Page 1 Internal Use Only Service Manual LG-P970 Date: April, 2011 / Issue 1.0...
Page 2: Table Of Contents
4. SIGNAL PATH ..................107 4.3 Checking TCXO Block .................109 4.4 Checking GSM TX Module(GSM PAM + FEM) Block ....111 LGE Internal Use Only - - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 4 • When returning system boards or parts like EEPROM to the factory, use the protective package as described. LGE Internal Use Only - 4 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 5: Abbreviations
International Portable User Identity Intermediate Frequency Liquid Crystal Display Low Drop Output Light Emitting Diode OPLL Offset Phase Locked Loop 6/140 LGE Internal Use Only - 5 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 6 UART Universal Asynchronous Receiver/Transmitter Voltage Controlled Oscillator VCTCXO Voltage Control Temperature Compensated Crystal Oscillator Wireless Application Protocol 7/140 LGE Internal Use Only - 6 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 7: Performance
Part Name Comment Digital Baseband PMB9801 : Infineon Analog Baseband PMB9801 : Infineon One chip RF Chip PMB5703: Infineon LGE Internal Use Only - 7 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 8: Hw Features
E2 (DCS) GPRS compatibility GPRS Class 12 EDGE compatibility EDGE Class 12 SIM card type Plug-In SIM 2.85V /1.8V LGE Internal Use Only - 8 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 9 Voice Recording Speaker Phone mode Support Travel Adapter CDROM Stereo Headset Data Cable T-Flash Up to 32GB (External Memory) LGE Internal Use Only - 9 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 10: Sw Features
Last Missed Number There is no limitation on the number of items. It depends on available memory amount. LGE Internal Use Only - 10 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 11 Send / Receive / Save Long Message MAX 459 characters SMS 3pages Cell Broadcast Download Over the Web Game Calendar LGE Internal Use Only - 11 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 12 FM radio GPRS Class 12 EDGE Class 12 Hold / Retrieve Conference Call Max. 6 DTMF Memo pad LGE Internal Use Only - 1 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 14: Hw Spec
: -98dBm/-96dBm (2.439%) AM Suppression -98dBm/-96dBm (2.439%) GSM : -31dBm DCS : -29dBm Timing Advance ± 0.5T LGE Internal Use Only - 14 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 15 < 17.5 %, when Pout ≥ -20 dBm Peak Code Domain Error < -15 dB at Pout -20 dBm LGE Internal Use Only - 15 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 16 +1.5/4 Inner Loop Power Control -0.5/+0.5 -0.5/+0.5 -0.5/+0.5 In Uplink -0.5/-1.5 -1/-3 -1.5/-4 group(10equal command group) +8/+12 +16/+24 LGE Internal Use Only - 16 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 17 Power Ratio (ACLR) > 43 dB @ ±10 MHz Error Vector < 17.5 %, when Pout ≥ -20 dBm Magnitude LGE Internal Use Only - 17 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 18 Sub-Test : 1=11/15, 2=6/15, 3=15/9, 4=2/15, 5=15/15 Leakage > 33 dB @ ±5 MHz Power Ratio (ACLR) > 43 dB @ ±10 MHz LGE Internal Use Only - 18 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 19 ≥ -10dBm(1Mbps,2Mbps,5.5Mbps,11Mbps) @ FER ≤ 8% Rx Adjacent Channel ≥ 35dB @FER ≤ 8%, Rejection interference input signal -70dBm@fc±25MHz(11Mbps) LGE Internal Use Only - 19 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 20 ACR shall be measured by setting the desired signal's strength 3 dB above the rate-dependent sensitivity specified in min input sensitivity LGE Internal Use Only - 0 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 21 ACR shall be measured by setting the desired signal's strength 3 dB above the rate-dependent sensitivity specified in min input sensitivity LGE Internal Use Only - 1 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 22 (DRX = 1.28) Low Pwr mode) 350 hours over 250 min over (Paging Period = 9) (TX Level = Max) LGE Internal Use Only - - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 23 2. PERFORMANCE 12) Charging hour 3.5hour under ( 1500mAh battery, 1A TA) LGE Internal Use Only - 3 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 24: Battery Bar
4% ~ 15% : One Time popup (No call) Critical Low Battery Pop-up 0% ~ 3% : Every Level change popup (No call) POWER OFF LGE Internal Use Only - 4 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 25: Technical Brief
3. TECHNICAL BRIEF 3.1 GENERAL DESCRIPTION The LG-P970 supports UMTS-900, UMTS-1900, UMTS-2100, GSM-850, GSM-850, GSM-900, GSM-1800, and GSM- 1900 based GSM/GPRS/EDGE/UMTS. All receivers and the UMTS transmitter use the radioOne1Zero-IF architecture to eliminate intermediate frequencies, directly converting signals between RF and baseband. The quad-band GSM transmitters use a baseband-to-IF upconversion followed by an offset phase-locked loop that translates the GMSK-modulated or 8-PSK-modulated signal to RF.
Page 26 PA, the complete loop circuits are implemented in the digital domain, which enables a high reliability of the loop performance for both standards. LGE Internal Use Only - 6 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 27 The AFC control is maintained by providing a voltage generated by a 12-Bit DAC to the external TCVCXO module, which means the reference clock is synchronized to the system frequency. LGE Internal Use Only - 7 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 28: Gsm Mode
(1 dB step) analog switch RF filter mixer buffer baseband filter [Figure 3-2] 2G Receiver Line Up-GSM Single Mode Setup LGE Internal Use Only - 8 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 29 The downconverted baseband outputs are multiplexed and routed to lowpass filters (one I and one Q) having passband and stopband characteristics suitable for GMSK or 8-PSK processing. These filter circuits include DC offset corrections. LGE Internal Use Only - 9 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 31: Umts Mode
The range and gain step of the following buffer amplifier is actually determined by the needs of the AGC in 3G mode. LGE Internal Use Only - 31 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 32: Umts Transmitter
AC / OC NZsh time adj. 1 bh sign DC offset comp CORDIC Word [Figure 3-6] 3G Transmitter Line Up LGE Internal Use Only - 3 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 33: Gps Receiver
LNA is sent to an I/Q mixer, which uses a local Oscillator to directly down-convert the signal to an IF Near 6MHz. LGE Internal Use Only - 33 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 34 5 3 2 L804 C807 U802 100n 0.5p C808 1.8p Fig3.8. The Schematic of GPS RF path circuit of P970 LGE Internal Use Only - 34 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 35 VSSC3 1.8V_VIO 1.8V_VIO C811 C812 C813 2.2u 2.2u 2.2u Fig3.9. The Schematic of GPS main circuit of P970 LGE Internal Use Only - 35 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 36 GPS LNA. The impedance transformer circuit topology is shown in Figure 3.10. [Figure 3.10] GPS Input Network Topology LGE Internal Use Only - 36 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 37: Lo Generation And Distribution Circuit
