Table of Contents
Advertisement
Rear Discharge Grooming Mowers
FDR3590
15939
Table of Contents
310-229M
Operator's Manual
!
Read the Operator's manual entirely. When
you see this symbol, the subsequent
15939
instructions and warnings are serious - follow
without exception. Your life and the lives of
others depend on it!
© Copyright 2007 Printed
Cover photo may show optional equipment
not supplied with standard unit.
12/10/07
Advertisement
Table of Contents
Related Manuals for Land Pride FDR3590
Summary of Contents for Land Pride FDR3590
- Page 1 Rear Discharge Grooming Mowers FDR3590 15939 Table of Contents 310-229M Operator’s Manual Read the Operator’s manual entirely. When you see this symbol, the subsequent 15939 instructions and warnings are serious - follow without exception. Your life and the lives of others depend on it! ©...
-
Page 2: Table Of Contents
Copyright 2007 All rights Reserved Land Pride provides this publication “as is” without warranty of any kind, either expressed or implied. While every precaution has been taken in the preparation of this manual, Land Pride assumes no responsibility for errors or omissions. Neither is any liability assumed for damages resulting from the use of the information contained herein. Land Pride reserves the right to revise and improve its products as it sees fit. -
Page 3: Important Safety Information
For Your Protection Thoroughly read and understand the “Safety Label” section, read all instructions noted on them. FDR3590 Rear Discharge Grooming Mowers 310-229M WARNING Indicates a potentially hazardous situation which, if not avoided, could result in death or serious injury, and includes hazards that are exposed when guards are removed. - Page 4 Never allow children to operate equipment. FDR3590 Rear Discharge Grooming Mowers 310-229M Table of Contents Transport Machinery Safely Comply with state and local laws. Maximum transport speed for implement is 20 mph.
- Page 5 Operating equipment safely requires the full attention of the operator. Avoid wearing radio headphones while operating machinery. FDR3590 Rear Discharge Grooming Mowers 310-229M Avoid High Pressure Fluids Hazard Escaping fluid under pressure can penetrate the skin causing serious injury.
-
Page 6: Safety Labels
Keep all safety labels clean and legible. Replace all damaged or missing labels. To order new labels go to your nearest Land Pride dealer or visit our dealer locator at landpride.com. Some new equipment installed during repair requires safety labels to be affixed to the replaced component as... - Page 7 Land Pride Important Safety Information 12/10/07 Table of Contents 15945 15944 15945 15945 FDR3590 Rear Discharge Grooming Mowers 310-229M 818-237C Caution: V-Belt 818-142C Danger: Rotating Driveline 818-555C Danger: Rotating Blade 818-556C Danger: Thrown Object...
- Page 8 Important Safety Information FDR3590 Rear Discharge Grooming Mowers 310-229M Table of Contents 15943 ROTATING DRIVELINE KEEP AWAY! 13314 13314 Land Pride 818-558C Warning: General Safety 818-552C Danger: Rotating Driveline 818-540C Danger: Guard Missing 12/10/07...
-
Page 9: Introduction
Land Pride Introduction Introduction Land Pride welcomes you to the growing family of new product owners. This Grooming Mower has been designed with care and built by skilled workers using quality materials. Proper assembly, maintenance and safe operating practices will help you get years of satisfactory use from the machine. -
Page 10: Section 1: Assembly And Set-Up
(#7), lock washers (#5) and hex nuts (#6). Upper Hitch Arms Assembly Figure 1-1 FDR3590 Rear Discharge Grooming Mowers 310-229M Table of Contents 4. Remove 5/8"-18 x 5" GR5 long bolt (#8), lock washer (#10), and hex nut (#11) from the upper pivoting hitch subassembly. -
Page 11: Tractor Hook-Up
3-point to lift the lower arms until the Grooming Mower’s driveline shaft is approximately level with tractor's PTO shaft. 2. Slide inner driveline universal joint over the splined input shaft of the gearbox. Secure with driveline yoke locking device. FDR3590 Rear Discharge Grooming Mowers 310-229M 13800 Figure 1-3... -
Page 12: Checking Driveline Maximum Length
Refer to Figure 1-5 The driveline maximum length must, when fully extended, have a minimum overlap of the profile tubes by FDR3590 Rear Discharge Grooming Mowers 310-229M Table of Contents not less than 1/3 the free length with both inner and outer profile tubes being of equal length. -
Page 13: Accessory Equipment
There are four blade choices to select from based upon soil condition, density of grass, and tractor horsepower. The appearance of the finish cut may vary between low lift and high lift blades. See your Land Pride dealer for blade availability. Low Lift Blades Land Pride’s low lift blades are designed for mowing over... -
