1 Safety Precautions 1.1. General Guidelines 1. When servicing, observe the original lead dress. If a short circuit is found, replace all parts which have been overheated or damaged by the short circuit. 2. After servicing, see to it that all the protective devices such as insulation barriers, insulation papers shields are properly installed.
2 Warning 2.1. Prevention of Electrostatic Discharge (ESD) to Electrostatically Sensi- tive (ES) Devices Some semiconductor (solid state) devices can be damaged easily by static electricity. Such components commonly are called Elec- trostatically Sensitive (ES) Devices. Examples of typical ES devices are integrated circuits and some field-effect transistors and semiconductor [chip] components.
2.2. About lead free solder (PbF) Note: Lead is listed as (Pb) in the periodic table of elements. In the information below, Pb will refer to Lead solder, and PbF will refer to Lead Free Solder. The Lead Free Solder used in our manufacturing process and discussed below is (Sn+Ag+Cu). That is Tin (Sn), Silver (Ag) and Copper (Cu) although other types are available.
3 Service Navigation 3.1. Service Hint (42 inch) Board Name Function Board Name Function Power Supply Data Driver (Lower Right) DC-DC Converter Data Driver (Lower Left) Speaker out, Sound Processor Scan Drive AV Terminal, AV Switch Scan out (Upper) Digital Signal Processor, MPU, HDMI Interface Scan out (Lower) Peaks Lite 2p Sustain Drive...
Page 6
3.2. Service Hint (37 inch) Board Name Function Board Name Function Power Supply Data Driver (Lower Right) DC-DC Converter Data Driver (Lower Left) Speaker out, Sound Processor Scan Drive AV Terminal, AV Switch Scan out Digital Signal Processor, MPU, HDMI Interface Sustain Drive Peaks Lite 2p Key Switch, Front Terminal...
4 Specifications Power Source AC 220 - 240 V, 50/60 Hz Power Consumption Average use 235 W (37 inch) 255 W (42 inch) Standby condition 0.7 W (Without monitor out recording) 20 W (With monitor out recording) Plasma Display panel Aspect Ratio 16:9 Visible screen size...
Page 9
• This equipment complies with the EMC standards listed below. EN55013, EN61000-3-2, EN61000-3-3, EN55020.
5 Service Mode 5.1. How to enter into Service Mode While pressing [VOLUME ( - )] button of the main unit, press [0] button of the remote control three times within 2 seconds. 5.1.1. Key command [1] button...Main items Selection in forward direction [2] button...Main items Selection in reverse direction [3] button...Sub items Selection in forward direction [4] button...Sub items Selection in reverse direction...
5.1.2. Contents of adjustment mode • Value is shown as a hexadecimal number. • Preset value differs depending on models. • After entering the adjustment mode, take note of the value in each item before starting adjustment. 5.1.3. How to exit Switch off the power with the [POWER] button on the main unit or the [POWER] button on the remote control.
5.2. Service tool mode 5.2.1. How to access 1. Select [SRV-TOOL] in Service Mode. 2. Press [OK] button on the remote control. 5.2.2. Display of SOS History SOS History (Number of LED blinking) indication. From left side; Last SOS, before Last, three occurrence before, 2nd occurrence after shipment, 1st occurrence after shipment. This indication will be cleared by [Self-check indication and forced to factory shipment setting].
5.3. Hotel mode 1. Purpose Restrict a function for hotels. item Function 2. Access command to the Hotel mode setup menu Hotel Mode Select hotel mode ON/OFF In order to display the Hotel mode setup menu, please Initial INPUT Select input signal modes. enter the following command (within 2 second).
6 Troubleshooting Guide Use the self-check function to test the unit. 1. Checking the IIC bus lines 2. Power LED Blinking timing 6.1. Check of the IIC bus lines 6.1.1. How to access Self-check indication only: Produce TV reception screen, and while pressing [VOLUME ( - )] button on the main unit, press [OK] button on the remote control for more than 3 seconds.
6.2. Power LED Blinking timing chart 1. Subject Information of LED Flashing timing chart. 2. Contents When an abnormality has occurred the unit, the protection circuit operates and reset to the stand by mode. At this time, the defective block can be identified by the number of blinks of the Power LED on the front panel of the unit.
Page 16
6.3. No Power First check point There are following 2 states of No Power indication by power LED. 1. No lit 2. Red is lit then turns red blinking a few seconds later. (See 6.2.)
7 Disassembly and Assembly Instructions 7.1. Remove the rear cover 7.4. Remove the Tuner unit 1. See Service Hint (Section 3) 1. Unlock the cable clampers to free the cable. 2. Disconnect the connectors (A1, A7, A12, A20, A25, A31, 7.2.
