BRP EVINRUDE E15R4 Operator's Manual page 63

Description
Propeller
Gear oil
Lower Unit
Cooling water
inlet
*1
Water pump
*1
Power tilt
*1
Warning system
Bolts and Nuts
Throttle wire
Remote control cable
Sliding and Rotating Parts.
Grease Nipples
Outer Equipment
Anode
*1: Have this handled by your dealer.
ENON00030-0
Note
Your outboard motor should receive careful, and complete inspection at 300 hours. This is the best
time for major maintenance procedures to be carried out.
ENOM00091-A
Engine oil replacement
Engine oil mixed with dust or water will
dramatically shorten the life of the engine.
ENOW00091-0
CAUTION
You may be injured due to high engine tem-
peratures if you fill engine oil just after
stopping. Changing engine oil should be
done after the engine has been cooled.
ENOW00092-0
CAUTION
 Do not overfill engine oil, or engine oil
could leak and/or engine could be dam-
aged. If engine oil level is over upper
limit marks of oil gauge, drain oil to level
lower than upper limit.
Inspection intervals
First 20 Every 50 Every 100 Every 200
hours or 1 hours or 3 hours or 6 hours or 1
month months months year
 
Replace Replace

 
 
Replace

 

 


 
 

INSPECTION AND MAINTENANCE
Inspection procedure
Check for bent blades, damage, wear.
Replace if necessary. (Seepage 68)
Change or replenish-oil and check for
water leaks. (See page 58)
Check clogging
Check for wear or damage and replace

if necessary
Check & replenish oil, manually operate
Check function
Retighten
Check for wear or damage and replace
if necessary
Check and adjust if necessary
Apply and pump in grease. (See
page 73)
Check for corrosion.
Check for corrosion and deformation.
 Be sure that outboard motor is in upright
and level position when checking or
changing oil.
 Stop engine immediately if low oil pres-
sure warning lamp is lit or oil leak is
found, or engine could be severely dam-
aged. Consult dealer.
 Wipe off engine oil well immediately if
spilled and dispose of it in accordance
with local fire prevention and environ-
ment protection regulations.
ENOW00090-0
CAUTION
Use of engine oils that do not meet these
requirements will result in reduced engine
life, and other engine problems.
63
Remarks
500 mL (16.9
fl.oz.)
Replace impeller
every 12 months.
Replace if
necessary.
10