All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior permission of Philips. Published by WO 0470 Service PaCE...
EN 2 FTP2.2U AA Technical Specifications, Connections, and Chassis Overview 1. Technical Specifications, Connections, and Chassis Overview Index of this chapter: Connections 1. Technical Specifications 2. Connections Note: The following connector color abbreviations are used 3. Chassis Overview (acc. to DIN/IEC 757): Bk= Black, Bu= Blue, Gn= Green, Gy= Grey, Rd= Red, Wh= White, Ye= Yellow.
Page 3
Technical Specifications, Connections, and Chassis Overview FTP2.2U AA EN 3 AV1 S-Video: Y/C - In Service connector (ComPair) - Ground Y - SDA-S I2C Data (0 - 5 V) - Ground C - SCL-S I2C Clock (0 - 5 V)
EN 4 FTP2.2U AA Safety Instructions, Warnings, and Notes 2. Safety Instructions, Warnings, and Notes • Safety Instructions Where necessary, measure the waveforms and voltages with (D) and without (E) aerial signal. Measure the voltages in the power supply section both in normal Safety regulations require that during a repair: operation (G) and in standby (F).
Page 5
Lead Free Solder Some PWBs in this chassis are “lead-free prepared”. This is indicated on the PWB by the PHILIPS lead-free logo (either by a service-printing or by a sticker). It does not mean that lead- free solder is actually used! Figure 2-2 Lead-free logo 2.3.5...
EN 6 FTP2.2U AA Directions for Use 3. Directions for Use You can download this information from the following website: http://www.philips.com/support...
Mechanical Instructions FTP2.2U AA EN 7 4. Mechanical Instructions Index of this chapter: Notes: 1. Cable Dressing • Figures below can deviate slightly from the actual situation, 2. Service Positions due to the different set executions. 3. Assy / PWB Removal •...
Page 8
EN 8 FTP2.2U AA Mechanical Instructions 4.3.3 Assy/PWB Removal Ambient Light Panel 1. Disconnect all cables from the Ambient Light Inverter 4.3.1 Metal Back Plate panel. 2. Remove all mounting screws from the Ambient Light Caution: Disconnect the AC Power (mains) cord before you Inverter panel.
Page 9
Mechanical Instructions FTP2.2U AA EN 9 3. Shift the Ambient light unit to the side (3) and take out the unit. Plasma Panel / Glass Plate (Dis)Assembly Important: Be sure to work in a dust free environment during the following activities. In addition, the use of (fabric) hand gloves is advised.
Page 10
EN 10 FTP2.2U AA Mechanical Instructions – Audio panel supply plug on PSU. Set Re-assembly – LVDS plug on SSB. SSBCaution: Be careful, because this connection is To re-assemble the whole set, execute all processes in reverse very fragile! order.
Caution: If the SDM is activated via the pins, all the the Customer Service Mode (CSM) is used for communication software-controlled protections are de-activated. between a Philips Customer Care Centre (P3C) and a • Use the DST-emulation feature of ComPair.
Page 12
Software downloading). You will development analysis, before initialising. This will give find details of the software versions in the chapter the Philips Service department an extra possibility for “Software Survey” of the “Product Survey - Color diagnosis (e.g. when Development asks for this).
Page 13
Service Modes, Error Codes, and Fault Finding FTP2.2U AA EN 13 • VOLUME. Gives the last status of the volume as set by the CUSTOMER SERVICE MENU 3 • customer. The value can vary from 0 (volume is minimum) BALANCE. Indicates the balance settings, between “-50”...
Page 14
SHARPNESS is "3" or "4" and the value of line NOISE FIGURE is high ("127" or higher), ComPair (Computer Aided Repair) is a service tool for Philips decrease the "Sharpness” value. Consumer Electronics products. ComPair is a further...
Page 15
Service Modes, Error Codes, and Fault Finding FTP2.2U AA EN 15 5.4.2 Specifications Mains cord IN ComPair consists of a Windows based faultfinding program and an interface box between PC and the (defective) product. OTC gets supply voltage The ComPair interface box is connected to the PC via a serial...
