General Information On Ktm Disc Brakes - KTM 640 LC4 Owner's Manual

LC4
LC4 SUPERMOTO
1
3
DOT
5.1
General informations about KTM disc brakes
BRAKE CALIPERS (LC4):
The brake calipers of this series "float". This means that the brake calipers
are not solidly attached to the caliper support. Thus, the brake pads are
always in optimum contact with the brake disc. Secure the screws of the
caliper support with Loctite 243 and tighten to 25 Nm.
BRAKE CALIPERS (LC4 SUPERMOTO):
The front brake caliper
the fork leg. The rear brake caliper has one brake piston and "floats", which
means that it is not rigidly connected to the brake caliper support. The
resulting lateral adjustment ensures that the brake pads
against the brake disk at any time. Secure the screws
support with Loctite 243 and tighten to 40 Nm.
BRAKE PADS:
The motorcycles are delivered with organic brake pads and have also been
type-coded with these pads. Said pads are suitable for almost the entire
range of application of these motorcycles.It is only for competitive racing in
extremely dirty conditions (e.g., water in combination with sand and mud)
that we recommend brake pads that have sintered linings. However, take
notice of the fact that brake pads with sintered linings have not been type
coded! Besides, they may cause greater wear on the brake discs.
B
RAKE PADS AVAILABLE IN THE ACCESSORY TRADE ARE OFTEN NOT AUTHORIZED FOR
2
OPERATION OF YOUR
AND
SIGNIFICANTLY FROM ORIGINAL
THAN THOSE PROVIDED WITH THE ORIGINAL EQUIPMENT
THAT THEY ARE AUTHORIZED FOR USE IN ROAD TRAFFIC
LONGER COMPLY WITH THE REGULATIONS AUTHORIZING THE USE OF VEHICLES FOR
ROAD TRAFFIC AND THE WARRANTY WILL BE VOID
BRAKE FLUID:
KTM fills the brake systems with „Motorex Brake Fluid DOT 5.1" brake
fluid, one of the best brake fluids that is currently available. We recommend
that you continue to use it. DOT 5.1 brake fluid is based on glycol ether
and of an amber color. If you do not have any DOT 5.1 for refilling, you
may use DOT 4 brake fluid. However, you should replace it as soon as
possible by DOT 5.1.
Never use DOT 5 braking fluid. It is based on silicone oil and has a purple
color. Gaskets and brake hoses are not compatible with it.
H
AVE THE BRAKE FLUID CHANGED AT LEAST ONCE ANNUALLY
MOTORCYCLE OFTEN
B
RAKE FLUID TENDS TO ABSORB WATER
"
OLD
DOT
FAIL
5
BRAKE FLUID RESERVOIRS:
The brake fluid reservoirs on the front and rear wheel brakes have been
designed in such a way that even if the brake pads are worn it is not
necessary to top up the brake fluid. If the brake fluid level drops below the
minimum either the brake system has a leak or the brake pads are
completely worn down. In this case, consult an authorized KTM dealer
immediately.
BRAKE DISCS:
A
Wear reduces the thickness of the brake disc in the area of contact
the brake pads. At its thinnest spot
B
than 0.4mm thinner than its nominal dimension
can be gaged in a location beyond the area of contact with the brake pads.
Check wear in several spots.
– B
4
HAZARD
WEAR LIMIT
– A
BY A LICENSED
1 has 4 brake pistons and is rigidly connected to
WARNING
KTM
MOTORCYCLE IN ROAD TRAFFIC
FRICTION FACTOR AND THEREFORE
KTM
WARNING
,
THE BRAKE FLUID SHOULD BE CHANGED EVEN MORE FREQUENTLY
"
BRAKE FLUIDS EVEN AT LOW TEMPERATURES
.
WARNING
RAKE DISCS SUFFERING FROM WEAR GREATER THAN
. H
AVE THE BRAKE DISC REPLACED IMMEDIATELY AS SOON AS IT REACHES ITS
.
,
S A MATTER OF PRINCIPLE HAVE ANY REPAIR OF THE BRAKE SYSTEM CARRIED OUT
KTM .
MECHANIC
2 optimally rest
3
of the caliper
. T
HE BRAKE PADS DESIGN
THE BRAKING POWER
. I
BRAKE PADS F YOU USE DIFFERENT BRAKE PADS
,
IT CANNOT BE WARRANTED
. Y
OUR MOTORCYCLE WILL NOT
.
. I
F YOU WASH YOUR
. T ,
HEREFORE VAPOR POCKETS MAY FORM IN
,
CAUSING THE BRAKE SYSTEM TO
A
, the brake disc must not be more
B . The nominal dimension
0.4
MM CONSTITUTE A SAFETY
25
CAN DEVIATE
.
4
with