Page 14: Section 2: Operating Instructions
Lubricate the mower as needed. Refer to “Maintenance and Lubrication”. FDR3590 Rear Discharge Grooming Mowers 310-229M Table of Contents 3. Carefully raise and lower the implement to ensure that the drawbar, tires, and other equipment on the tractor do not contact the frame or PTO driveline. -
Page 15: Mowing Instructions
Frequent inspection should be made and blades replaced if damaged. Low lift blades are available from your Land Pride dealer. 1. Clear the area to be mowed of rocks, branches and other foreign objects that might be picked up and thrown by the mower blades. -
Page 16: General Operating Instructions
By now you should have thoroughly read your FDR Grooming Mower Operator’s Manual, properly attached your Land Pride FDR3590 to your tractor, and reviewed the operating checklist. You should have also inspected the area where you intend to mow and cleared it of safety hazards and foreign objects. -
Page 17: Section 3: Adjustments
For a guide on measuring cutting height refer to Cutting Height Chart below. 15948 Spindle Tube 10 1/8" Cutting Height Figure 3-2 FDR3590 Rear Discharge Grooming Mowers 310-229M Cutting Height Chart 5 5/8" 3/4" 6 1/8" 1 1/4" 7 1/8"... -
Page 18: Point Hitch Adjustments
2. To adjust belt tension, adjust eyebolt (#1), as necessary. This adjustment will increase or decrease tension on spring (#2). FDR3590 Rear Discharge Grooming Mowers 310-229M Table of Contents 3. Excessive tension on the belt may lead to premature failure of belt and drive components. Excessive tension on the belt may also lead to a safety hazard to the operator or bystanders. -
Page 19: Section 4: Maintenance And Lubrication
20. • Replace any worn, damaged or illegible safety labels by obtaining new labels from your Land Pride Dealer. Information about labels is located under Safety Labels in the “Important Safety Information” section starting on page 1. -
Page 20: Blade Sharpening Or Replacement
1. Verify blade rotation and bolt thread type (right hand or left hand) before loosening center blade bolts and removing blade to be sharpened or replaced. The FDR3590 is equipped with right hand threaded center blade bolts. IMPORTANT: Center Blade bolts have right hand threads. -
Page 21: V-Belt Installation
20. 5. Store unit inside if possible for longer life. 6. Repaint parts where paint is worn or scratched to prevent rust. Ask your dealer for Aerosol Land Pride touch-up paint. Land Pride Touch-up Paint Part No. -
Page 22: Lubrication
Section 4: Maintenance and Lubrication Lubrication Lubrication Multi-purpose Legend spray lube 24871 24871 24873 FDR3590 Rear Discharge Grooming Mowers 310-229M Table of Contents Multi-purpose Multi-purpose grease lube oil lube Driveline Shaft U-Joints Type of Lubrication: Multi-purpose Grease Quantity - 4 to 8 Pumps... -
Page 23: Gearbox
EP 80-90W oil until oil reaches full mark on the dipstick. Reinstall vent plug with dipstick and tighten. Take your gearbox to a Land Pride dealer if it requires service. Type of Lubrication: Gear Lube EP 80-90W Quantity = Fill until oil reaches full mark on dipstick. -
Page 24: Section 5: Specifications & Capacities
Blade Tip Speed Blade Spindles Hitch Quick Hitch Gauge Wheels Caster Wheel Spindle Drive Train Driveline Optional Equipment FDR3590 Rear Discharge Grooming Mowers 310-229M Table of Contents FDR3590 60 HP. 90" 92” 40” 81” 1026 lbs. 3/4” to 5 1/4” in 1/2” Increments 3/16”... -
Page 25: Section 6: Features And Benefits
Shows our confidence in the gearbox integrity. 5 year housing, gears, shafts, warranty 3 year bearings and seals. Quick Hitch Compatible Compatible with Land Pride Quick Hitch (S/N 294658+) for easy attachment and removal and increased productivity. 12/10/07 Table of Contents... -
Page 26: Section 7: Troubleshooting
Excessive vibration Gearbox noisy Blades scalping grass Uneven cut Tractor loaded down by mower FDR3590 Rear Discharge Grooming Mowers 310-229M Table of Contents Solution Check installation of belt. Wait until grass dries. Raise cutting height of mower and cut grass twice. -
Page 27: Section 8: Appendix
1950 4290 3160 mm x pitch = nominal thread diameter in millimeters x thread pitch 2190 4820 3560 FDR3590 Rear Discharge Grooming Mowers 310-229M Bolt Head Identification 10.9 Class 5.8 Class 8.8 Class 10.9 l215 1050 1150... -
Page 28: Notes
Table of Contents Land Pride Section 8: Appendix Notes FDR3590 Rear Discharge Grooming Mowers 310-229M 12/10/07... -
Page 29: Warranty
Belt, Blades, Friction Disc in Slip Clutches & Tires: Considered wear items. This Warranty is limited to the replacement of any defective part by Land Pride and the installation by the dealer of any such replacement part, and does not cover common wear items. - Page 30 Corporate Office: P.O. Box 5060 Salina, Kansas 67402-5060 USA www.landpride.com...