Dis Engine Harness Checks (Uesc Harness Connector Removed All Sensor Connected To Harness); Codes - Temperature Sensor Characteristics Chart (Tscc) - Ford VSG-411 Service Manual

28-06
lanition Svstem
28-06
0 DIS ENGINE HARNESS CHECKS (UESC HARNESS CONNECTOR REMOVED
ALL SENSORS CONNECTED TO HARNESS)
I
I 1
E8JL-AC, AD
2
to
3
0
ZOO-600
Engine RPM & Crank Position, Wires
264, 265
& V.R. Sensor
/ 2 1 ESJL-CA Same as Test 1
I I
1 3 1 E9JL-CS, CC Same as Test 1
I I
4
E8JL-AC, AD 4to10 f-l 105,000@
QO
Eng. Coolant Temp. Sensor, Wires
354,
354A
and 359.
,
1 5 1 ESJL-CA Same as Test
4
E9JL-CB, CC 4to IO 95,000@
Temp. Sensor, Wires 354
I I
7
E8JL-AC, AD iI
Eng. Spark Adv. Circuit, Wires 6 & 6
No Grounds Equals S/A Set for 87 Oct.
I
8 ) ESJL-CA
I
Same as Test 7
I I
1' 9 1 ESJL-CB, CC
Same as Test
7
I I
I
-With the Ignition Switch " ON" - Wires
Checked 21 A, 16M & 57.
11 ESJL-CA Same as Test IO *AD & CC-Ign. Switch ' " ON" , Wires
12 E9JL-CB' Same as Test IO
Checked 161, 16C, 16M & 57 -
12 VDC lnidcated
13
14
E8JL=AC, AD 11 to 12
n
0.5-I
.o Wires 850 or 850A, 852 or 852A &
Coil Circuit Has Cointinuity.
7
ESJL-CA
Same as Test 13
I 15 I E9JL-CB, CC
r
Same .as Test 13
"I I
16 E8JL-AC
Coil Sec. **Remove the
4
Spark Plug Wires and
I-4**
0 14000 z!z 005 Measure the Sec. Resistance.
17
E9JL-CA Same as Test 16
1 18 1 E9JL-CB
I
Same as Test 16
I I
1 19 1 E8JL-AC ICoil Sec. Z-31 Same as Test 16
I I
/ 20 1 E9JL-CA Same as Test 16
I
I
) 21 1 E9JL-CB I Same as Test 16
I I
H.T. spark plug wire resistance 9,000 to 16,000 ohms - (maximum 30,000 per wire)
CODES - TEMPERATURE SENSOR CHARACTERISTICS CHART (TSCC)
@ Column A converts the sensor only resistance to a temperature reading (page 2B-07)
Column B converts the sensor and harness resistance
to a temperature (page 2B-07)
@ Use column A when the sensor is connected to the harness (page 2B-07) (Harness does not have IOK resistor)
@ Use column B when the sensor is connected to the harness (page 2B-07) (Harness has 1OK resistor)
@ E.C.T.S. brass only in 32°F ice water