Static Generator Values 250-380 Exc (Kokusan 2K-3) (Except 250 Usa) - KTM EXC Repair Manual

7-7C
STATIC GENERATOR VALUES 250-380 EXC (KOKUSAN 2K-3)
Measuring conditions:
– cold engine
– seat and tank removed
– all connectors and the ground connection in a non-corroding condition, connectors tightly connected
– light switch turned off
– kick the kick starter forcefully at least 5 times for each measurement
7
8
10
Static generator values 250-380 EXC (except 250 USA)
Check the generator output
page) for voltage between the following cable colors:
– between yellow and brown (ground), connector
– between white and brown (ground), connector
– Repeat both measurements with connector
measured values should be the same.
NOTE: the black measuring lead of the peak voltage adapter must be
applied to the ground.
Check regulator rectifier output voltage
opposite page) cable colors yellow/red, regulator rectifier
capacitor bl
– between yellow/red and brown (ground)
NOTE:
– the black measuring lead
S
applied to the ground.
– 300/380 USA corresponds to 300/380 EXC Europe but with less
accessories (blinkers, horn, no capacitor installed). Features no rectifi-
cation, only an over-voltage regulation.
6
(also see circuit diagram on opposite
Multimeter display (250): 19 volts +/- 2 volts
(300-380): 15 volts +/- 1 volt
Multimeter display (250): 24 volts +/- 2 volts
(300-380): 19 volts +/- 1 volt
disconnected:
Multimeter display: 14 volts +/- 1 volt
S
of the peak voltage adapter must be
7 disconnected
8
disconnected
7 8
and connected. The
9
(also see circuit diagram on
bk
connected,