VCO. The RX synthesizer is in UMTS RX block working with the 3G RX VCO. [Figure 3-6] RF Synthesizer (GMSK/8-PSK and UMTS) LGE Internal Use Only - 37 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 38 To cover the wide frequency range the VCOs are automatically aligned by a binary automatic band selection before the settling process of the synthesizer starts. LGE Internal Use Only - 38 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 39: Off-Chip Rf Components
(hetero-junction Bipolar Transistor) MMIC (microwave monolithic integrated circuit) technology offering state- of-the-art reliability, temperature stability and ruggedness. [Figure 3-7] ACPM5281 (W2100,W900) [Figure 3-8] ACPM-5202(W1900) LGE Internal Use Only - 39 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 40 (hetero-junction Bipolar Transistor) MMIC (microwave monolithic integrated circuit) technology offering state- of-the-art reliability, temperature stability and ruggedness. [Figure 3-7] ACPM5281 (W2100,W900) [Figure 3-8] ACPM-5202(W1900) LGE Internal Use Only - 40 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 42 LINEAR RF VDET DETECTOR POWER VRAMP RxTx-M1 CONTROL Rx-L1 Tx_LB Match RxTx-L V-Q3_LB Batt [Figure 3-10] SKY77529 Block Diagram LGE Internal Use Only - 4 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 43 The ALM1612 is packaged in a compact 3.3 mm x 2.1 mm x 1.2 mm package with low external component count required to achieve the best-in-class performance. LGE Internal Use Only - 43 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 44: Digital Baseband(Dbb/Msm77)
-General purpose times ( eleven GP timers ) -Two Watchdog timers / 32 kHz clock timer - Six 32-bit GPIO controllers LGE Internal Use Only - 44 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 45 -High speed interface to SIM & USB 2.0 HS -Package size : 8 × 8 × 0.8 mm, 0.4 mm pitch LGE Internal Use Only - 45 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 46: Hardware Architecture
Audio DP/DN USB DP/DM tWL Subsystem TWL5034 Charger EAR_MIC MUIC MAX17040 Battery Fuel gauge (1500mAh) Figure. Block Diagram LGE Internal Use Only - 46 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 47 RX_L1 RX SAW RX_L2X 2.85V RF2 2.85V_RF2 VRF2 VDD_FSYS 1800 RX_M1 RX_M3 RX SAW 1.8V_SD RX_M1X VDD_IO VSD2 LGE Internal Use Only - 47 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 48: Subsystem (Msm77)
– Access from the crossbar via the 3G_MACOM slave interface – Access from the 3G modem controller subsystem via the 3G_MEMIF bus LGE Internal Use Only - 48 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 49 – Access to the SBRAM1 performing framewise storage of the demodulated coded composite transport channels via the dedicated bus system LGE Internal Use Only - 49 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 50 – Access from the 2G side for 2G data read and write access to and from the RF side LGE Internal Use Only - 50 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 51 It is tightly coupled to the Master Chip Control Functions of the 2G subsystem in the X-GOLD™618. LGE Internal Use Only - 51 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 52 • Supporting HSUPA category 6, up to 5.8Mps. • Robust Header Compression (RoHC). • Fractional DPCH. • WB-AMR Support. LGE Internal Use Only - 5 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 53: Gsm Subsystem
• EGPRS class 33 support for modulation and coding schemes MSC1..MSC9 • Incremental redundancy (ARQ2) for EGPRS • Dual transfer mode (DTM) class 33 LGE Internal Use Only - 53 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 54 • SAIC / DARP • Repeated FACCH and repeated SACCH • A-GPS Support • Support for WB-AMR • GPRS ROHC LGE Internal Use Only - 54 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 55 The SPI is implemented using the USIF2 of the X-GOLD™616, with the GPIO’s implementing sleep mode and readiness handling LGE Internal Use Only - 55 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 56 ARM - remain purely digital audio processing. Refer to the document “system requirements specification” for more details on the different audio application features supported by the chip. LGE Internal Use Only - 56 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 57: Vocoder Subsystem
HW. This is sufficient for a modem only design where charging is controlled by another chip LGE Internal Use Only - 57 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 58 • UICC-Terminal USB interface according to ETSI TS 102 600 (ICCD only) •Suspend/Resume and Remote Wakeup (for power saving) LGE Internal Use Only - 58 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 59: Power Block
1G / 512Mb 2 85v SiM 2.85v_SiM vDD vSiM vDD_vSiM USIM For Infineon (7mA) Figure. LGP970 Modem Power Block Diagram LGE Internal Use Only - 59 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 60 Charging IC (MAX14526DeeWP) Battery iNt : 1.8v_vio RT9524 1500mA/h USB_vBUS[4.9v, 60mA] CHGSB : 1.8v_vio Figure. TWL5034 functional block diagram LGE Internal Use Only - 60 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 61 Programmed Charging Current Under Voltage Lockout Over Voltage Protection Thermal Feedback Optimized Charge Rate RoHS Compliant and Halogen Free LGE Internal Use Only - 61 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 62 The RT9524 offers ISET pin to program the charge current. The resistor R is connected to ISET and GND. The ISET parameter K is specified in the specification table. ISET LGE Internal Use Only - 6 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 63 -Nominal Battery Capacity : 1500mAh -Charging time : Max. 3h 30m - Full charge indication current (icon stop current) : 156mA LGE Internal Use Only - 63 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 64 Critical Low Battery Pop-up 0% ~ 3% : Popup at every level change POWER OFF Table. LGP970 battery bar specification LGE Internal Use Only - 64 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 65: External Memory Interface
3.11.4. External SD card memory Interface TI OMAP3630 supports external SD card which supports up to 32GB (SDHC compatible) LGE Internal Use Only - 65 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 66: H/W Sub System
SPI(SPI_CLK, SPI_SS, SPI_DRW) : FEM Control Interface - LNA Control LNA_CTRL1, LNA_CTRL2, LNA_CTRL3, LNA_CTRL4 : LNA Control Output LGE Internal Use Only - 66 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 67 2.85V RF2 2.85V_RF2 VRF2 VDD_FSYS 1800 RX_M1 RX_M3 1.8V_SD RX SAW RX_M1X VDD_IO VSD2 Figure. RF Interface Block Diagram LGE Internal Use Only - 67 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 68 * CLK_IN : Crystal amplifier input or frequency reference input. * CLK_REQ : Crystal Circuit / Reference Clock Enable (active-high) LGE Internal Use Only - 68 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 70 - GPS PWR_ON : Used as a control signal for enabling Deep Sleep mode. Figure. GPS Interface Block Diagram LGE Internal Use Only - 70 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 71 Main display TWL50xx WVGA S-VIDEO Y/C Subdisplay TI – TSC200x Touchscreen controller Display subsystem intro_177-001 Introduction SWPU176A – October LGE Internal Use Only - 71 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 72 External and stacked memories L4 interconnect (wake-up) GPTIMER1, WDT2, GPIO1, 32KTIMER External peripherals ports memmap-001 SWPU176A – October 2009 Memory Mapping LGE Internal Use Only - 7 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 73 SMPS SR_MPU interrupt MPU INTC VP_MPU interrupt Voltage command Voltage Voltage processor interface interface controller Acknowledge DATA PRCM LGE Internal Use Only - 73 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 74 If one or another of the interfaces is enabled, then the camera input signals will be automatically routed to the corresponding ISP receiver depending on the PHY operating mode settings (SCM.CONTROL_CAMERA_PHY_CTRL register) LGE Internal Use Only - 74 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 75: Display Modes
