Related Manuals for Elkay smartwell SW1806CR
Summary of Contents for Elkay smartwell SW1806CR
- Page 1 Installation Manual Beverage Dispenser ™ Smartwell Countertop Beverage Dispenser with Remote Chiller Model - SW1806CR Read the instructions in this manual and retain for future reference. WARNING...
-
Page 2: Table Of Contents
What`s in the Box ....... 7 ELKAY Smartwell Documents..... . 2 Smartwell Cabinet (Optional) . -
Page 3: Disclaimer
Elkay is used, you must be satisfied that it is safe for yourself and from sheet metal components. others. You should also make sure that the product will not be damaged Shock and Electrocution Hazards by the methods you choose. -
Page 4: Key Components
Still water inlet Switch Sparkling water inlet Smartwell power switch and circuit breaker reset Note: Sparkling water inlet is labeled as "CO port" on the back of the unit Elkay Manufacturing Company Countertop Installation Manual (2000000029 Rev. B - 01/22) -
Page 5: Installation Preparation
NOTICE to route the tubes to the Remote Chiller and CO tank. 1. Elkay recommends a water pressure of 40 to 105 psi Note: No additional holes are required if installing onto on our cooler products. A pressure regulator provided the Smartwell Cabinet. - Page 6 * 20 lb. CO tank shown for reference. Compatible with smaller tank sizes. ** Depth of the kitchen cabinet should be at least 22 inches. ***Refer P/N 2000000401 for ventilation instruction sheet/template. Elkay Manufacturing Company Countertop Installation Manual (2000000029 Rev. B - 01/22)
-
Page 7: Installation
2. Unbox the Smartwell Cabinet, inspect to ensure no shipping damage, then place upright on the floor in desired location for the Smartwell. Lifting Hazard Use two people to carefully lift the Countertop dispenser unit. Elkay Manufacturing Company Installation Manual (2000000029 Rev. B - 01/22) Countertop... - Page 8 Note: Refer section 5.6, steps 1 and 2 for detailed connection between the Remote Chiller and the Countertop unit. Shut off Valve Pressure Regulator 10. Install the CO regulator on top of the CO tank. Elkay Manufacturing Company Countertop Installation Manual (2000000029 Rev. B - 01/22)
-
Page 9: Chiller Duct Installation In Kitchen Cabinet
Note: The location where the filter is stored should not exceed 100°F. 1. Remove 4 screws from the grate on the back of the chiller. Screw Screw Filter Head Elkay Manufacturing Company Installation Manual (2000000029 Rev. B - 01/22) Countertop... - Page 10 Remove four Phillips screws and the cover from port on the Remote Chiller. the back of the chiller. Note: This reveals the overflow tube. Water Inlet port Remote Chiller Filter Remote Chiller Elkay Manufacturing Company Countertop Installation Manual (2000000029 Rev. B - 01/22)
-
Page 11: Connecting The Remote Chiller And Countertop
15 feet. Cold Water Outlet Port Still Water Inlet Port Remote Chiller b. Use an Ethernet cable to connect the Wi-Fi extender to the back of the Countertop unit. Elkay Manufacturing Company Installation Manual (2000000029 Rev. B - 01/22) Countertop... -
Page 12: Startup Instructions
Confirm both ports are not blocked by any firewall or network settings. b. If connecting the unit with an Ethernet cable directly to your network, select Ethernet connection. Elkay Manufacturing Company Countertop Installation Manual (2000000029 Rev. B - 01/22) -
Page 13: Pouches
Save. — The right-hand screen will appear if the unit is Countertop connected to the Internet. Select the appropriate Unit time zone settings, then press Save. Elkay Manufacturing Company Installation Manual (2000000029 Rev. B - 01/22) Countertop... - Page 14 Select either the 5, 10, 15, 20 lb. tank capacity Note: Check and ensure the flow straightener is being installed. snapped properly. Enhancement Pouch Pump Flow Straightener Manifold Elkay Manufacturing Company Countertop Installation Manual (2000000029 Rev. B - 01/22)
-
Page 15: Purging The Water Lines
CO tank counterclockwise until it is fully opened. OPEN 10. The Elkay Smartwell customer portal should now be accessible if the unit is connected to the Internet. Login and confirm the unit appears in the listing page. Elkay Manufacturing Company Installation Manual (2000000029 Rev. -
Page 16: Set The Water Flow Parameters
26.613. Enter 27 into the data field. 4) If the beverage is being measured in milliliters, then flow rate is equal to the measured volume b. Elkay smartwell touchless screen will appear. divided by 10. Accept the Terms and Conditions. Press submit. -
Page 17: Unit Diagnostics
Enter 0101 and press the Sign In button. 2. Press the Set Up button on the admin screen and then press the Unit Diagnostics button. Elkay Manufacturing Company Installation Manual (2000000029 Rev. B - 01/22) Countertop... - Page 18 END OF DOCUMENT FOR PARTS, CONTACT YOUR LOCAL DISTRIBUTOR OR CALL 1.800.834.4816 REPAIR SERVICE INFORMATION TOLL FREE NUMBER 1.800.260.6640 ELKAY MANUFACTURING COMPANY • 1333 BUTTERFIELD ROAD SUITE 200 DOWNERS GROVE, IL 60515 • 630.574.8484 • www.elkay.com Elkay Manufacturing Company Countertop...