EN 16 FTP2.2U AA Service Modes, Error Codes, and Fault Finding 5.5.2 How to read the Error Buffer START Initialize PDP SDI Use one of the following methods: Max 3.04 sec after 5V and 8V =OK • On screen via the SAM (only if you have a picture).
Page 17
Service Modes, Error Codes, and Fault Finding FTP2.2U AA EN 17 Table 5-1 Error Table Error Device Description Def. item Def. Module indication Diagr. M24C32 NVM, spontaneous blinking error 1 7011 Control SAA4978 PICNIC 7713 Feature Box Supply 5 V...
EN 18 FTP2.2U AA Service Modes, Error Codes, and Fault Finding To get a quick diagnosis, this chassis has three service-modes 8 V and 5 V protections: The microprocessor senses the implemented: presence of the 8 V and 5 V (via the “+5V_CON” and •...
Page 19
Service Modes, Error Codes, and Fault Finding FTP2.2U AA EN 19 5.8.2 5.8.3 ComPair Protections A “Service” (ComPair) connector is implemented at the rear Activating SDM via the “service pads” will overrule the side of the set, which is directly accessible. In addition to this,...
Page 20
EN 20 FTP2.2U AA Service Modes, Error Codes, and Fault Finding Personal Notes: E_06532_012.eps 131004...
Page 76
Circuit Diagrams and PWB Layouts FTP2.2U AA Layout Small Signal Panel (Top Side Overview) Part 1 E_14780_130a.eps Part 2 E_14780_130b.eps Part 3 E_14780_130c.eps Part 4 E_14780_130d.eps 3104 303 3913.3 E_14620_130.eps 020704...
Page 78
Circuit Diagrams and PWB Layouts FTP2.2U AA Layout Small Signal Panel (Top Side Part 1) Part 1 E_14620_130a.eps 070704...
Page 79
Circuit Diagrams and PWB Layouts FTP2.2U AA Layout Small Signal Panel (Top Side Part 2) Part 2 E_14620_130b.eps 070704...
Page 80
Circuit Diagrams and PWB Layouts FTP2.2U AA Layout Small Signal Panel (Top Side Part 3) Part 3 E_14620_130c.eps 070704...
Page 81
Circuit Diagrams and PWB Layouts FTP2.2U AA Layout Small Signal Panel (Top Side Part 4) Part 4 E_14620_130d.eps 070704...
Page 82
Circuit Diagrams and PWB Layouts FTP2.2U AA Layout Small Signal Panel (Bottom Side Overview) Part 2 E_14620_131b.eps Part 1 E_14620_131a.eps Part 3 E_14620_131c.eps Part 4 E_14620_131d.eps E_14620_131.eps 080704 3104 303 3913.3...
Alignments FTP2.2U AA EN 97 8. Alignments 8.3.1 Index of this chapter: GENERAL 1. General alignment conditions 2. Hardware alignments For the next alignments, supply the following test signals via a 3. Software alignments video generator to the RF input: 4.
Page 98
EN 98 FTP2.2U AA Alignments 8.3.2 2FH ADC ALIGNMENT Table 8-3 White D alignment values Only necessary to align, when the A/D convertor or NVM is color Cool Normal Warm replaced. Use the default values as mentioned in the table.
Page 99
Yes / No Rear lighting feature present / not present Tuner type UV1316 / TEDE9 Model with Philips tuner / Alps tuner Hotel Mode Yes / No Hotel Mode On / Off (only applicable for Institutional TV models) Intelligent Lights...
Page 100
EN 100 FTP2.2U AA Alignments 8.4.4 OPT. NO. (Option numbers) Select this sub menu to set all options at once (expressed in two long strings of numbers). Table 8-7 Option number overview Model Number 12 NC Options Group 1 Options Group 2...
Circuit Descriptions, Abbreviation List, and IC Data Sheets FTP2.2U AA EN 101 9. Circuit Descriptions, Abbreviation List, and IC Data Sheets Index of this chapter detected automatically. “Columbus improved noise 1. Introduction reduction” is used when the Columbus is present.