• Programmable pixel display modes (1, 2, 4, 8, 12, 16, and 24 bits-per-pixel [BPP] modes) LGE Internal Use Only - 75 - Copyright © 011 LG Electronics. Inc. All right reserved. • Programmable display size supported: Only for training and service purposes...
Page 76 TX FIFO by writing to the I2Ci.I2C_DATA[7:0] DATA bit field. LGE Internal Use Only - 76 - Copyright © 011 LG Electronics. Inc. All right reserved. 2862 SWPU176A – October 2009 Multimaster High-Speed I...
Page 77 • Baud generation based on programmable divisors N (N = 1 ... 16,384) operating from a fixed functional 2938 UART/IrDA/CIR SWPU176A – October 2009 LGE Internal Use Only - 77 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 78 • Up to four master channels or single channel in slave mode LGE Internal Use Only • Master multichannel mode: - 78 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes – Full duplex/half duplex – Transmit-only/receive-only/transmit-and-receive modes...
Page 79 12 pins ULPI Channel 2 usb-035 3280 High-Speed USB Host Subsystem and High-Speed USB OTG Controller SWPU176A – October 2009 LGE Internal Use Only - 79 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 80 Wakeup from mmc3_dat1 pin (SDIO interrupt) using GPIO GPIO Wakeup from mmc1_dat1 pin (SDIO interrupt) using GPIO mmchs-001 LGE Internal Use Only - 80 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 81 The module provides an alternative to the atomic test and set operations for the following registers: • GPIOi.GPIO_DATAOUT LGE Internal Use Only - 81 - Copyright © 011 LG Electronics. Inc. All right reserved. • GPIOi.GPIO_IRQENABLE1 Only for training and service purposes •...
Page 82: Audio And Sound
3. TECHNICAL BRIEF 3.13 Audio and sound 3.13.1 Overview of Audio path Figure. Block diagram of Audio & Sound path LGE Internal Use Only - 8 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 83 – Left/right paths switch on hands-free speaker and predriver for external class D amplifier. – Differential H-bridge driver for Vibrator. LGE Internal Use Only - 83 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 84 Option 1: Four simultaneous multimedia analog channels (four multimedia digital-to-analog converters LGE Internal Use Only - 84 - Copyright © 011 LG Electronics. Inc. All right reserved. (DACs) and no modem voice path), and two simultaneous analog-to-digital converters or 4 channels Only for training and service purposes coming from digital microphones.
Page 85: Functional Description
Figure. Detailed diagram of TWL5034 audio interface SWCU051F – March 2008 – Revised July 2010 Audio LGE Internal Use Only - 85 - Copyright © 011 LG Electronics. Inc. All right reserved. Copyright © 2008–2010, Texas Instruments Incorporated Only for training and service purposes...
Page 86 The WM9093 is available in a 2.0mm × 2.5mm 20-bump CSP package. Figure. Detailed diagram of WM9093 audio interface LGE Internal Use Only - 86 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 87: Audio Subsystem
I2C2_SCL 1.8V_AUDIOAMP I2C2_SDA R610 EAR_GND MIC Switch VBAT U610 MIC_P MIC1P MIC_SEL MIC2P MIC_N MIC1N MIC2N C690 2.2u LGE Internal Use Only - 87 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 88 3. TECHNICAL BRIEF EAR DETECTION (Close to Connector) Q601 1.8V_VIO EAR_SENSE EAR_DETECT HOOK 1.8V_VIO 1.8V_VIO U602 VIN- HOOK_DIG VIN+ HOOK_ADC LGE Internal Use Only - 88 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 89: Display
LCD_BL_OUT2 LCD_BL_OUT7 LCD_BL_OUT1 LCD_BL_OUT6 LCD_BL_OUT5 C720 C715 C714 4.7u 2.2u 2.2u Figure. Schematic of LCD connector (Main Board) LGE Internal Use Only - 89 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 90 Negative MIPI Data1 Input / Output MDATA0_M MDATA0_P Positive MIPI Data1 Input / Output MDATA0_P Table. Interface between LCD Module and MAIN Board LGE Internal Use Only - 90 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 91 Note(1): IOVcc is the reference voltage for adjusting the I/O signal level of TA8851A. IOVcc voltage must be determined according to a customer’s system. Table. LCD Module general data LGE Internal Use Only - 91 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 92 Table. LCD Module block diagram Hitachi Displays, Ltd. Date Nov. 04, 2010 3284PS 2607 - TX10D10VM0EAA-1 Page 7-1/1 LGE Internal Use Only - 9 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 93: Main (5M Pixels) & Sub (M Pixels) Camera
3. TECHNICAL BRIEF 3.14 Main (5M pixels) & Sub (2M pixels) Camera 3.15 LG-P970 supports two cameras. One is 5M pixels, main camera, the other is 2M pixels, sub camera used VT & self camera scene. 1.2V_5M_VDIG FL601 2.7V_5M_VANA 5M_MIPI_CLK_N 5M_MIPI_CLK_P 1.8V_5M_VIO...
Page 94 VINTUSB1P5_OUT VUSB_3P1 C463 VINTDIG_OUT C482 VRTC_OUT C483 VINTANA2_OUT_02 3.1V_VUSB VINTANA2_OUT_01 C484 VINTANA1_OUT C485 Figure. 5M Camera PMIC Schematic LGE Internal Use Only - 94 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 95 2.8v_5M_vCM reSet_N 1.2v_5M_vDiG i2C3_SDA i2C3_SCL i2C3_SDA i2C3_SCL vt_MCLK vt_CAM_Drv_2.8v vt_PCLK vt_CAM_io_1.8v vt_DAtA[0:7] vt_vSYNC vt_HSYNC Figure. Camera Block diagram LGE Internal Use Only - 95 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 96: Vibrator
The ERM motor, also distinguished as ‘Q-coin Motor’ creates a certain kind of vibration controlled and defined uniquely by LG Electronics. The followings are the certain examples of conditions that the users may feel the vibration from the phone: Incoming Call (in Silence Mode), Google Keys Pressed, Turn-on / -off, Dialing, and Text Messaging.
Page 97: Compass Sensor
Timing Control Voltage Reference Magnetic source DRDY FUSE ROM CAD0 CAD1 TST1 TST TST6 Figure. Compass Sensor Block Diagram LGE Internal Use Only - 97 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 98: Motion Sensor
Figure. Motion Sensor Schematic Senser Charge Amp Senser Senser Digital IO Vdd Filter Digital Engine Figure. Motion Sensor Block Diagram LGE Internal Use Only - 98 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 99: Gyro Sensor
The gyro sensor(MPU3050) can sense angular velocity not gravity and accelerated motion. The gyro sensor applied in LG- P970 can detect 3-axis rotation force sensing X,Y and Z angular velocity. And the gyro sensor data is supplemented by the motion sensor data. It make possible user to development application SW using gyro sensor data like that motion games.
