Table of Contents
Advertisement
Advertisement
Table of Contents
Related Manuals for Louisiana Grills 420
Summary of Contents for Louisiana Grills 420
- Page 1 2010 M 2010 M ODELS ODELS Revised 0410...
- Page 2 Dear “Country Smoker” Wood Pellet Barbecue Owner: Thank you for choosing to purchase a “Louisiana Grill Country Smoker” wood pellet smoking’ grill. Cooking with your Louisiana Wood Pellet Grill is about to bring you full circle from the days of the caveman when cooking outdoors with wood was a necessity, to cooking indoors in your modern kitchen and now back to the great outdoors and that savory wood flavor.
-
Page 3: Table Of Contents
Contents & W ANGERS ARNINGS NPACKING OUNTRY MOKER SSEMBLY NSTRUCTIONS & L HEELS EVELERS ERIES OPPER SSEMBLY & H LAVOR UARD ANDLE RIDS THERMOMETER BUCKET NOWLEDGE IS OWER OUNTRY MOKER ORKS PECS RCHED LAVOR UARD GNITER & B RATE UGER EEDS OUISIANA RILLS... -
Page 4: Dangers & Warnings
Dangers & Warnings Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious bodily injury or death, or in a fire or cause damage to property. DO NOT “TAILGATE” PLACE THE MODEL DIRECTLY ON A COMBUSTIBLE SURFACE HERE MUST BE A COMBUSTIBLE SURFACE BETWEEN THE SMOKER AND A COMBUSTIBLE SURFACE WARNING:... -
Page 5: Unpacking Your Country Smoker
Unpacking Your Country Smoker IMPORTANT NOTICE Be sure to inspect the entire grill after removing the protective shipping carton. Report any damage to your local dealer immediately. Shipping damage is not covered under warranty. When you open your smoker/grill, please ensure you have and can identify all the following parts: NOTE: Numbers following parts names throughout this manual refer to... -
Page 6: Assembly Instruction
Assembly Instruction INSTALLING THE WHEELS & LEVELERS Parts Included: 2 Screw-On 2 Wheel Assemblies Leg Levellers wheel, axle, fender washer, and #3 hitch pin cli p Tools Required: None... -
Page 7: Series 3 Hopper Assembly
Assembly Instruction INSTALLING THE HOPPER & IGNITER Parts Included: Series 3 Hopper Assembly Mounting hardware Tools Required: Phillips & Standard Screwdrivers 1/4” Hex Nut Driver & 5/16” Hex Nut Driver Installation: Step 1 Protecting the Igniter : • Carefully remove the tape holding the igniter to the rear panel of the hopper. -
Page 8: Burn Pot And Burn Grate:
Assembly Instructions Installation: . . . Con’t Step 3 Installing the Igniter : • Carefully remove the igniter from within the hopper to the inside of the cooking barrel • Using your 1/4” nut driver and the 2 (two) remaining #10 x 16 x 1/2”... -
Page 9: Assembly Instructions
Assembly Instructions POSITIONING THE BURN POT AND BURN GRATE … con’t: Check position of the Igniter It is extremely important to have the igniter and the igniter hole in the burn grate line-up. The burn grate should not be sitting on top of the igniter or the hot rod. - Page 10 Assembly Instructions INSTALLING THE PORCELAIN GRIDS: • Your Country Smoker comes complete with 2 Porcelain Grids • NOTE: To maintain the searing and grilling performance of your grid, as well as their longevity, some special care and maintenance is required. INSTALLING THE THERMOMETER: The thermometer comes complete with its own threaded nut already installed on the thermometer.
-
Page 11: Knowledge Is Power
11. Grease Bucket NEW ! 12. “Arched Flavor Guard” 13. Porcelain Cooking Grids 14. Convection Cooking Chamber 15. Dome Thermometer 16. Air Cooled Vented Hopper 17. Convection Air Exhaust 18. “Louisiana Grills” Control 19. Bottom Shelf 20. Wheels 21. Leveling Legs... - Page 12 Knowledge is Power Your New 420, 450, 570, 680 Wood Pellet Fired Smokin Grills Powder Coat Finish Large 12lb. Hopper capacity Dome Thermometer Easy flip up top Time proven Metal Auger Feed System 450, 570, 680 14 Gauge Steel Construction...