7.7. Remove the SU-Board (42 inch) 3. Remove the screw (×1 ) and remove the GS-Board. 1. Remove the flexible cables (SU1B, SU2B, SU3B and SU4B) connected to the SU-Board. 2. Remove the flexible cable (SU11-SD11) and the bridge connector (SC41-SU41). , ×2 3.
7.9. Remove the SD-Board (42 inch) 7.11. Remove the SS-Board 1. Remove the flexible cables (SD1B, SD2B, SD3B and 1. Unlock the cable clampers to free the cable. SD4B) connected to the SD-Board. 2. Disconnect the connectors (SS11, SS12, SS23 and 2.
7.13. Remove the C1-Board 37 inch 1. Remove the tuner unit. (See section 7.4.) 2. Unlock the cable clampers to free the cable. 3. Remove the flexible cables holder fastening screws (×8 4. Disconnect the flexible cables (CB1, CB2, CB3 and CB4). 5.
7.17. Remove the speaker L, R 7.19. Remove the K-Board 1. Disconnect the connector (A12). (See section 7.4.) 1. Remove the S-Board. (See section 7.18.) 2. Unlock the cable clampers to free the cable. 2. Remove the screws (×4 each) and remove the speaker L, R.
2. Remove the cabinet assy and the plasma panel fastening 5. Remove the BC hook (left, right). screws (×7 3. For leaving the plasma panel from the front frame, pull the bottom of the cabinet assy forward, lift, and remove. Caution: •...
8 Measurements and Adjustments 8.1. Driver Set-up 8.1.1. Item / Preparation 8.1.2. Adjustments 1. Input a white signal to plasma video input. Adjust driver section voltages referring the panel data on the 2. Set the picture controls as follows. panel data label. Picture menu: Dynamic Check or adjust the following voltages with the multimeter.
8.1.3. P.C.B. (Printed Circuit Board) exchange 8.1.3.1. Caution 1. To remove P.C.B. , wait 1 minute after power was off for discharge from electrolysis capacitors. 8.1.3.2. Quick adjustment after P.C.B. exchange Adjust the following voltages with the multimeter. P.C.B. Name Test Point Voltage Volume...
9 Block Diagram 9.1. Block (1/7) Diagram to/from SC20 BA/EA ONLY DDR2 CLOCK GEN EEPROM SOS6_SC1 (LED 6TIMES) CI SLOT SD CARD SLOT SOS7_SC2 (LED 7TIMES) Genx6 SD CARD I/F SD DATA EEPROM POWER SOS to/from POWER_SOS GS52 (LED 4TIMES) +3.3V(S) +3.3V(S) +5V(P)
Page 28
9.2. Block (2/7) Diagram (42 inch) SC SCAN DRIVE SC-BOARD ENERGY RECOVERY VSUS SOS DETECT POWER SUPPLY (LED 6 TIMES) SU SCAN OUT (UPPER) SOS6_SC1 SC-BOARD FLOATING PART PS SOS SOS DETECT (LED 4 TIME) P-BOARD SUSTAIN DRIVE (LED 7 TIMES) +5V(P) SOS DETECT POWER MICOM...
Page 29
C2 DATA DRIVER (LEFT) C1 DATA DRIVER (RIGHT) +5V(P) +5V(P) SOS8_SS SOS8_SS SUSTAIN CONTROL SUSTAIN CONTROL DATA DATA DATA DATA DATA DATA DATA DATA DRIVER DRIVER DRIVER DRIVER DRIVER DRIVER DRIVER DRIVER TH-37PV8PA, PX8BA/EA TH-37PV8PA, PX8BA/EA Block (3/7) Diagram Block (3/7) Diagram...
Page 30
9.4. Block (4/7) Diagram JK3002 JK3003 TU8301 JK3100 HEADPHONE JK4500 JK4501 AUDIO Dig/Ana YPBPR CONTROL A-BOARD IN/OUT HDMI2 HDMI1 Tuner BUTTON IC4510 HDMI Rx/AD CONV. HDMI PROCESSOR Digtal SPEAKER L,R Audio Signal HDMI1 HDMI AUDIO DECORD Digtal HDMI2 Video VIDEO Signal IIC_TUNER Analog video signal...
Page 31
9.5. Block (5/7) Diagram A-BOARD IC8001 IC9900 PD2-M Peaks-lite2p (MAIN MCU+VIDEO SIGNAL PROCESSOR) IIC2 VIDEO DATA *PLASMA AI VIDEO DATA RGB MATRIX LVDS LVDS *CPG with SS HV ENHANCER *H/V Sync Control VIDEO DATA DRIVER AI PROCESSOR IIC3 *Sub Filed Processor CONTROL DATA PIXEL CONV.