Page 100: Proximity Sensor
I2C3_SDA LEDC C105 VOUT PROX_OUT C107 C106 0.1u 4.7u Figure. Proximity Sensor Schematic Figure. Proximity Sensor Block Diagram LGE Internal Use Only - 100 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 101: Illumination Sensor
U101(VT_CAM FPCB) : BH1621 IC interface to AAT2870 U101 LSENSOR_SENS LSENSOR_BIAS IOUT GND1 Figure. Illumination Sensor Schematic Figure. Illumination Sensor Block Diagram LGE Internal Use Only - 101 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 102: Touch Module
I2C Data 3.0V TOUCH Power Supply for Driver IC TOUCH_INT_N Interrupt Table. Interface between Touch Module and MAIN Board LGE Internal Use Only - 10 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 103: Main Features
- Supports Bluetooth and HS-USB - Supports WLAN(802.11b, 802.11g, 802.11n) - Supports FM Radio - 1500 mAh (Li-Ion) LGE Internal Use Only - 103 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 104 Maker P/N: SDIN50-G Function: EMMC-MEMORY Maker P/N: BD81 Function: RGB LED DRIVER Maker P/N: OMAP 3630 Function: Application Processor LGE Internal Use Only - 104 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 105 Maker P/N: ACPM581-TR1G Maker P/N: RT954 Function: 3G Dual PAM Function: Charging IC Maker P/N: MAX17043 Function: Fuel gauge LGE Internal Use Only - 105 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 106: Trouble Shooting
U106 WCDMA (I,II,VIII) LNA FL110 WCDMA (I) Duplexer X101 TC-VCXO(26MHz) FL106 WCDMA (II) Duplexer U102 WCDMA Power Detector LGE Internal Use Only - 106 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 107: Signal Path
WCDMA 1900 TX PATH, WCDMA 900 TX PATH GSM Low Band Tx PATH, GSM Hign Band Tx PATH LGE Internal Use Only - 107 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 108 WCDMA 2100 RX PATH, WCDMA 1900/PCS RX PATH, WCDMA 900/EGSM TX PATH DCS Band Rx PATH, GSM 850 Band Rx PATH LGE Internal Use Only - 108 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 109: Checking Tcxo Block
4.3 Checking TCXO Block The output frequency (26MHz) of TCXO (X101) is used as the reference one of PMB5703 LGE Internal Use Only - 109 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 110 .45 ≤ VCC ≤ .6V Check the PMB5703 Check TP 6MHz signal Check soldering and components TCXO OK LGE Internal Use Only - 110 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 111: Checking Gsm Tx Module(Gsm Pam + Fem) Block
VCMOS RXTX_M1 C180 VRAMP GND5 GND_HB RX_M2 RX_1900 C185 DCS_PCS_TX RX_1800 TX_HB RX_M3 Schematic of the TX Module LGE Internal Use Only - 111 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 112: Lge Internal Use Only
Not Assigned to Specifiic Runction Rx/Tx-L Defaut Rx/Tx-M1 Rx/Tx-H Reserved Reserved Tx-M GMSK ANT Tx-L GMSK ANT Reserved LGE Internal Use Only - 11 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 113: Lge Internal Use Only
PAM Vbatt of Check TP1 .9V < VCC < 5V Replace the GSM Module(U104) Check the Logic in each mode LGE Internal Use Only - 113 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 114: Checking Wcdma Block
3. Check RF Tx Level 4. Check PAM Block Refer to 1.5.4 5. Check RF Level 6. Ro-download SW & Cal. LGE Internal Use Only - 114 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 115 Refer to 1.3 4.5.2. Checking FEM Block Refer to 1.4 4.5.3. Checking RF TX Level Test Point (TX Level) LGE Internal Use Only - 115 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 116 GND1 GND4 C194 C104 1950MHz GND2 GND5 GND3 GND6 1950MHz, 2140MHz For testing, Max power output is needed. LGE Internal Use Only - 116 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 117 Check PAM Block Refer to 1.5.4 PMB5703 Maximum output Power = 7 dBm PMB5703 minimum output Power = -73 dBm LGE Internal Use Only - 117 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 118: Checking Pam Block
(WCDW_PA_Mode(C162,C183):Low, WCDMA_PA_Mode2(C161,C184):Low), PAM OUT power must be over 21 dBm PAM IN power must be under 10 dBm LGE Internal Use Only - 118 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 119 VEN_LOW PA_EN_2100 GND1 VEN_HI RFIN_HI FL111 L115 C187 C188 TX3G_H_2100 2.7n L125 1.5n C192 C193 C194 C104 1950MHz LGE Internal Use Only - 119 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 120 RF Tx Level is OK Check TP PA_MODE ≥ 0.5V Check PMB5703 Check TP1 Over 10 dBm? Check PMB5703 Change the board LGE Internal Use Only - 10 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 121 C179 0.1u GND_SPI GND4 PA_RAMP VCMOS RXTX_M1 C180 VRAMP GND5 GND_HB RX_M2 RX_1900 C185 DCS_PCS_TX RX_1800 TX_HB RX_M3 LGE Internal Use Only - 11 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 122 RX_900_L1X Band8/EGSM L105 G1 O1 L106 4.7n L132 3.3n FL105 RFOUTL G2 O2 C133 8.2p C132 RX_900_L1 942.5MHz LGE Internal Use Only - 1 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 123 RFIN2 RFOUT2 C5028 U106 RFIN1 RFOUT1/4 RFOUTH C5026 RFOUTL RFGND1/2 RFOUT5 RFIN4 L120 2.7n LNA_CTRL1 LNA_CTRL2 L121 8.2n LGE Internal Use Only - 13 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 124 Check TP4 Signal exist? Check LNA Check TP5 Signal exist? Check PMB5703 and Rx SAW filter Change the board LGE Internal Use Only - 14 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 125: Checking Gsm Block
1. Check TCXO Block . Check ANT.SW Module 3. Check RF TRX Level 4. Ro-download SW & Cal. LGE Internal Use Only - 15 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 126: Checking Rf Tx Level
4.6.1 Checking TCXO Block Refer to 1.3 4.6.2 Checking FEM Block Refer to 1.4 4.6.3 Checking RF TX level LGE Internal Use Only - 16 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 127 4.6.1 Checking TCXO Block Refer to 1.3 4.6.2 Checking FEM Block Refer to 1.4 4.6.3 Checking RF TX level LGE Internal Use Only - 17 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 128 C179 0.1u GND_SPI GND4 PA_RAMP VCMOS RXTX_M1 C180 VRAMP GND5 GND_HB RX_M2 RX_1900 C185 DCS_PCS_TX RX_1800 TX_HB RX_M3 LGE Internal Use Only - 18 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 129 If DCS/PCS(TP3) over7 dBm? No Problem Check PMB5703 & PAD Check soldering and components Still exist Problem Change the board LGE Internal Use Only - 19 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 130: Checking Rf Rx Block
C179 0.1u GND_SPI GND4 PA_RAMP VCMOS RXTX_M1 C180 VRAMP GND5 GND_HB RX_M2 RX_1900 C185 DCS_PCS_TX RX_1800 TX_HB RX_M3 LGE Internal Use Only - 130 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 131 RX_900_L1X Band8/EGSM L105 G1 O1 L106 4.7n L132 3.3n FL105 RFOUTL G2 O2 C133 8.2p C132 RX_900_L1 942.5MHz LGE Internal Use Only - 131 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 132 Check TP1 Signal exist? Check RF Switch (M/S) Check TP Signal exist? Check FEM Block Refer 1.4 Change the board LGE Internal Use Only - 13 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 133: Gps/Wifi/Bt Rf Components
GPS Chip (BCM4751) U802 LNA Module (LNA + SAW) FL801 SAW Filter (1575MHz) X801 TCXO (26MHz) U405 LDO (150mA) LGE Internal Use Only - 133 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 134 WiFi/BT/FM Chip (BCM43291) U805 FEM Module (SP3T + LNA) FL802 Dielectric Filter (2450MHz) X802 TCXO (26MHz) U804 LDO (150mA) LGE Internal Use Only - 134 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 135: Gps/Wifi/Bt Signal Path
