35V p-p.
EXPLODED VIEW-PARTS LIST NOTE: THE COMPONENTS IDENTIFIED BY MARK ! ARE CRITICAL FOR RISK OF FIRE AND ELECTRIC SHOCK. REPLACE ONLY WITH PART NUMBER SPECIFIED. CAUTION: Replacement for transistor of mark *, if necessary must be made from the same beta group (h ) as the original type.
Page 80
REF.NO. PART NO. DESCRIPTION F9501 252160 or 2.5A-UL/T-237 or 252254 2.5A-T/UL-ST2,Fuse <D> 252075, 2.5A-SE-EAK, 252241 or 2.5A-SE-TL250V or 252275 2.5A-SE-TL250V, Fuse <A> P101 2047152522 NCFC7-152522,Flexible cable P6931 2045133012 NCFC5-133012,Flexible cable P7501 2045081512 NCFC5-081512,Flexible cable P7502 2047111512 NCFC7-111512,Flexible cable P901 253297KAW or ! AS-UC-2 or 253352TES AS-UC-2,Power supply cord <D>...
Page 81
REF.NO. PART NO. DESCRIPTION 1A972575-1H NAPS-7975-1H, Constant voltage circuit PC board ass'y <D> 1A972575-1I NAPS-7975-1I, Constant voltage circuit PC board ass'y <A> 1A972576-1D NAETC-7976-1D, PC board for holder <D> 1A972576-1E NAETC-7976-1E, PC board for holder <A> 1A972577-1H NAETC-7977-1H,Primary terminal PC board ass'y <D> 1A972577-1I NAETC-7977-1I,Primary terminal PC board ass'y <A>...
Page 82
DSP CIRCUIT PC BOARD (NADG-7952-2B/2C) CIRCUIT NO. PART NO. DESCRIPTION Q110,Q111 22241383R2 or NJM4565M-D or Q300 22240581R2 NJM4565M Q113,Q114 22241943R2 CS5333-KZ Q301 22241787R3 TC9274F-020 Q302 22241761R3 BD3811K1 Q303~Q306 22241383R2 or NJM4565M-D or 22240581R2 NJM4565M Q307,Q308 22241383R2 or NJM4565M-D or 22240581R2 NJM4565M Q309,Q310 22241785R2...
Page 83
Q9504 or 2212855 2SB1068-U Q9505 2214470R2 or RN1402 or 2216190R2 KRC102S Q9507 2202314 or 2SA1726-Y or 2202315 2SA1726-P Q9511 2214530R2 or RN2402 or 2216220R2 KRA102S Diodes D101~D108 223234R2 or 1SS352 or D300,D300 223269R2 1SS355 D7001~D7003 223234R2 or 1SS352 or D7005 223269R2 1SS355 D7004...
Page 89
Q7502 22241971R3 MPD780232GC-085-8BT Remote sensor U7501 241348 RPM7138-H9 Transistors Q7503 2216175R2 or KTC3875-GR or 2213145R2 2SC2712-GR Q7504 2216230R2 or KRA103S or 2214540R2 RN2403 Q7505 2216190R2 or KRC102S or 2214470R2 RN1402 Q7581 2216190R2 or KRC102S or 2214470R2 RN1402 Q7582 2216190R2 or KRC102S or 2214470R2 RN1402...
Page 90
R7592 49163104412 RM1/10IJ-100K*12,Array Relay RL7701 25065610 or NRL-2P1A-DC4.5-156 or 25065645 NPL-2P1A-DC4.5-169 Switches S7611~S7618 25035699 or NPS-111-S662 or S7621~S7624 25035714 NPS-111-S677 S7619 25035699 or NPS-111-S662 or S7619 25035714 NPS-111-S677 S7625 25035699 or NPS-111-S662 or S7625 25035714 NPS-111-S677 S7626~S7628 25035699 or NPS-111-S662 or S7631~S7638 25035714 NPS-111-S677...