Page 32
9.6. Block (6/7) Diagram (42 inch) SUSTAIN DRIVE POWER SWITCH TPVSUS Vsus PLASMA PANEL IC16131 IC16301 Q16001,2 SW2500 PANEL DRIVER PANEL DRIVER VSUS Gen. POWER IC16302 DRIVER SWITCH D16321 TPVE2 Q16021,2 TRANS T16301 IC16151 MAIN SW1 +5V(P) MAIN SW2 ENERGY TPVE Q16041 RECOVERY...
10 Wiring Connection Diagram 10.1. Caution statement. Caution: Please confirm that all flexible cables are assembled correctly. Also make sure that they are locked in the connectors. Verify by giving the flexible cables a very slight pull. 10.2. Wiring (42 inch)
11.10. A-Board (2/19) Schematic Diagram A-BOARD (2/19) IC8001 MN2WS0047 Peaks-Lite2+ IC8003 PEAKS,DDR C3ABRY000015 CRNo.8000-8299 DDR2_0 DDR I/F IC8002 IC8002 IC8002 R8084 IC8002 LOSD OUT (for HQ1) MCLK AE23 IC8001 IC8002 FOR HQ1L VIDEO B PORT (Sub Video Input or Address) CPU BUS I/F IC8002 FOR ADV7493...
11.18. A-Board (10/19) Schematic Diagram L3017 E_AV1_V/A_AV2_V *R3072 J0JCC0000100 GND(PLUG) VIDEO IN *R3097 TV VIDEO OUT A-BOARD (10/19) GND(BLK) JS3010 GND(VIDEO) *R3073 *R3098 FB IN JS3011 E_AV1_FB RED IN JS3012 E_AV1_RED/A_AV2C_PR *R3188 *R3074 JS3013 E_AV1_GREEN/A_AV2C_Y REAR TERMINAL,AVSW GND(RED) JS3014 E_AV1_BLUE/A_AV2C_PB CRNo.3000-3399 *R3153 GREEN IN...
11.22. A-Board (14/19) Schematic Diagram TO 9/19 TO 6/19 TO 2/19 TO 2/19 TO 9/19 TO 5,6/19 TO 5,9/19 TO 9/19 TO 1/19 STB3.3V/RESET R9088 IC9011 100k STB_D3.3V STB5V C0EBF0000431 R9161 R9128 R9153 Q9058 VOUT 2SD0601A0L C9033 C9036 C9034 C9035 0.1u R9089 0.1u...
12.5. C1-Board (42 inch) Parts Location C1-BOARD IC IC IC17101 IC17102 C1-BOARD (FOIL SIDE) TNPA4642 1 2 3 TNPA4642 P b F S E E R E V E R S E F O R O R D E R N O . C1-BOARD (COMPONENT SIDE) TNPA4642 CR NO.17...
12.7. C2-Board (42 inch) Parts Location C2-BOARD IC IC IC17201 IC17202 IC17203 C2-BOARD (FOIL SIDE) TNPA4643 1 2 3 TNPA4643 1 C2 P b F S E E R E V E R S E F O R O R D E R N O . C2-BOARD (COMPONENT SIDE) TNPA4643 TNPA4643...
R 2 5 7 D 2 1 1 D 2 0 4 R 2 1 7 D 2 2 1 R 2 2 7 R 2 2 4 ZA204 D 2 0 6 TH-37PV8PA, PX8BA/EA TH-37PV8PA, PX8BA/EA C2-BOARD TNPA4641 C2-BOARD TNPA4641...
Page 99
D 4 8 1 T P 2 3 T P 9 0 T P 9 1 C 5 6 3 T P 1 2 T P 1 3 TH-37PV8PA, PX8BA/EA TH-42PV8PA, PX8BA/EA TH-37PV8PA, PX8BA/EA TH-42PV8PA, PX8BA/EA SC-BOARD TNPA4644AB SC-BOARD TNPA4644 SC-BOARD TNPA4644AB...
Page 100
Parts Location Parts Location SC-BOARD (FOIL SIDE) SC-BOARD (COMPONENT SIDE) TEST POINT PHOTO COUPLER TEST POINT TP41 Q16661 TP42 Q16662 IC16471 PC16461 IC16784 TP43 Q16663 IC16786 IC16472 PC16480 TP46 TP44 Q16664 IC16501 PC16601 IC16788 TP82 TP51 Q16665 IC16791 IC16521 PC16603 TPSC1 TP52 Q16666...
Page 101
I C 5 8 1 R 5 9 3 R 5 8 4 D 4 7 4 R 5 9 1 I C 5 6 2 TH-37PV8PA, PX8BA/EA TH-42PV8PA, PX8BA/EA TH-37PV8PA, PX8BA/EA TH-42PV8PA, PX8BA/EA SC-BOARD TNPA4644AB SC-BOARD TNPA4644 SC-BOARD TNPA4644AB...
12.10. SU-Board (42 inch) SU-BOARD (FOIL SIDE) TNPA4399 1 2 3 TNPA4399 S E E R E V E R S E F O R O R D E R N O . P b F Parts Location SU-BOARD IC IC IC14901 IC14902 IC14903...