GPS UART to AP Figure. RF signal path of GPS on top side of the P970 bear board. LGE Internal Use Only - 135 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 136 WiFi / BT ANT. Figure. RF signal path of WiFi/BT/FM on top side of the P970 bear board. LGE Internal Use Only - 136 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 137: Power On Troubleshooting
AUDIOAMP(C460_TP6) → VDD1_CORE(L40_TP7) → VDD_CORE(L403_TP8) → 1.8V_VPLL1(C459_TP9) → OMAP_PWR_ 1.8V_AUDIOAMP(C460) VDD1_CORE(L402) VDD2_CORE(L403) 1.8V_VPLL1(C459) OMAP_PWR_RESET RESET goes high! goes high! LGE Internal Use Only - 137 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 138 Change the Main board Power up? is clock OK? Change the TCXO and X-tal X40: 3.768Khz Change the Main board LGE Internal Use Only - 138 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 139 (TP7) C459 (TP9) C460 (TP6) C452 (TP5) X601 L404 L403 (TP3) (TP8) TOP view of LGP970 R409 (TP1) LGE Internal Use Only - 139 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 140: Charger Troubleshooting
- Check the charger (TA or USB Cable) connector - Control the charging current by RT954 IC - Charging current flows into the battery LGE Internal Use Only - 140 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 141 After turning on? Check PMIC SMT status by X-ray Exchange PMIC or Change the main board and Retest LGE Internal Use Only - 141 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 142 4. TROUBLE SHOOTING TOP view of LGP970 C506 (TP1) C511 (TP2) U502 LGE Internal Use Only - 14 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 143: Usb Trouble Shooting
Block Diagram of USB & UART connection is shown below USB_DM_TWL USB_ID USB_ID USB_DP_TWL USB_DM USB_DM USB_DP USB_DP CN1001 U705 UART_RX CN904 UART_TX UART_RX_SW UART_TX_SW LGE Internal Use Only - 143 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 144 TP1(C50) is 5V? Lower FPCB damaged? Change Lower FPCB connector USB_D+ is 3.3V? Check U501 Change the Main board LGE Internal Use Only - 144 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 145 INT1 INT2 PWR_ON_SW PWRON PWR_WARM NRESWARM OMAP_PWR_RESET NRESPWRON C432 VREF SYSEN VBAT R407 BOOT0 BOOT1 R408 1.8V_VIO MSECURE LGE Internal Use Only - 145 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 147: Audio Trouble
Check the waveform of TP. Change the Main PCB Waveform is OK? Change the Audio codec IC Speaker sound OK LGE Internal Use Only - 147 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 148 TP101 SPK_P TP102 SPK_N VA103 VA104 FB601 SPK_P FB602 SPK_N R601 EAR_L R602 EAR_R C613 C614 0.1u 0.1u LGE Internal Use Only - 148 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 149: Receiver Troubleshooting
Check the waveform of TP. Change the USB FPCB Waveform is OK? Change the Main PCB Speaker sound OK LGE Internal Use Only - 149 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 150 4. TROUBLE SHOOTING CN104 RCV_P RCV_N ZD904 VA903 VA904 CN904 PWR_ON_SW USB_ID RCV_N RCV_P LGE Internal Use Only - 150 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 151 Check the TP1. Change the ANT. FPCB Bias range 1.8V~.V Change the Main PCB Voice recording is OK LGE Internal Use Only - 151 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 152 Main MIC MIC1P MIC1N MICBIAS MIC101 VA107 VA108 As close as to MIC, Not in the ANT Carrier LGE Internal Use Only - 15 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 153 Speaker phone call is OK? Check the TP1. Bias range 1.8V~.V Change the VCAM PCB Speaker phone call is OK LGE Internal Use Only - 153 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 154 VT_DATA[6] EAR_GND R917 VT_MCLK VT_DATA[5] R919 VT_CAM_IO_1.8V VT_DATA[4] R918 VT_PCLK VT_DATA[3] VT_CAM_PWDN VT_DATA[2] R913 VT_RESET_N VT_DATA[1] VT_DATA[0] C918 LGE Internal Use Only - 154 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 155 FPCB Waveform is OK? Check the Audio LDO or Audio subsystem IC or Main PCB All sounds OK LGE Internal Use Only - 155 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 156 VT_DATA[6] EAR_GND R917 VT_MCLK VT_DATA[5] R919 VT_CAM_IO_1.8V VT_DATA[4] R918 VT_PCLK VT_DATA[3] VT_CAM_PWDN VT_DATA[2] R913 VT_DATA[1] VT_RESET_N VT_DATA[0] C918 LGE Internal Use Only - 156 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 158: Camera Troubleshooting
DVDD(TP), AVDD(TP3) Check the camera signals MCLK(TP4), Change the main board MIPI_CLK(TP5), MIPI_DATA(TP6) Change the camera Camera is OK? LGE Internal Use Only - 158 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 159 1.8V_5M_VIO 5M_MCLK CN602 2.8V_5M_VCM FL602 5M_MIPI_DATA0_N 5M_MIPI_DATA0_P 5M_MIPI_DATA1_N 5M_MIPI_DATA1_P I2C3_SDA I2C3_SCL 5M_RESET_N 5M_CAM_VCM_EN C621 C622 C620 0.1u 4.7u LGE Internal Use Only - 159 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 160 VT_DATA[6] EAR_GND R917 VT_MCLK VT_DATA[5] R919 VT_CAM_IO_1.8V VT_DATA[4] R918 VT_PCLK VT_DATA[3] VT_CAM_PWDN VT_DATA[2] R913 VT_RESET_N VT_DATA[1] VT_DATA[0] C918 LGE Internal Use Only - 160 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 161: Main Lcd Trouble
LCD display OK? Check Power VCC_LCD_1V8 Change the LCD module VCC_LCD_V8 V_POWERALL Change the Main board The LCD works LGE Internal Use Only - 161 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 162 DSS_DATA5 DSS_DATA6 DSS_DATA7 DSS_DATA8 DSS_DATA9 AD28 DSS_DATA10 AD27 DSS_DATA11 AB28 DSS_DATA12 AB27 DSS_DATA13 AA28 DSS_DATA14 AA27 DSS_DATA15 DSS_DATA16 LGE Internal Use Only - 16 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 164: Sim Detect Trouble Shooting
.85V_SIM (TP1_C14) runs? Change the main board Change SUB FPCB Work well? Change SIM card Work well? Change Main board LGE Internal Use Only - 164 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 165 C216 100n 220n 220n 100n 220n 0.1u 220n 0.1u 0.1u C202 220n IPC_MRDY IPC_SRDY MODEM_AP_WAKE MODEM_WAKE MODEM_PWR_CHK MODEM_CHK LGE Internal Use Only - 165 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 166 PWR_ON_SW UART_RX_IFX SIM_RST SIM_CLK MICROSD_CMD SIM_IO MICROSD_CLK I2C3_SCL MICROSD_DAT0 I2C3_SDA MICROSD_DAT1 MICROSD_DAT2 KEY_C[0] MICROSD_DAT3 KEY_R[0] MICROSD_DET_N KEY_R[1] KEY_R[2] LGE Internal Use Only - 166 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 168: Side Key Trouble Shooting
(SUB FPCB) goes low when the key is pressed? LOWER FPCB damaged? Change LOWER FPCB Change the Main board LGE Internal Use Only - 168 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 169 4. TROUBLE SHOOTING R108 KEY_R[0] Vol. Up R109 KEY_R[1] Vol. Down R110 KEY_R[2] Gesture R111 KEY_C[0] LGE Internal Use Only - 169 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 170: Vibrator Troubleshooting
Check Haptic Feedback on the setting menu Vibration OK? Change the vibrator Check TP1(C517) Change the Main board Vibrator works LGE Internal Use Only - 170 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 172 4. TROUBLE SHOOTING 3.0V_MOTOR U504 VIBE_EN VIB_P VIBE_PWM MODE VIB_N GAIN C517 2.2u C519 R517 Q-Motor VB101 VIB_P VIB_N SJMY0007118 LGE Internal Use Only - 17 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 173: Motion Sensor Troubleshooting
