Figure 63 - Sample Printout (Status) - York YK Style H Operation Manual

SECTION 4 - PRINTING
YORK Update
ChilleR id 0
(c) 1997 – 2001 YORK INTERNATIONAL CORPORATION
Mon 22 Nov 1999 8:50:45 AM
SYSTEM RUN
LEAVING CHILLED LIQUID CONTROL
[List all warnings presently active]
Controls C.MLM.01.06.102
Run Time 0 Days 2 Hr 59 Min
Operating Hours
Number Of Starts
Control Source
Evaporator
-----------------------------------------------------------------------------------
Leaving Chilled Active Setpoint
Chilled Liquid Pump
Chilled Liquid Flow Switch
Leaving Chilled Liquid Temperature
Return Chilled Liquid Temperature
Evaporator Pressure
Evaporator Saturation Temperature
Evaporator Refrigerant Temperature
[If Refrigerant Sensor enabled]
Small Temperature Difference
Condenser
-----------------------------------------------------------------------------------
Condenser Liquid Pump
Condenser Liquid Flow Switch
Leaving Condenser Liquid Temperature
Return Condenser Liquid Temperature
Condenser Pressure
Condenser Saturation Temperature
Small Temperature Difference
Drop Leg Refrigerant Temperature
[If Drop Leg Sensor enabled]
Sub Cooling Temperature
[If Drop Leg Sensor enabled]
Compressor
-----------------------------------------------------------------------------------
Discharge Temperature
Liquid Line Solenoid
[If Mod C Chiller]
Vent Line Solenoid
[If Mod D Chiller or higher]
Oil Sump
-----------------------------------------------------------------------------------
Oil Pump Run Output
Sump Oil Pressure (LOP)
Pump Oil Pressure (HOP)
Oil Pressure
Oil Sump Temperature
Oil Heater
[If Mod D Chiller or higher]
Oil Return Solenoid
[If Mod D Chiller or higher]

FIGURE 63 - SAMPLE PRINTOUT (STATUS)

194
[Skip the following section if Hot Gas Bypass is not
enabled]
Hot Gas
-----------------------------------------------------------------------------------
Valve Position
Pre-Rotation Vanes Position
Surge
-----------------------------------------------------------------------------------
Total Surge Count
Surge Window Time
= 25 Hr
Surge Window Count
= 6
= Local
[Skip the following section if Variable Speed Oil
Pump is not installed]
Variable Speed Oil Pump
-----------------------------------------------------------------------------------
= 45.0 ~F
Oil Pump Drive Command Frequency
= Run
Pulldown Time Remaining
= Closed
[If Pulldown in effect]
= 45.0 ~F
= 55.0 ~F
[Skip the following section if Liquid Level is not
= 75.0 Psig
enabled]
= 44.4 ~F
Refrigerant Level Control
= 44.5 ~F
-----------------------------------------------------------------------------------
Refrigerant Level Position
= 0.5 ~F
Ramp Up Time Remaining
[If Ramp Up in effect]
Proximity Probe
= Run
-----------------------------------------------------------------------------------
= Closed
High Speed Thrust Bearing Proximity Differen = 2 Mils
= 95.0 ~F
High Speed Thrust Solenoid
= 85.0 ~F
[If Mod C Chiller]
= 200.0 Psig
= 101.4 ~F
[Skip the following section if Motor Type is not EM]
= 6.4 ~F
Electro-Mechanical Starter
= 83.0 ~F
-----------------------------------------------------------------------------------
Motor Run
= 18.4 ~F
% Full Load Amps
[Skip the following section if Motor Type is not Mod A SSS]
Liquid-Cooled Solid State Starter
-----------------------------------------------------------------------------------
= 120.0 ~F
Motor Run
= On
% Full Load Amps
Phase A Voltage
= On
Phase B Voltage
Phase C Voltage
Phase A Current
Phase B Current
Phase C Current
= On
= 75.8 Psig
[Skip the following section if Motor Type is not Mod
= 124.6 Psig
B SSS]
= 47.8 Psid
Liquid-Cooled Solid State Starter
= 150.0 ~F
-----------------------------------------------------------------------------------
= Off
Starter Model
Motor Run
= Off
% Full Load Amps
kW Hours
Input Power
FIGURE 64 - SAMPLE PRINTOUT (STATUS) (CONT'D)
FORM 160.76-O2
issue date: 6/15/2015
= 15 %
= 75 %
= 127
= 1 Min
= 0
= 25.0 Hz
= 9.0 Min
= 35 %
= 15 Sec
= On
= On
= 94 %
= On
= 94 %
= 447 V
= 409 V
= 442 V
= 193 A
= 204 A
= 190 A
= 26L
= On
= 95 %
= 20723 kWH
= 8225 kW
JOHNsON CONtROLs