12.11. SD-Board (42 inch) SD-BOARD (FOIL SIDE) TNPA4400 P b F TNPA4400 S E E R E V E R S E F O R N O . O R D E R 1 2 3 Parts Location SD-BOARD IC IC IC14951 IC14952 IC14953...
Page 104
D 9 0 4 C 9 7 7 C 9 8 3 C 9 7 9 A 6 0 A 6 0 A 6 0 A 6 0 A 6 0 A 6 0 TH-37PV8PA, PX8BA/EA TH-37PV8PA, PX8BA/EA SM-BOARD TNPA4401 SM-BOARD TNPA4401...
Page 105
S S 5 3 A S S 5 3 T P 2 6 T P 2 5 S S 5 6 A S S 5 6 TH-37PV8PA, PX8BA/EA TH-42PV8PA, PX8BA/EA TH-37PV8PA, PX8BA/EA TH-42PV8PA, PX8BA/EA SS-BOARD TNPA4659AB SS-BOARD TNPA4659 SS-BOARD TNPA4659AB...
Page 106
O R D E R N O . C 1 0 2 SS56 P b F C R N o . 1 6 Z A 0 0 2 TH-37PV8PA, PX8BA/EA TH-42PV8PA, PX8BA/EA TH-37PV8PA, PX8BA/EA TH-42PV8PA, PX8BA/EA SS-BOARD TNPA4659AB SS-BOARD TNPA4659...
Page 110
Ref. Safety Part No. Part Name & Description Q'ty Remarks EAS16S06A SPEAKER J0KG00000014 FILTER K2CN3DH00006 AC CORD 1 EA/PA K2CT3DH00018 AC CORD 1 BA MD37H11A2J PLASMA DISPLAY PANEL 1 37 INCH MD42H11A2J PLASMA DISPLAY PANEL 1 42 INCH N2QAYB000222 REMOTE CONTROL 1 PAVCCZ BA/EA N2QAYB000223 REMOTE CONTROL...
Page 111
Ref. Safety Part No. Part Name & Description Q'ty Remarks TMK0E729 SPONGE(UPPER/BOTTOM) 2 PAVCCZ 42 INCH TMK0E730 SPONGE(UPPER/BOTTOM) 2 PAVCCZ 37 INCH TMK0EG009 SPEAKER SPONGE 2 PAVCCZ TMKG190-1 SPONGE(5x40x115) 1 PAVCCZ TMM0E302 REAR COVER SPACER 6 PAVCCZ TMM0E311 REAR COVER SPACER RING 6 PAVCCZ TMM0E313 M8 SPACER...
Page 112
Ref. Safety Part No. Part Name & Description Q'ty Remarks TPE0E4019-1 SET BAG 1 PAVCCZ TPE0E9001 ACCESSORIES BAG 1 PAVCCZ TPEB333-1 BAG (STAND) TPEB336 BAG (STAND POLE RIGHT) TPEB338 BAG (SCREW STAND-TV) 1 PAVCCZ TQB0E0718 INSTRUCTION BOOK (ENGLISH) 1 PAVCCZ BA TQB0E0724A INSTRUCTION BOOK(GERMAN) 1 PAVCCZ EA...
Page 113
Ref. Safety Part No. Part Name & Description Q'ty Remarks TQB0E0738P INSTRUCTION BOOK(POLISH) 1 PAVCCZ PA TQB0E0738Q INSTRUCTION BOOK(HUNGARIAN) 1 PAVCCZ PA TQB0E0738R INSTRUCTION BOOK(CZECH) 1 PAVCCZ PA TQB0E0738S INSTRUCTION BOOK(GREEK) 1 PAVCCZ PA TQB0E0738T INSTRUCTION BOOK(TURKISH) 1 PAVCCZ PA TQB0E0738U INSTRUCTION BOOK(ENGLISH) 1 PAVCCZ PA...
Page 114
Ref. Safety Part No. Part Name & Description Q'ty Remarks XYN4+E8FJ SCREW XYN4+F10FJ SCREW XYN4+F30FJK SCREW XYN5+C15FJ SCREW XYN5+F18FN SCREW (STAND POLE) XZB9X18C05 BAG (STAND POLE LEFT) XZBT6506 POLY BAG (INSTRUCTION BOOK)
13.2.2. Electrical Replacement Parts List (42 inch) Safety Ref. No. Part No. Part Name & Pcs Remarks Description Safety Ref. No. Part No. Part Name & Pcs Remarks C2106 F1G1C104A116 C 0.10UF, K, 16V Description C2107 F2G0J470A019 E 47UF 6.3V C2108 F2G0J470A019 E 47UF 6.3V K1KA11A00178 11P CONNECTOR...