Working or not?) Function is OK? Change the IC (U104) Function is OK? Change the SUB-FPCB Function is OK? LGE Internal Use Only - 173 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 174 C123 0.1u DNC3 1.8V_MOTION_VIO MOTION_INT DNC2 DNC1 DNC4 U104 IME_CL IO_VDD C118 0.1u IME_DA U104 (KXTF9) Motion Sensor LGE Internal Use Only - 174 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 175: Gyro/Compass Sensor Troubleshooting
Function is OK? Change the Gyro sensor IC (U103) Function is OK? Change the SUB-FPCB Function is OK? LGE Internal Use Only - 175 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 176 C120 0.1u 1.8V_MOTION_VIO 3.0V_MOTION C116 0.1u CAD0 3.0V_MOTION U105 CAD1 TST6 I2C3_SDA SDA/SI C117 0.1u 1.8V_MOTION_VIO C119 0.1u LGE Internal Use Only - 176 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 178: Proximity Sensor On/Off Trouble
SCL output & Prox_out Change the main board Work well? Measurement PROXI_VCC 1.8V_VIO PROXI_LEDA PROX_OUT (TP3) I2C3_SCL (TP1) I2C3_SDA (TP) LGE Internal Use Only - 178 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 179 4. TROUBLE SHOOTING 1.8V_VIO PROXI_VCC PROXI_LEDA U102 I2C3_SCL LEDA I2C3_SDA LEDC C105 VOUT PROX_OUT C107 C106 0.1u 4.7u LGE Internal Use Only - 179 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 180: Illumination Sensor On/Off Trouble
Check TP1, Change the VT_CAM FPCB (LSENSOR_BIAS/SENS) Change the main board Work well? Measurement LSENSOR_BIAS (TP) LSENSOR_SENS (TP1) LGE Internal Use Only - 180 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 182: Touch Trouble
Change the main board 1.8V TOUCH (TP) Change the touch module Work well? Measurement 3.0V TOUCH (TP1) 1.8V TOUCH (TP) LGE Internal Use Only - 18 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 183 4. TROUBLE SHOOTING 1.8V_TOUCH 3.0V_TOUCH 1.8V_TOUCH CN701 TOUCH_INT_N I2C2_TOUCH_SDA I2C2_TOUCH_SCL LGE Internal Use Only - 183 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 185 5. DOWNLOAD LG-P970 LG-P970 LG-P970 LG-P970 LG-P970 LG-P970 LG-P970 LGE Internal Use Only - 185 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 198 5. DOWNLOAD LG-P970 LG-P970 LG-P970 LG-P970 LG-P970 LG-P970 LG-P970 LG-P970 LG-P970 LG-P970 LG-P970 LGE Internal Use Only - 198 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 203: Block Diagram
HS USB data INT1 I2C2 Audio DP/DN USB DP/DM tWL Subsystem TWL5034 Charger EAR_MIC MUIC MAX17040 Battery Fuel gauge (1500mAh) LGE Internal Use Only - 03 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 204 RX_L1 RX SAW RX_L2X 2.85V RF2 2.85V_RF2 VRF2 VDD_FSYS 1800 RX_M1 RX_M3 1.8V_SD RX SAW RX_M1X VDD_IO VSD2 LGE Internal Use Only - 04 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 205: Power Block Diagram
AMBIENT AMBIENT (for Infineon) vANA1 LIGHT 1G / 512Mb SENSOR USIM For 2.85v_SiM vDD_vSiM Infineon (7mA) LEVEL SHIFTER LGE Internal Use Only - 05 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 206: Circuit Diagram
C5026 RFGND1/2 RFOUT5 RFOUTL RFIN4 CN20 CN19 CN18 CN13 CN14 CN15 CN17 L120 2.7n LNA_CTRL1 LNA_CTRL2 L121 8.2n LGE Internal Use Only - 206 - Copyright © 2011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 207 TRSTN JTAG_OMAP_TRST JTAG_OMAP_TDI JTAG_OMAP_TMS JTAG_OMAP_TCK TRIG_IN JTAG_OMAP_RTCK JTAG_OMAP_TDO RESET1_N OMAP_PWR_RESET UART_TX_IFX UART3_TX_OMAP UART_RX_IFX UART3_RX_OMAP 2.3V_RTC IFX_USB_VBUS C241 C242 LGE Internal Use Only - 207 - Copyright © 2011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 208 4G LPDDR U305 BOOT CONFIGURATION Fiducial1 SYS_BOOT0 SYS_BOOT1 SYS_BOOT2 SYS_BOOT3 SYS_BOOT4 SYS_BOOT5 SYS_BOOT6 OneNAND boot eMMC boot External boot LGE Internal Use Only - 208 - Copyright © 2011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 209 0.1u 0.1u VOUT 3.0V_USER_MEM 0.1u EAR_MICBIAS_EN STBY GPS_PWR_ON CE_NC 1.8V_MMC_EN C5032 C5033 C5023 C5022 C5025 C5031 C5024 R410 LGE Internal Use Only - 209 - Copyright © 2011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 210 AUD1 0.1u MODE AUD2 VIB_N GAIN C513 ISET C517 2.2u C519 1.8V_VIO 100K R503 R517 SCREW HOLE OJ501 LGE Internal Use Only - 210 - Copyright © 2011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 211 I2C3_SCL 5M_RESET_N 5M_CAM_VCM_EN CAM_SUBPM_EN C620 C621 C622 LDO4 4.7u 0.1u DEFSEL IDSEL LDO5 C626 C627 C628 C629 C630 LGE Internal Use Only - 211 - Copyright © 2011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 212 I2C2_SCL G2LED KEY_LED_BACK B2LED I2C2_SDA KEY_LED_BLUE2 I2C2_TOUCH_SDA I2C2_SDA COM1 RGB1CNT RGBGND RGB2CNT CLKIO I2C2_TOUCH_SCL ADDSEL RGBISET R708 120K LGE Internal Use Only - 212 - Copyright © 2011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 213 VDD_TCXO VOUT X802 1XTW38400FAA C852 100p CLK_REQ STBY CLK_IN GND1 GND2 384MHZ R804 C853 C854 100K DAISHINKU WLBGA,181,R/TP,WiFi(11bgn)+BT+FM(Rx),BT3.0+HS,6.57x5.62x0.55 LGE Internal Use Only - 213 - Copyright © 2011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 214 NC122 NC30 NC123 ZD904 VA903 VA904 CN904 PWR_ON_SW USB_ID USB_DP USB_DM RCV_N FL902 RCV_P FL901 VCHG GND1 GND2 LGE Internal Use Only - 214 - Copyright © 2011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 215 DNC1 DNC4 C115 SDA/SI U104 2.2n IO_VDD IME_CL C117 C118 0.1u 0.1u 1.8V_MOTION_VIO IME_DA C120 C119 0.1u 0.1u LGE Internal Use Only - 215 - Copyright © 2011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 216 M4-L LEDA I2C3_SCL EAR_DETECT I2C3_SDA M4-DETECT LEDC EAR_R M1-R M6-GND FM_ANT PROX_OUT VOUT C105 C106 C107 4.7u 0.1u LGE Internal Use Only - 216 - Copyright © 2011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 217 SPK_N MIC101 C105 C106 VA103 VA104 VA107 VA108 As close as to MIC, Not in the ANT Carrier LGE Internal Use Only - 217 - Copyright © 2011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 218 CN102 PWR_ON_SW USB_DP USB_ID USB_DM USB_DP USB_DM RCV_N USB_ID RCV_P VCHG PWR ON KB101 CN104 PWR_ON_SW RCV_P RCV_N LGE Internal Use Only - 218 - Copyright © 2011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 219: Bga Pin Map
8. BGA PIN MAP 8. BGA Pin Map 8. BGA PIN MAP -PMB9801 LGE Internal Use Only - 19 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 224: Pcb Layout
- no RF sensitivity CN902 : Lower Conn. - no LED - no MIC - no speaker - no Vibrator LG-P970_MAIN_EAX63969101_1.0_TOP LGE Internal Use Only - 224 - Copyright © 2011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 225 - no booting - no Power On - no Servive R236 R228 R235 R229 R233 R234 C241 C242 LG-P970_MAIN_EAX63969101_1.0_BOT LGE Internal Use Only - 225 - Copyright © 2011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 227 J101 : SIM Socket - no motion sensor - no SIM U104 : Motion sensor - no motion sensor LG-P970_SUB_EAX63990501_1.0_BOT LGE Internal Use Only - 227 - Copyright © 2011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 234: Calibration
10. CALIBRATION 10. CALIBRATION 10.1 General Description This document describes how to install and use the RF calibration software (Tachyon) of LG 3G mobile phone with Infineon Chipsets. 10.2 Requirement Requirements for RF calibration of LGE mobile phone are outlined in the following sections.
