Troubleshooting - Antunes, AJ MEC-600 Manual

MANUAL EGG COOKER/STEAMER
To avoid possible personal injury and/or damage to the unit, inspection, test and repair of electrical equip-
ment should be performed by qualified service personnel. The unit should be unplugged when servicing.
Problem
Unit fails to operate and
control panel lights fail
to signal on.
Unit fails to heat.
Eggs do not cook prop-
erly.
Eggs sticking to Platen.
Eggs sticking to Egg
Rings.
Not signaling on "Bacon"
or "Ready".
If the troubleshooting steps listed do not solve your problem, contact an A.J. Antunes Authorized Service
Agency for further assistance.

TROUBLESHOOTING

Possible Cause
No power/low power.
Inoperable electrical outlet.
Inoperable rocker (power On/Off)
switch.
Inoperable power cord.
Loose Connections.
Loose connections.
Inoperable Platen.
Low voltage.
Inoperable hi-limit thermostat.
Inoperable thermocouple.
Inoperable solid state relay.
Using refrigerated eggs and time
selector switch set for 2' 00".
Time selector switch is set for 2' 30"
(eggs overcooked).
Incorrect amount of water added to
trough in cover.
Platen Temperature is too low or too
high.
Loose connections.
Unit/table is not level.
Dirty Platen.
Insufficient butter being used.
Insufficient butter being used.
Dirty Egg Rings.
Inoperable Egg Ring.
Inoperable indicator light or audio
signal.
Inoperable control board.
Loose connection.
Bacon Timer is disabled.
WARNING
Make sure Rocker Switch (power On/Off) is ON
and power cord is locked into place. Check main
circuit breakers.
Plug into different outlet of same amperage rat-
ing.
Contact your maintenance person or an
Authorized Service Agency.
Contact your maintenance person or an
Authorized Service Agency.
Set time selector switch to 2' 30" when using
refrigerated eggs.
Set time selector switch to 2' 00" when using
room temperature eggs.
Fill trough in cover with water before starting time
cycle.
Check temperature according to the Maintenance
section of this manual.
Contact your Authorized Service Agency.
Level the table and unit as necessary.
Clean Platen.
See the Operating section of this manual.
See the Operating section of this manual.
Do not use an abrasive scrubbing pad to clean
Egg Rings.
Replace Egg Ring.
Contact your maintenance person or an
Authorized Service Agency.
Enable Bacon Timer according to the Operating
Section of this manual.
10
Corrective Action
P/N 1010841 Rev. F 12/04
McDonald's