Page 117
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description C2251 F1J1A106A043 C 0.010UF, K, C2525 ECJ1VB1H102K C 1000PF, K, 50V C2526 ECJ1VB1H102K C 1000PF, K, 50V C2261 F1J1A106A043 C 0.010UF, K, C2527 ECJ1VB1H102K C 1000PF, K, 50V...
Page 118
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description C3092 F1J1A106A043 C 0.010UF, K, C4614 F1G1C104A116 C 0.10UF, K, 16V C4616 F1J1A475A039 C 4.7UF, K, 10V C3095 F2G1C1010034 E 100PF, J, 16V C4617 F1J0G2260001 C 0.001UF, 6.3V...
Page 119
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description C5626 F1G1C104A116 C 0.10UF, K, 16V C8036 F1J1A106A043 C 0.010UF, K, C5627 F1G1C104A116 C 0.10UF, K, 16V C8037 F1G1C104A116 C 0.10UF, K, 16V C5628 ECGRL0G680ER C 68PF, J, 4V...
Page 120
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description C8336 F1G1E103A123 C 0.010UF, K, BA/EA C9841 F1G1C104A116 C 0.10UF, K, 16V C9842 F1G1C104A116 C 0.10UF, K, 16V C8338 F1G1H220A731 C 22UF, 50V BA/EA...
Page 121
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description C9940 F1G1C104A116 C 0.10UF, K, 16V C14971 F1J1H221A709 C 220UF, 50V C9941 F1G1C104A116 C 0.10UF, K, 16V C14972 F1J1H221A709 C 220UF, 50V C9942 F1G1C104A116 C 0.10UF, K, 16V...
Page 122
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description C16472 F1K1E105A029 C 1UF, Z, 25V C16862 F1H1C104A143 C 0.1UF, K, 16V C16491 F1L2J1020001 C 1000UF, K,6.3V C16863 F1H1H103A970 C 0.001UF, K, C16501 F1K1E105A029 C 1UF, Z, 25V...
Page 123
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description D2530 MAZ80560ML ZENER DIODE D14956 B0HCMM000013 DIODE D3013 MAZ81400ML ZENER DIODE D14958 B0HCMM000013 DIODE D3014 MAZ81400ML ZENER DIODE D14959 MA2J11100L DIODE...
Page 124
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description D16619 B0ECKP000047 DIODE D16631 MAZ82400ML DIODE K1KY16BA0192 16P CONNECTOR D16632 MAZ82400ML DIODE D16641 B0FBCN000006 DIODE GS52 K1KA12A00317 12P CONNECTOR D16642 B0FBCN000006 DIODE D16660...
Page 125
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description IC14956 AN16082A-VT JS3712 D0GDR00Z0002 M 0 OHM, 1/10W IC14961 C0JBAZ000994 IC JS3713 D0GDR00Z0002 M 0 OHM, 1/10W IC14962 C0JBAZ000994 IC JS7701 D0GBR00Z0002 M 0 OHM J 1/16W...
Page 126
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description L8003 J0JHC0000045 CHIP INDUCTOR TXN/G1RRTB CIRCUIT BOARD G PAVCCZ L8004 J0JHC0000045 CHIP INDUCTOR TXN/K1RWTB CIRCUIT BOARD K PAVCCZ BA/EA L8005 J0JHC0000045 CHIP INDUCTOR...
Page 127
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description Q16304 2SB0709ASL TRANSISTOR R1106 ERJ2GEJ101 M 100 OHM, J,0.063W Q16331 2SK326800L R1107 ERJ2GEJ101 M 100 OHM, Q16339 2SK326800L J,0.063W Q16401 2PG0090000RP TRANSISTOR...
Page 128
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R2002 ERJ2GEJ681 M 680 OHM, R2125 ERJ8GEYJ3R3V M 3.3 OHM, J,1/ J,0.063W R2003 ERJ2GEJ105 M 1MOHM, R2127 ERJ8GEYJ3R3V M 3.3 OHM, J,1/ J,0.063W R2006 ERJ2GEJ471...
Page 129
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R3008 ERJ2GEJ222 M 2.2KOHM, R3115 ERJ2GEJ221 M 220 OHM, J,0.063W J,0.063W R3009 ERJ2GEJ222 M 2.2KOHM, R3116 ERJ2GEJ221 M 220 OHM, J,0.063W J,0.063W R3010...
Page 130
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R3245 ERJ2GEJ221 M 220 OHM, R4624 ERJ2GEJ103 M 10KOHM, J,0.063W J,0.063W R3716 ERJ6GEYJ184 M 180KOHM,J,1/ R4625 ERJ2GEJ103 M 10KOHM, J,0.063W R3717 ERJ6GEYJ184...
Page 131
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R5512 ERJ2GEJ101 M 100 OHM, R7703 ERJ2GEJ680 M 68 OHM, J,0.063W J,0.063W R5535 ERJ2GEJ222 M 2.2KOHM, R7704 ERJ2GEJ680 M 68 OHM, J,0.063W J,0.063W...