Page 235: Setup For Rf Calibration
2) Unzip Tachyon_Release_xxxxxxxx.zip, and overwrite all files to the same path. 3) Install OCX_Registration.bat for registering Tachyon Components in C:/LGE/Tachyon/OCX/ directory. LGE Internal Use Only - 35 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 236 3)Click “model selection” button in toolbar for selecting the appropriate model. 4)Double click the right model - P970/ORF - in model tree, and then click ”select” button. LGE Internal Use Only - 36 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 237 3)Click “model selection” button in toolbar for selecting the appropriate model. 4)Double click the right model - P970/ORF - in model tree, and then click ”select” button. LGE Internal Use Only - 37 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 238 6)Click “run option” button in toolbar for passing over LGE factory setting. 7)Check “PID write” and “Skip previously Phone PID check” LGE Internal Use Only - 38 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 239 9)Click “Calibration+Auto Test” button in Toolbar. Now RF calibration and autotest will start. For more information, refer to the manual in C:/LGE/Tachyon/Manual folder. LGE Internal Use Only - 39 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 240: Overview Of Rf Calibration
Rx LNA Range 16-channel LNA gain offset Offset vs Freq measurements Calibration Table 1-1. The calibration list for WCDMA LGE Internal Use Only - 40 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 241 8 or 16 channel Rx Gain measurements For more information, refer to “XMM6180_RF_parametrical_structure.pdf”. Table 1-2. The calibration list for GSM LGE Internal Use Only - 41 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 242 -50.0 Range 2-3 -26.0 -38.0 Range 3-4 -26.0 Table 1-3. Feature of Tx/Rx calibration in WCDMA 2100/900 band LGE Internal Use Only - 4 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 243 5,3750,3825,3900,3975,4050,4125,4200,4275,4350,4425,4500,4575,4650,4725,4800,4875,4 950,5025,5100,5175,5250,5325,5400,5475,5550,5625,5700,5775,5850,5925,6025,6125,622 5,6325,6425,6525,6625,6725,6825,6925,7025,7125,7225,7325,7425,7525,7625,7725,7825,7 925,8025,8125,8225,8325,8425,8525,8625,8725,8825,8925,9025,9125,9225,9325,9425,952 5,9625,9725,9825,9925,10025,10125,10225,10325,10425,10525,10625,10725,10825,10925, 11025,11125,11225,11375,11525,11675,11825,11975,12125,12275,12425,12575,12725,128 75,13025,13175,13325,13475,13625,13775,13925,14075,14225,14375,14525,14675,14825, 14975,15125,15275,15425,15575,15725,15875,16025,16175,16300 Table 1-4. Feature of Tx/Rx calibration in Quad GSM band LGE Internal Use Only - 43 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 244 97 5 10 00 10 23 Table 1-5 Channel of GSM850/GSM900 1800 1900 Table 1-7 Channel of GSM/1800/GSM1900 LGE Internal Use Only - 44 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 245: Hidden Menu
Factory Rest : Changing information on the the Factory menu, giving you Delete Userdata : Delete ability test Userdata LGE Internal Use Only - 45 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 246 Key / SIM / SD Card / TA / Proximity / ALC / Compass Ring Test Camera Test_1 - Primary Camera LGE Internal Use Only - 46 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 247 - Sencondary Camera ELT Test GPS / BT / WiFi Automatic Mode : Test Automatically Manual Mode : Test selectivity LGE Internal Use Only - 47 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 248 SMS Prefer Set FOTA Test LCD Always On FS_TEST Hidden Reset Heap Free Info Stability Test Charging Test LGE Internal Use Only - 48 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 249 11. HIDDEN MENU SIM Test Streaming Browser Utility Call Test MMS Test Aging Test LGE Internal Use Only - 49 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 250 11. HIDDEN MENU SMS Test WLAN Test WLAN performance on Network Mode GPS Test KR Setting GPS Test_HW LGE Internal Use Only - 50 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 251 11. HIDDEN MENU Contacts Test ADC Test OmaDM Test DRM Test ERS Menu DB check LGE Internal Use Only - 51 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 252 11. HIDDEN MENU IMEI / BT address Log Service Collect Log VT Test LGE Internal Use Only - 5 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 253: Exploded View & Replacement Part List
Can Assembly,Shield SVCY01 Camera Module EBR04 PCB Assembly,Flexible GMEY00 Screw,Machine ACQ02 Cover Assembly,Battery EAB00 EAA00 EAC00 Rechargeable Battery,Lithium Ion LGE Internal Use Only - 253 - Copyright © 2011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 254: Replacement Parts
CUTTING TR 30 LGKU5900.AKTFBK ZZ:Without MCQ015703 Damper, Connector MCQ66573501 Color - CUTTING TR 30 LGKU5900.AKTFBK ZZ:Without MCQ015700 Damper, Connector MCQ66573601 Color - LGE Internal Use Only - 54 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 255 EAX63990901 LGP970.ADEUZY 1.2 POLYI Multi 3 0.33 Flexible PCB Assembly, EBR070200 Flexible, EBR73418702 LGP970.ADEUZY 1.0 Flexible SMT Bottom LGE Internal Use Only - 55 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 256 EBR070400 EBR73418601 LGP970.ADEUZY 1.0 Flexible Flexible, SMT EAX010700 PCB, Flexible EAX63991001 LGP970.ADEUZY 1.1 POLYI SBL 5 0.5 Flexible LGE Internal Use Only - 56 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 257 42 dB, 3.76*2.95*1.1, mems smd mic KNOWLES Condenser ACOUSTICS TSMC-G402A CAPACITIVE TOUCH G/G Touch Window EBD00 EBD61045401 SYNAPTICS T1320 4 Inch B to B - LG INNOTEK., Assembly LTD. TX10D10VM0EAA WVGA 4.0INCH 480X800 EAJ00 LCD, Module-TFT EAJ61772201 700CD COLOR 70% 16/9 1000:1 60Hz Inverter N - HITACHI DISPLAYS., LTD...
Page 258 MCQ02 Damper MCQ66707801 CUTTING SR LGP970.ABYTTL ZZ:Without Color - MCQ03 Damper MCQ66707901 CUTTING SR LGP970.ABYTTL ZZ:Without Color - LGE Internal Use Only - 58 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 259 CUTTING TAPE LGP970.ADEUZY ZZ:Without MJN03 Tape MJN67775401 Color - CUTTING TAPE LGP970.ADEUZY ZZ:Without MJN061100 Tape, Protect MJN67780701 Color - LGE Internal Use Only - 59 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 260 8.5x8.5x5.35t, MIPI, FPCB LG INNOTEK CO., LTD PCB Assembly, EBR04 EBR73418508 LGP970.ABYTTL 1.0 Flexible Flexible PCB Assembly, EBR070400 EBR73418604 LGP970.ADEUZY 1.0 Flexible Flexible, SMT LGE Internal Use Only - 60 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 261 Cover Assembly, ACQ02 ACQ85555901 LGP970.ADEUZY ZZ:Without Color - Battery MCK004100 Cover, Battery MCK66664801 MOLD PC LGP970.ADEUZY ZZ:Without Color - LGE Internal Use Only - 61 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 262 COMPLEX KG800 FRABK DB:DARK BLUE - COMPLEX LGP970.AORATL ZZ:Without Color MAY084000 Box, Unit MAY64851007 GSP2 Type_Global SP Model for Only LGE Internal Use Only - 6 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 263: Main Component