Page 102
EN 102 FTP2.2U AA Circuit Descriptions, Abbreviation List, and IC Data Sheets INTERFACING DC/DC CONVERTER LVDS PIP/DW AUDIO PIP/DW TUNER EPLD FBX SUPPLY FBX (2FH) HIP2 HIP1 MAIN MAIN TUNER HDMI RECEIVER E_14620_141.eps 090704 Figure 9-1 SSB top view INTERFACING...
Page 103
Circuit Descriptions, Abbreviation List, and IC Data Sheets FTP2.2U AA EN 103 Power Supply Unit The OTC delivers a PDP-GO signal to the PDP when the set is not in standby. 9.2.1 Power Supply Samsung PDP (SDI) Aux Supply This is an LLC supply that delivers the Va, Vs, Vscan, Ve, and General Vset directly to the PDP.
Page 104
EN 104 FTP2.2U AA Circuit Descriptions, Abbreviation List, and IC Data Sheets • LLC resonant supply: 9 V becomes 30 V for the 12 V down Differences with the SDI PSU: • converter. Extra filter added for detecting low frequency.
Page 105
Circuit Descriptions, Abbreviation List, and IC Data Sheets FTP2.2U AA EN 105 • Power States OUT: The set is OUT when the mains cord is disconnected. There are four different power states. Their characteristics are When the mains cord is connected, the set goes to OFF or summarised in the "Power states"...
Page 106
EN 106 FTP2.2U AA Circuit Descriptions, Abbreviation List, and IC Data Sheets Feature Box depending on the amplitude of the detail and the user setting. So, it is advised to use this feature only at the lowest settings. The key components of the FBX are the following ICs: •...
Page 107
Circuit Descriptions, Abbreviation List, and IC Data Sheets FTP2.2U AA EN 107 The noise reduction part of the Columbus is controlled by the Bypass Mode FBX software using the SNERT interface (the “Limeric” noise The 3D Comb filter can be set in bypass mode. In this mode, reduction in the PICNIC is “off”...
Page 108
EN 108 FTP2.2U AA Circuit Descriptions, Abbreviation List, and IC Data Sheets Block Diagram A PAL delay line is added in the UV path. This is done because The signal CVBS-TXT that used to go to the “old” Comb filter a delay line in front of the 3D Comb filter does need an extra (item 7307 in EM5.1E) is here re-routed via an emitter follower...
Page 109
Circuit Descriptions, Abbreviation List, and IC Data Sheets FTP2.2U AA EN 109 b. The other way is to use the peaking dynamically, in To reduce loss of detail, the high frequencies can be bypassed. This can be done because the human eye is more sensitive to order to boost smaller details and provide less gain noise with low frequencies.
Page 110
EN 110 FTP2.2U AA Circuit Descriptions, Abbreviation List, and IC Data Sheets 2. Then it detects a reflection of this signal caused by a Emitting phase person approaching the set. 3. Finally, it lights up the different LEDs. IR Transmission (fo) The IR transmission is realised with diode D6080 (TSAL5300).
Page 111
Circuit Descriptions, Abbreviation List, and IC Data Sheets FTP2.2U AA EN 111 The light can re-trigger if the microcontroller receives the will switch "on". If the user activates any button within the keyboard press information (as described in the "keyboard lighting phase, the light stays on for another 6 s.
EN 112 FTP2.2U AA Circuit Descriptions, Abbreviation List, and IC Data Sheets 9.14 Abbreviation list All mentioned blocks (from "Cycle Generator" to "HSV-to-RGB Converter" are implemented in the main software. Via I C, the RGB values are sent to the EPLD (where a selection is made...
Page 113
Circuit Descriptions, Abbreviation List, and IC Data Sheets FTP2.2U AA EN 113 Double Window MOSFET Metal Oxide Semiconductor Field Eagle Feature box IC performing peaking, Effect Transistor zooming and sub pixel LTI in both MPEG Motion Pictures Experts Group horizontal and vertical direction, CTI...
Page 114
Eastern Europe. Color carriers = 4.406250 MHz and 4.250000 MHz Sound Intermediate Frequency SNERT Synchronous No parity Eight bit Reception and Transmit SOPS Self Oscillating Power Supply S/PDIF Sony Philips Digital InterFace SSB/SSP Small Signal Board/Panel STBY Standby Subwoofer Teletext TXT-DS Teletext Dual Screen TXT-KILL To kill the TXT picture to insert a PIP.