Page 132
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R8075 ERJ2GEJ470 M 47 OHM, R8336 EXB2HV680J RESISTOR ARRAY BA/EA J,0.063W R8337 EXB28V680JX RESISTOR ARRAY BA/EA R8076 ERJ2GEJ470 M 47 OHM, R8338 ERJ2GEJ680...
Page 133
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R8454 EXB28V151J RESISTOR ARRAY BA/EA R8808 ERJ2GEJ103 M 10KOHM, J,0.063W R8456 ERJ2GEJ680 M 68 OHM, BA/EA J,0.063W R8809 ERJ2GEJ103 M 10KOHM, J,0.063W...
Page 134
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R8892 ERJ2GEJ680 M 68 OHM, R9063 ERJ2GEJ101 M 100 OHM, J,0.063W J,0.063W R8894 ERJ2GEJ680 M 68 OHM, R9064 ERJ2GEJ101 M 100 OHM, J,0.063W...
Page 135
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R9166 ERJ2GEJ103 M 10KOHM, R9588 ERJ2GEJ472 M 4.7KOHM, J,0.063W J,0.063W R9170 ERJ2GEJ393 R9598 ERJ2GEJ470 M 47 OHM, 39KOHM,J,0.063W J,0.063W R9171 ERJ2GEJ393...
Page 136
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R9958 D0GDR00Z0002 M 0 OHM, 1/10W R14957 ERJ3GEYJ220 M 22 OHM,J,1/16W R9966 ERJ2GEJ681 M 680 OHM, R14958 ERJ3GEYJ220 M 22 OHM,J,1/16W J,0.063W R14959...
Page 137
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R16110 ERJ6GEYF473 M 47KOHM,J,1/10W R16304 ERJT08J751V M750 OHM,F,0.33W PAVCCZ R16116 ERJ6GEYF473 M 47KOHM,J,1/10W R16305 ERJ6GEYJ271V M 270 OHM J 1/ R16131 D0GD101JA036 M 100 OHM,J,0.25W...
Page 138
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R16510 ERJT14J1R0U C1.0 OHM, J,1/4W R16661 ERJ6GEYG182 M 1.8KOHM,J,1/ R16511 ERJ6GEYF473 M 47KOHM,J,1/10W R16662 ERJ6ENF3001 M 3KOHM, 1/10W R16512 ERJ6GEYF473 M 47KOHM,J,1/10W...
Page 139
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R16769 ERJT06J750V M 75 OHM,F,0.25W R17156 D0GZ6R8JA020 M 6.8 OHM,J, 0.5W R16774 ERG1SJ683 M 68KOHM, J, 1W R17157 D0GZ6R8JA020 M 6.8 OHM,J, R16775 ERJ6GEYJ472V M 4.7K OHM J 1/...
Page 140
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description SS11 K1KA02A00676 2P CONNECTOR C421 ECJ1VB1E104K C 0.10UF, K, 25V SS12 K1KA10AA0194 10P CONNECTOR C423 ECJ1VB1H472K C 4700PF, K, 50V SS23 K1KA12AA0194 12P CONNECTOR C425...
Page 141
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description C574 ECJ1VB1E104K C 0.10UF, K, 25V D438 B0BC02000014 ZENER DIODE C577 F2A2A3300016 E 33UF, 100V D439 B0EAKT000048 DIODE D441 B0HAMM000122 DIODE C581...
Page 142
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description L403 EXCELSA35 BEAD CHOKE R409 D0GB102JA057 M 1KOHM,J,1/16W L404 G0B123K00004 CHOKE COIL R410 D1AB2203A023 CHIP RESISTOR R411 ERF5TJ100 W 10 OHM, J, 5W L405 G0B123K00004 CHOKE COIL...
Page 143
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R502 ERJ3GEYJ224 M 220KOHM,J,1/ R575 ERJ3GEYJ224 M 220KOHM,J,1/ R503 ERJ3GEYJ224 M 220KOHM,J,1/ R576 ERJ6RBD123V M 12KOHM, 1/10W R577 ERJ6GEYG102 M 1KOHM,J,1/10W R505...
Page 144
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R644 ERJ8RQFR39 M 0.39OHM, J,1/ R719 ERJ6GEYG102 M 1KOHM,J,1/10W R720 D0GB152JA057 M 1.5KOHM,J,1/ R645 ERJ6GEYJ101V M 100 OHM,J,1/ R721 ERJ6GEY0R00V M 0 OHM, 1/10W R646...
13.2.3. Electrical Replacement Parts List (37 inch) Safety Ref. No. Part No. Part Name & Pcs Remarks Description Safety Ref. No. Part No. Part Name & Pcs Remarks C2106 F1G1C104A116 C 0.10UF, K, 16V Description C2107 F2G0J470A019 E 47UF 6.3V C2108 F2G0J470A019 E 47UF 6.3V K1KA11A00178 11P CONNECTOR...
