Page 1
Tools required for assembly and service may not be included. For technical questions or replacement parts, please call 1-800-444-3353. mAchine 99702 ® . All rights reserved. No portion of this manual or any artwork ®...
SKU 99702 For technical questions, please call 1-800-444-3353. nOtice is used to address practices not related to personal injury. cAutiOn, without...
Page 3
SKU 99702 For technical questions, please call 1-800-444-3353. prevent unintentional starting. ensure the switch is in the off-po- sition before connecting to power source and/or battery pack, pick- ing up or carrying the tool.
Page 4
Do not allow spray to strike you and do not spray toward SKU 99702 For technical questions, please call 1-800-444-3353. people or animals. Do not spray the tool itself or any electrical source.
Wash hands after handling. (Califor- nia Health & Safety Code § 25249.5, et seq.) SKU 99702 For technical questions, please call 1-800-444-3353. The warnings, precautions, and in- structions discussed in this instruction manual cannot cover all possible con- ditions and situations that may occur.
(see table A.) SKU 99702 For technical questions, please call 1-800-444-3353. The smaller the gauge number of the wire, the greater the capacity of the cord.
Page 8
150% of the rated amperes. symbology Double Insulated Canadian Standards Association Underwriters Laboratories, Inc. Volts Alternating Current Amperes No Load Revolutions per Minute n 0 xxxx/min. (RPM) SKU 99702 For technical questions, please call 1-800-444-3353. Page 8...
For additional information regarding the parts listed in the following pages, refer to the Assembly Diagram near the end of this manual. SKU 99702 For technical questions, please call 1-800-444-3353. Assembly Turn the knobs on the handle coun- terclockwise, pull the handle up, and secure it by turning the knobs clock- wise.
Remove the plastic cap from gun tip. Thread the suction tube onto the inlet valve. Press the return tube onto the return tube fitting. SKU 99702 For technical questions, please call 1-800-444-3353. return tube on return tube fitting OperAting instructiOns...
Lay the pump on its back and remove the oil cap. Fill with a good quality SKU 99702 For technical questions, please call 1-800-444-3353. hydraulic oil. Replace the cap and set the unit upright. Push the lubrication button on the face of the unit ten times to lubricate the system before each use.
Page 12
“SPRAY” position and hold the Trig- ger down until all air and impurities are cleansed from the Hose and the paint runs pure. SKU 99702 For technical questions, please call 1-800-444-3353. Release the Trigger. Turn the “PRIME/SPRAY” knob to the “PRIME”...
Page 13
Trigger to discharge Gun and Hose pressure. Lock the Gun. Disconnect the power supply after use. Clean, then store the tool in- doors out of children’s reach. SKU 99702 For technical questions, please call 1-800-444-3353. Page 13...
Page 14
When using oil based paint, use mineral spirits to clean the sprayer and components. SKU 99702 For technical questions, please call 1-800-444-3353. Lock the Gun and remove the Spray Tip assembly. Submerge the Suction Tube in a container with the appropriate clean- ing solution.
Page 15
Clean the washer, and spray tip seat. Reassemble the Gun. WArning! if the supply cord of this power tool is damaged, it must be replaced only by a qualified service technician. SKU 99702 For technical questions, please call 1-800-444-3353. Page 15...
ASSUMES ALL RISk AND LIAbILITy ARISING OUT Of HIS OR HER REPAIRS TO THE ORIGINAL PRODUCT OR REPLACEMENT PARTS THERETO, OR ARISING OUT Of HIS OR HER INSTALLATION Of REPLACEMENT PARTS THERETO. SKU 99702 For technical questions, please call 1-800-444-3353. troubleshooting likely solutions Check power at outlet.
If product has no serial number, record month and year of purchase instead. note: Some parts are listed and shown for illustration purposes only, and are not avail- able individually as replacement parts. SKU 99702 For technical questions, please call 1-800-444-3353. pump pArts list...
Page 20
When order parts from this list use the suffix “b” note: Some parts are listed and shown for illustration purposes only, and are not avail- able individually as replacement parts. SKU 99702 For technical questions, please call 1-800-444-3353. Page 20...
Page 21
When order parts from this list use the suffix “C” note: Some parts are listed and shown for illustration purposes only, and are not avail- able individually as replacement parts. SKU 99702 For technical questions, please call 1-800-444-3353. gun pArts list &...
3491 Mission Oaks Blvd. • PO Box 6009 • Camarillo, CA 93011 • (800) 444-3353 record product’s serial number here: note: If product has no serial number, record month and year of purchase instead. SKU 99702 For technical questions, please call 1-800-444-3353. Page 22...