IECS0505C040FR 10V 0% 4E-12F 1.0x0.5x0.3 VA105, Varistor SEVY0010501 IEC61000-4-1 (ESD) level #4 SMD R/TP VA107, INNOCHIPS TECHNOLOGY VA108 LGE Internal Use Only - 63 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 264 CL10A475KP8NNNC 4.7uF 10% 10V X5R - C112, Capacitor, Ceramic, ECCH0007802 55TO+85C 1608 R/TP - SAMSUNG ELECTRO- C114 Chip MECHANICS CO., LTD. LGE Internal Use Only - 64 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 265 RT8515 QFN, 16, R/TP, 2X3, IC, DC, DC IC, DC, DC U102 EUSY0344406 ConverterIC, DC, DC Converter RICHTEK Converter TECHNOLOGY CORP. LGE Internal Use Only - 65 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 266 12.0x12.0x0.74 TR 168P DRAM FBGA - HYNIX SEMICONDUCTOR INC. R303, MCR006YZPJ202 2KOHM 5% 1/20W 0603 R/TP - Resistor, Chip ERHY0009592 R304 ROHM. LGE Internal Use Only - 66 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 267 55TO+85C 0603 R/TP - TDK CORPORATION C414, C415, C453, C455, C467, C468, C472, C476, C478, C479, C480, C489, C492, C495, C499 LGE Internal Use Only - 67 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 268 PAD SHORT R805, R920 X201, FC-135(12.5PF, +-20PPM) 32.768KHZ 20PPM Crystal EXXY0018701 X402 12.5PF 32*15 SMD R/TP SEIKO EPSON CORP LGE Internal Use Only - 68 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 269 BLM15AG601SN1D 600 ohm 1.0X0.5X0.5 25% 0.6 FB804, Filter, Bead SFBH0008101 ohm 0.3A SMD R/TP 2P 0 MURATA FB805, MANUFACTURING CO., LTD. FB806 LGE Internal Use Only - 69 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 270 Capacitor, Ceramic, C5019, ECCH0017301 45TO+85C 0603 R/TP - SAMSUNG ELECTRO- Chip C5032, MECHANICS CO., LTD. C820, C849, C855, C859 LGE Internal Use Only - 70 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 271 R903, R904, MCR006YZPF6802 68KOHM 1% 1/20W 0603 R905, Resistor, Chip ERHY0009558 R/TP - ROHM. R906, R907, R908, R909 LGE Internal Use Only - 71 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 272 CL10A106MP8NNNC 10uF 20% 10V X5R - Capacitor, Ceramic, C104 ECCH0007803 55TO+85C 1608 R/TP 0.8MM SAMSUNG Chip ELECTRO-MECHANICS CO., LTD. LGE Internal Use Only - 7 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 273 C1005C0G1H120JT000F 12pF 5% 50V NP0 - Capacitor, Ceramic, C832 ECZH0000816 55TO+125C 1005 R/TP - TDK KOREA Chip COOPERATION LGE Internal Use Only - 73 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 274 MIPS2520D3R3M 3.3UH 30% - 1A 0.12OHM - - L201, Inductor, Wire ELCP0008007 SHIELD 2.5X2X1MM NONE R/TP FDK L202 Wound, Chip CORPORATION. LGE Internal Use Only - 74 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 275 55TO+125C 0603 R/TP - MURATA C601 Chip MANUFACTURING CO., LTD. MCR006YZPF1002 10KOHM 1% 1/20W 0603 R211 Resistor, Chip ERHY0009303 R/TP - ROHM. LGE Internal Use Only - 75 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 276 KOREA CORPORATION IC, Audio Sub WM9093ECS/R 1.71~5.5V 0W WLCSP R/TP 20P IC601 EUSY0403901 System - WOLFSON MICROELECTRONICS PLC LGE Internal Use Only - 76 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 277 ESD9L5.0ST5G ESD9L5.0ST5G, SOD-923, 5 V, ZD701, ZD702 Diode, TVS EDTY0010201 .15 W, R/TP, 0.5pF SCG HONG KONG SAR LTD. LGE Internal Use Only - 77 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 278 55TO+85C 0603 R/TP - TDK CORPORATION C414, C415, C453, C455, C467, C468, C472, C476, C478, C479, C480, C489, C492, C495, C499 LGE Internal Use Only - 78 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 279 CN6, C1005C0G1H1R5CT000F 1.5pF 0.25PF 50V NP0 Capacitor, Ceramic, C126 ECZH0000822 -55TO+125C 1005 R/TP - TDK KOREA Chip COOPERATION LGE Internal Use Only - 79 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 280 CORPORATION C419, Capacitor, Ceramic, MCH032A150JK 15pF 5% 25V X7R -55TO+125C C437, ECCH0009520 Chip 0603 R/TP - ROHM. C450 LGE Internal Use Only - 80 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 281 Chip C909 COOPERATION R230, R231, PCB ASSY, MAIN, R411, SAFP0000401 LG-LU3000 LGTBK, MAIN, A, PAD SHORT R805, R920 LGE Internal Use Only - 81 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 282 MCR006YZPJ472 4.7KOHM 5% 1/20W 0603 R/TP Resistor, Chip ERHY0009526 R312, - ROHM. R314, R317, R318, R319, R321, R322 LGE Internal Use Only - 8 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 283 GRM033R71C102K 1nF 10% 16V X7R - C418, Capacitor, Ceramic, ECZH0025920 55TO+125C 0603 R/TP - MURATA C907 Chip MANUFACTURING CO., LTD. LGE Internal Use Only - 83 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 284 GPS LOW LOSS MURATA MANUFACTURING CO., LTD. R606, MCR006YZPF1003 100KOHM 1% 1/20W 0603 Resistor, Chip ERHY0009536 R607 R/TP - ROHM. LGE Internal Use Only - 84 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 285 ZD501, PSD12-LF 12V 13.3 25.9V 21A 500W SOD323 Diode, TVS EDTY0008602 ZD902 R/TP 2P 1 PROTEK DEVICES INC. LGE Internal Use Only - 85 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 286 1005GC2T5N6SLF 5.6NH 0.3NH - 300mA L101, Inductor, Multilayer, 0.27OHM 3.2GHZ 8 SHIELD NONE ELCH0004718 L102 Chip 1.0X0.5X0.5MM R/TP PILKOR ELECTRONICS LTD. LGE Internal Use Only - 86 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 287 6P 5 PROTEK DEVICES INC. D103 2SJ347 P-CHANNEL MOSFET -20V -7 -0.05A Q601 EQFP0000101 40OHM 100mW SSM R/TP 3P TOSHIBA LGE Internal Use Only - 87 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 288 Chip MECHANICS CO., LTD. SAFEB1G84FA0F00 1842.5 1.4*1.1*0.6 SMD FL101 Filter, Saw SFSY0024302 R/TP 5P MURATA MANUFACTURING CO., LTD. LGE Internal Use Only - 88 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 289 ROHM CO., LTD. C239, Capacitor, Ceramic, MCH032A180JK 18pF 5% 25V NP0 -55TO+125C ECCH0009504 C240 Chip 0603 R/TP - ROHM. LGE Internal Use Only - 89 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 290 FSUSB63 2.7~4.3V 400NSEC 45NSEC 0W MLP IC301 IC, Analog Switch EAN61871401 R/TP 12P 1 FAIRCHILD SEMICONDUCTOR HONG KONG LTD. LGE Internal Use Only - 90 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 291 GRM0335C1E220J 22pF 5% 25V X7R - C152, Capacitor, Ceramic, ECCH0009216 55TO+125C 0603 R/TP - MURATA C814 Chip MANUFACTURING CO., LTD. LGE Internal Use Only - 91 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 292 1005GC2T12NJLF 12NH 5% - 250mA 0.48OHM Inductor, Multilayer, L104 ELCH0004701 2.1GHZ 8 SHIELD NONE 1.0X0.5X0.5MM R/TP Chip PILKOR ELECTRONICS LTD. LGE Internal Use Only - 9 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 293 GRM188R60J106M 10000000 pF, 6.3V, M, X5R, C427, Capacitor, Ceramic, ECCH0005604 TC, 1608, R/TP, 0.8 mm MURATA C431 Chip MANUFACTURING CO., LTD. LGE Internal Use Only - 93 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 294 C1005Y5V1A474ZT000F 470nF -20TO+80% 10V Capacitor, Ceramic, C520 ECZH0001210 Y5V -30TO+85C 1005 R/TP - TDK KOREA Chip COOPERATION LGE Internal Use Only - 94 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 295 Battery, EAC61518301 61x44x4.4 65x44x4.8 ACE BLACK Bar type, Top Lithium Ion cap Screw joint - LG Chem, LTD. LGE Internal Use Only - 95 - Copyright © 011 LG Electronics. Inc. All right reserved. Only for training and service purposes...

LG -P970 Service Manual

1 Introduction

2 Performance

3 Technical Brief

4 Trouble Shooting

5 Download

6 Block Diagram

7 Circuit Diagram

8 BGA Pin Map

9 Pcb Layout

10 Calibration

11 Hidden Menu

12 Exploded View & Replacement Part List

Quick Links

Troubleshooting

Related Manuals for LG LG-P970

Summary of Contents for LG LG-P970

Table of Contents