Page 146
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description C2251 F1J1A106A043 C 0.010UF, K, C2525 ECJ1VB1H102K C 1000PF, K, 50V C2526 ECJ1VB1H102K C 1000PF, K, 50V C2261 F1J1A106A043 C 0.010UF, K, C2527 ECJ1VB1H102K C 1000PF, K, 50V...
Page 147
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description C3092 F1J1A106A043 C 0.010UF, K, C4614 F1G1C104A116 C 0.10UF, K, 16V C4616 F1J1A475A039 C 4.7UF, K, 10V C3095 F2G1C1010034 E 100PF, J, 16V C4617 F1J0G2260001 C 0.001UF, 6.3V...
Page 148
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description C5626 F1G1C104A116 C 0.10UF, K, 16V C8036 F1J1A106A043 C 0.010UF, K, C5627 F1G1C104A116 C 0.10UF, K, 16V C8037 F1G1C104A116 C 0.10UF, K, 16V C5628 ECGRL0G680ER C 68PF, J, 4V...
Page 149
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description C8336 F1G1E103A123 C 0.010UF, K, BA/EA C9841 F1G1C104A116 C 0.10UF, K, 16V C9842 F1G1C104A116 C 0.10UF, K, 16V C8338 F1G1H220A731 C 22UF, 50V BA/EA...
Page 150
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description C9940 F1G1C104A116 C 0.10UF, K, 16V C14973 F1J1H102A834 C 1000UF, 50V C9941 F1G1C104A116 C 0.10UF, K, 16V C14976 F1J1H102A834 C 1000UF, 50V C9942 F1G1C104A116 C 0.10UF, K, 16V...
Page 151
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description C16472 F1K1E105A029 C 1UF, Z, 25V C16862 F1H1C104A143 C 0.1UF, K, 16V C16491 F1L2J1020001 C 1000UF, K,6.3V C16863 F1H1H103A970 C 0.001UF, K, C16501 F1K1E105A029 C 1UF, Z, 25V...
Page 152
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description D3014 MAZ81400ML ZENER DIODE D14961 MA8056H ZENER DIODE D3701 MAZ81400ML ZENER DIODE D14962 MA2J11100L DIODE D3702 MAZ81400ML ZENER DIODE D14971 MA2J11100L DIODE...
Page 153
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description D16660 B0HCMM000014 DIODE IC1100 MN103SG3FPA1 IC D16661 MA2J11100L DIODE IC1101 TVRP929-3 PAVCCZ D16662 MA8330M ZENER DIODE IC1102 C0JBAZ002261 IC D16663 MA8330M ZENER DIODE...
Page 154
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description IC16241 C0JBAZ002811 IC L1100 J0JYC0000068 CHIP INDUCTOR IC16251 C0BBBA000024 IC L2001 G1C150KA0038 INDUCTION COIL IC16301 MIP9L02MBS L2005 J0JCC0000284 CHIP INDUCTOR IC16302 C0CBALC00012 IC L2006...
Page 155
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description L8010 J0JHC0000045 CHIP INDUCTOR Q2001 2SD0601ARL TRANSISTOR L8301 J0JHC0000045 CHIP INDUCTOR BA/EA Q2022 2SB0709ARL TRANSISTOR L8304 J0JHC0000045 CHIP INDUCTOR BA/EA Q2027 B1CFNG000001 FET...
Page 156
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description Q16441 B1JAEP000003 TRANSISTOR R1140 ERJ2GEJ473 M 47KOHM, J,0.063W Q16451 B1JADP000003 TRANSISTOR R1153 ERJ2GEJ821 M 820 OHM, Q16471 B1ABCF000231 TRANSISTOR J,0.063W Q16501 B1HFPFA00001 TRANSISTOR...
Page 157
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R2008 ERJ2GEJ471 M 470 OHM, R2133 ERJ2GEJ100 M 10 OHM, J,0.063W J,0.063W R2015 ERJ2GEJ103 M 10KOHM, R2137 ERJ2GEJ100 M 10 OHM, J,0.063W J,0.063W...
Page 158
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R3012 ERJ2GEJ222 M 2.2KOHM, R3119 ERJ2GEJ221 M 220 OHM, J,0.063W J,0.063W R3013 ERJ2GEJ222 M 2.2KOHM, R3120 ERJ2GEJ331 M 330 OHM, J,0.063W J,0.063W R3019...
Page 159
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R3758 ERJ6ENF6651 M6.65KOHM, 1/10W R4636 ERJ2GEJ680 M 68 OHM, J,0.063W R3767 ERJ6ENF7151 M7.15KOHM, 1/10W R4637 ERJ2GEJ680 M 68 OHM, R4280 ERJ2GEJ473 M 47KOHM,...
