Battery/Charging System Troubleshooting; Battery Is Damaged Or Weak - Honda CBR954RR 2002 Service Manual

TROUBLESHOOTING

BATTERY IS DAMAGED OR WEAK

Remove the battery (page 16-4).
Check the battery condition using the recom-
mended battery tester.
RECOMMENDED BATTERY TESTER:
BM-210-AH or BM-210 (U.S.A. only)
I
I
Correct
Install the battery (page 16-4).
Check the battery current leakage (Leak test;
page 16-6).
SPECIFIED CURRENT LEAKAGE: 0.2 mA max.
Check the alternator charging coil (page 16-7).
-
STANDARD: 0.1 1 .O
Measure and record the battery voltage using a
digital multimeter (page 16-4).
Start the engine.
Measure the charging voltage (page 16-61.
Compare the measurement t o the result of the
following calculation.
STANDARD:
Measured battery voltage
ing voltage < 15.5 V
I
Incorrect
Check the voltage and resistance at the regula-
Fa u Ity reg u'lator/rectifier
Measured charg-
-
Incorrect
Faulty battery
Incorrect
Disconnect the regulatorhectifier connector and
recheck the battery current leakage.
Correct
Incorrect
Faulty charging coil
Correct
Faulty battery
Incorrect
Open circuit in related wires
.
Loose or poor contacts o f related terminal
Shorted wire harness
Incorrect
1 6-3