Circuit Descriptions, Abbreviation List, and IC Data Sheets FTP2.2U AA EN 115 9.15 IC Data Sheets In this paragraph, the internal block diagrams and pinning are given of ICs that are drawn as a 'black box' in the electrical diagrams (with the exception of 'memory' and 'logic' ICs).
Page 116
EN 116 FTP2.2U AA Circuit Descriptions, Abbreviation List, and IC Data Sheets 9.15.3 Diagram A7, TEA1507 (IC7112 and IC7212) SUPPLY START-UP V CC DRAIN MANAGEMENT CURRENT SOURCE clamp internal UVLO start n.c. VALLEY supply M-level VOLTAGE CONTROLLED LOGIC OSCILLATOR 100 mV...
Page 117
Circuit Descriptions, Abbreviation List, and IC Data Sheets FTP2.2U AA EN 117 9.15.5 Diagram B3B, SAA4998 (IC7760) Block diagram of the luminance part in full FALCONIC mode. FIELD MEMORY 2 MEMORY CONTROL FIELD MEMORY 3 DYNAMIC 55 to 62 YA0 to YA7...
Page 118
EN 118 FTP2.2U AA Circuit Descriptions, Abbreviation List, and IC Data Sheets 9.15.6 Diagram B3C, T6TX5EF (IC7720) EAGLE IC digital output Interface between Eagle and External SDRAM interface to LVDS device LVDS Int erface IC RASN TXN0 TXN1 CASN Eagle 1c...
Page 119
Circuit Descriptions, Abbreviation List, and IC Data Sheets FTP2.2U AA EN 119 9.15.7 Diagram B3C, CY2305SC-1 (IC7721) Block Diagram Pin Configuration SOIC/TSSOP Top View CLKOUT CLKOUT CLKA1 CLKA1 CLKA4 CLKA3 CLKA2 CLKA2 CLKA3 CLKB4 CLKB1 CLKB3 CLKA4 CLKB2 CLKB1 SOIC...
Page 120
EN 120 FTP2.2U AA Circuit Descriptions, Abbreviation List, and IC Data Sheets 9.15.9 Diagram B6B, MAS3528E (IC7A30) SYNC I2CD I2CC SPDI2 44 43 42 41 40 AVSS SPREF AVDD SPDI N.C. PI19 MAS 3528E N.C. PI18 CLKO PI17 SOD1 PI16...
Page 121
Circuit Descriptions, Abbreviation List, and IC Data Sheets FTP2.2U AA EN 121 9.15.10 Diagram B14D, UDA1352TS (IC7I25) BLOCK DIAGRAM V DDA(DAC) V ref V SSA(DAC) TEST1 TEST2 VOUTL VOUTR V DDA(PLL) V SSA(PLL) CLOCK TIMING CIRCUIT V DDD(C) V SSD(C)
Page 122
EN 122 FTP2.2U AA Circuit Descriptions, Abbreviation List, and IC Data Sheets 9.15.11 Diagram B14F, SiI9993CT100 (IC7I18) BLOCK DIAGRAM RESET# CSDA Registers Slave CSCL DSDA ---------------- Slave Configuration DSCL Logic Block Aux Data Logic HDCP HDCP Block MCLK Keys Decryption...
Page 123
Circuit Descriptions, Abbreviation List, and IC Data Sheets FTP2.2U AA EN 123 9.15.12 Diagram J, P87LPC760BDH (IC7075) BLOCK DIAGRAM ACCELERATED 80C51 CPU INTERNAL BUS UART 1 KBYTE CODE EPROM 128 BYTE DATA RAM TIMER 0, 1 PORT 2 CONFIGURABLE I/OS...
Revision List FTP2.2U AA EN 139 11. Revision List Manual xxxx xxx xxxx.0 • First release. Manual xxxx xxx xxxx.1 • Several pictures updated. Fonts and other minor issues in PDF-file solved. Manual xxxx xxx xxxx.2 • Frontpage: 12nc of the SDI plasma panel manual added.