-
Page 13: Arched Flavor Guard
Knowledge is Power Arched Flavor Guard All Country Smoker models come with a 14 gauge “Arched Flavor Guard”, designed to withstand high temperature and give years of performance. The Arched Flavor Guard has been designed to keep the flame out of direct contact with your cooking surface, thus helping to reduce the chance of flare-ups. -
Page 14: Louisiana Grills Standard Control
Knowledge is Power Louisiana Grills Standard Control Panel Board Features Power Switch Used to turn both the power “ON” and the combustion / cooling fan on. Also activates The “Shut Down” mode of the grill. START Touch Pad Used to activate the “Start Up” mode. The metal auger feed system will begin to operate, the Power LED will illuminate blue, and the Auto Igniter will begin to glow. -
Page 15: Hopper
Powder Coat Finish Louisiana Grills uses a “High Heat Powder Coat” finish throughout the entire line of the Country Smokers. This High Heat finish is rated for 1000°F. This is done to allow for easy and trouble free maintenance, and adding to the life of your smoking grill. -
Page 16: About Wood Pellets
Knowledge is Power About Wood Pellets They are no thicker than the eraser on the end of a pencil. People who see them for the first time think they look like rabbit food, but there is nothing small about the heat energy or flavor in a wood pellet. -
Page 17: Set Up Procedure
Getting Started Set Up Procedure Please note that during shipping or moving around on your deck, some movement within the grill may have taken place, so a complete visual inspection is required. Please follow these Initial Set-Up procedures to ensure the proper and safe operation of your grill. -
Page 18: Getting Started
2 to 3 season grill, depending on what part of the country you live in. For greater detail on grilling and weather conditions, see the “HOT and COLD” weather tips found in your Louisiana Grills Cook Book and Recipe Keeper. - Page 19 Getting Started Following is a list of the important tips that will contribute to the cooking perfection that you expect when using your Country Smoker. NOTE: The temperature markings on the control board are NOT accurate! Due to environment, fuel, and cooking conditions, the settings are only for reference! Operating the Grill …...
- Page 20 Getting Started Lighting Your Country Smoker It is a highly recommended practice to always go through these basic SET UP PROCEDURES, after every 1 to 3 cookings. This will ensure proper ignition, heat output and many continuous happy grilling experiences. Automatic Start Up Ensure the POWER switch is in the “OFF”...
-
Page 21: Manual Start Up
Getting Started Lighting Your Country Smoker … CON’T It is a highly recommended practice to always go through these basic SET UP PROCEDURES, after every 1 to 3 cookings. This will ensure proper ignition, heat output and many continuous happy grilling experiences. Manual Start Up If for any reason your electric igniter fails, you can start your Country Smoker manually. -
Page 22: Shutting Off Your Smoker
Getting Started Shutting OFF Your Smoker Your Country Smoker will give you many years of flavorful service with minimum cleaning. An important step is allowing the grill and cooking grids to “Self Clean” by running the grill on HIGH or PREHEAT temperatures for 5 to 10 minutes after each use. - Page 23 Grill Maintenance ….con’t OOKING RIDS When new, wash thoroughly with warm soapy water, place back in the smoker and PREHEAT the grill for 20 to 30 minutes. After the completion of grilling, open the lid and with a long handle grill cleaning brush give the grids a thorough cleaning. If you do not have a cleaning brush use long handle tongs and a balled up piece of aluminum foil wrap.
- Page 24 Grill Maintenance … con’t ERIES The proper seating of the Burn Pot is crucial to proper grill performance. The Series 3 Burn Pot has a solid, sealed bottom with a slot to permanently screw the pot to the barrel bottom The main function of the Burn Pot is to channel the fan forced air into the Burn Grate, thus there is very little maintenance required.
-
Page 25: Wiring Diagram
Wiring Diagram... -
Page 26: Limited Warranty
Limited Warranty The “Country Smoker” wood pellet barbecue line, manufactured by Canadian Comfort Industries (CCI), carries a five (5) year limited warranty for from the date of sale to the original owner only, against defects and workmanship on all steel parts, (excluding the burn grate), and three (3) year on electrical components. There is no specific warranty on the paint, powder coat, burn grate, grill cover and all gaskets or against damage caused from corrosion. -
Page 27: Limited Warranty
Limited Warranty Exceptions to the Limited Warranty There is no written or implied performance warranty on “Country Smoker” appliances, as the manufacturer has no control over the installation, operations, cleaning, maintenance or the type of fuel burned. This limited warranty will not apply nor will CCI assume responsibility if your appliance has not been installed, operated, cleaned and maintained in strict accordance with the manufacturer's instructions. -
Page 28: Parts & Service
If for any reason you do not have a local dealer, Dansons Inc. is proud to offer the best technical and sales support in the industry. If you require parts, options, rubs and spices, or general accessories you can contact the factory directly : Proudly Made In Louisiana Grills Customer Service T0LL FREE: 1-877-303-3134 TOLL FREE FAX: 1-877-303-3135 Email: service@dansons.com...