Page 160
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R5542 ERJ6GEYJ471 M 470 OHM,J,1/ R7709 ERJ2GEJ680 M 68 OHM, J,0.063W R5544 ERJ2GEJ221 M 220 OHM, R7710 ERJ2GEJ101 M 100 OHM, J,0.063W J,0.063W...
Page 161
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R8079 D0YAR0000007 M 0 OHM 1/4W R8345 ERJ2GEJ103 M 10KOHM, BA/EA J,0.063W R8080 D0YAR0000007 M 0 OHM 1/4W R8347 D0YAR0000007 M 0 OHM 1/4W BA/EA...
Page 162
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R8458 ERJ2GEJ680 M 68 OHM, BA/EA R8811 D0YAR0000007 M 0 OHM 1/4W J,0.063W R8812 D0YAR0000007 M 0 OHM 1/4W R8459 ERJ2GEJ680 M 68 OHM,...
Page 163
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R8897 D0YAR0000007 M 0 OHM 1/4W R9065 ERJ2GEJ101 M 100 OHM, J,0.063W R8898 ERJ2GEJ103 M 10KOHM, J,0.063W R9066 ERJ2GEJ101 M 100 OHM, J,0.063W...
Page 164
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R9171 ERJ2GEJ393 R9604 ERJ2GEJ103 M 10KOHM, 39KOHM,J,0.063W J,0.063W R9172 ERJ2GEJ393 R9608 EXB2HV470JV RESISTOR ARRAY 39KOHM,J,0.063W R9609 EXB2HV470JV RESISTOR ARRAY R9187 ERJ2GEJ472 M 4.7KOHM,...
Page 165
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R9967 ERJ2GEJ470 M 47 OHM, R14969 ERJ6GEYJ332V M 3.3K OHM J 1/ J,0.063W R9968 ERJ2GEJ470 M 47 OHM, R14970 ERJ6GEYJ472V M 4.7K OHM J 1/ J,0.063W...
Page 166
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R16154 ERJT06J750V M 75 OHM,F,0.25W R16316 ERJ6GEYJ103V M 10K OHM J 1/ R16155 ERJT08J1R0V M 1.8OHM,J, 0.33W R16321 ERJ6GEYF473 M 47KOHM,J,1/10W R16159...
Page 167
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R16535 ERJT08J1R0V M 1.8OHM,J, R16674 ERJT08J102V M 1KOHM,J, 0.33W 0.33W R16676 ERJ6GEYJ472V M 4.7K OHM J 1/ R16536 ERJT08J1R0V M 1.8OHM,J, 0.33W...
Page 168
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R16791 ERJ6GEYJ102V M 1K OHM J 1/10W R17216 D0GZ6R8JA020 M 6.8 OHM,J, 0.5W R16794 ERJ6ENF2003 M 200KOHM, 1/10W R17217 D0GZ6R8JA020 M 6.8 OHM,J, R16795...
Page 169
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description SW3754 EVQPC105K SWITCH C451 ECKD3A101KBP C 100PF, K, 1KV SW3755 EVQPC105K SWITCH C457 ECWH12333RHV P 0.013UF,J,1.2KV SW3756 EVQPC105K SWITCH C462 F1J1E225A209 C 2.2 UF 25V...
Page 170
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description C623 F2A1H1000083 E 10UF, 50V D531 B0HBSN000013 DIODE C624 ECJ1VB1H103K C 0.001UF, K, D535 MA188 DIODE D536 MA3DD82 DIODE C625 F2A1H1000083 E 10UF, 50V...
Page 171
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description PR509 ERBSE0R50U FUSE R431 D0GB103JA057 M 10K OHM J 1/ PR601 K5G312B00012 FUSE R432 D1AB4303A023 CHIP RESISTOR R433 ERJ6RBD123V M 12KOHM,J,1/10W Q401...
Page 172
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R520 ERJ6GEYJ101V M 100 OHM,J,1/ R592 ERJ3GEYJ223 M 22KOHM,J,1/16W R593 ERJ3GEYJ104 M 100KOHM,J,1/ R521 ERJ6GEYJ104V M 100KOHM,J,1/ R594 D0GB151JA057 M 150 OHM J 1/ R523 ERJ6GEYF473...
Page 173
Safety Ref. No. Part No. Part Name & Pcs Remarks Safety Ref. No. Part No. Part Name & Pcs Remarks Description Description R659 ERJ3EKF3002 M 30KOHM, 1/16W R732 ERJ8GEYJ105V M 1MOHM, J,1/8W R660 ERJ3EKF1202 M 12KOHM, 1/16W R733 ERJ8GEYJ105V M 1MOHM, J,1/8W R661 EVMAASA00B53 CONTROL 5KOHMB R734...