Page 91
P2553 25045678 NPJ-3PDB475 Sockets P209C 2009990792UL NSAS-10P1159 P2501C 2009990513UL NSAS-6P0675 P2554 25051569 NSCT-4P1356 FRONT OPTICAL INPUT PC BOARD (NADG-7964-1C) CIRCUIT NO. PART NO. DESCRIPTION Photo coupler U2601 24120108 GP1FA513RZ Coil L2601 231237M022R2 NCH-1471 Capacitor C2601 394621017 or CE04W6.3V-100M(VR) or 394721017 CE04W6.3V100M(SC),Elect.
Page 92
2215886, KTA1268-BL, 2211793 or 2SA992-E or 2211792 2SA992-F Diodes D6000~D6005 223163, 1SS133, D6010~D6015 223205 or 1SS270A or D6306,D6307 223222 WG713A D6701,D6702 223163, 1SS133, D6906 223205 or 1SS270A or 223222 WG713A D6703,D6704 224470512 MTZJ5.1B D6707 224470512 MTZJ5.1B D6904,D6905 22380337 D10XB60H Capacitors C604~C6045 394684707 CE04W50V-47M(VR),Elect.
Page 95
F903C 29361747 T2.5AL250V CONSTANT VOLTAGE CIRCUIT PC BOARD (NAPS-7975-1H/1I) CIRCUIT NO. PART NO. DESCRIPTION Q9001 222780565JRC NJM78M56FA Transistor Q9002 2215975 or KTA1266-GR or Q9002 or 2211455 2SA1015-GR Diodes D9001~D9004 22380260 or RL1N4003 or D9009~D9011 22380035 GP104003E D9005 22380271, D3SBA20, 22380285 or RS403M or 22380022 RBV402...
Page 96
Transistors Q2901 2215960 or KRC102M or 2213290 DTC114ES Q2902 2212855 or 2SB1068-U or Q2908,Q2909 2212853 2SB1068-K Q2904,Q2905 2215960 or KRC102M or Q2906,Q2907 2213290 DTC114ES Capacitors C2902 394642217 or CE04W16V-220M(VR) or 394742217 CE04W16V220M(SC),Elect. <D> C2903 394621017 CE04W6.3V-100M(VR),Elect. C2904 374722234 ECQ-B50V-223J,Plastic C2905 394644707 or CE04W16V-47M(VR) or 394744707...
Page 97
2211733 2SC1845-E Q5020~Q5022 2211793 or 2SA992-E or 2211792 2SA992-F Q5030~Q5032 2202094 or 2SA1360-Y or 2202093 2SA1360-O Q5033~Q5035 2215844, KTA1024-Y, 2215843, KTA1024-O, 2211354 or 2SA949-Y or 2211353 2SA949-O Q5040~Q5042 2202104 or 2SC3423-Y or 2202103 2SC3423-O Q5043~Q5045 2215854, KTC3206-Y, 2215853, KTC3206-O, 2211634 or 2SC2229-Y or 2211633 2SC2229-O...
Page 98
P308A 25055156 NPLG-12P140 P309A 25055147 NPLG-3P131 P6011B 27141859 (BUS-U) VIDEO CIRCUIT PC BOARD (NAVD-7988-1B) U.S.A. model only CIRCUIT NO. PART NO. DESCRIPTION Q2001 22241858R2 MM1093NF Q2005 22241850R2 TC90A69F Q201~Q203 22241946R2 NJM2595M Q204 22241779 LC74763-9836 Q205 22241221R2 TC9164AF Q2051 22241443R2 TK15420M Q206 22241849R2 MM1512...
Page 99
394721017 CE04W6.3V100M(SC),Elect. C2003 394680227 or CE04W50V-2.2M(VR) or 394780227 CE04W50V2.2M(SC),Elect. C2007 394680477 or CE04W50V-4.7M(VR) or 394780477 CE04W50V4.7M(SC),Elect. C2012,C2032 394684797 or CE04W50V-0.47M(VR) or 394784797 CE04W50V0.47M(SC),Elect. C2015,C2016 394644707 or CE04W16V-47M(VR) or C203 394744707 CE04W16V47M(SC),Elect. C2021,C2033 394621017 or CE04W6.3V-100M(VR) or C2034 394721017 CE04W6.3V100M(SC),Elect. C2022 375521044 MMT50V-104J,Plastic C2023...