APRILIA SXV / RXV 450 550 Use And Maintenance Book page 16

GENERAL INFORMATION
WARNING
Avoid spilling the engine coolant on the exhaust system or on the engine components. They may be
hot enough to cause the coolant to ignite and burn without a visible flame. The coolant (ethylene
glycol) can cause skin irritation and is poisonous if swallowed.
Coolant and coolant/water mixtures are sweet to the taste and brightly colored, therefore are highly
attractive to pets and children. Take extra precautions to keep new and used coolant out of reach of
children and animals.
KEEP COOLANT AWAY FROM CHILDREN.
WARNING
Risk of burns. Do not remove the radiator cap when the engine is hot. Wait until the engine has
completely cooled down. The coolant is under pressure and may splash out and cause burns.
HYDROGEN GAS AND BATTERY ELECTROLYTE
WARNING
The battery gives off noxious and explosive gases; keep cigarettes, flames and sparks away from the
battery.
Provide adequate ventilation when operating or recharging the battery.
During recharging and use, make sure that the room is properly ventilated and avoid inhaling the
gases released during the recharging.
The battery contains sulfuric acid (electrolyte). Contact with the skin or eyes may cause serious
burns. Always wear protective clothing, rubber gloves, and tight fitting goggles or a face shield when
working around the battery, especially when filling the battery with either water or electrolyte.
In case of contact with the skin, flush immediately with plenty of water. In case of contact with the
eyes, flush with plenty of water for at least 15 minutes.
Immediately consult a health professional.
The electrolyte is poisonous.
If the electrolyte is accidentally swallowed, drink large quantities of water or milk and then milk of
magnesia or vegetable oil. Immediately consult a health professional.
KEEP BATTERIES AND ELECTROLYTE
AWAY FROM CHILDREN.
KEEP BATTERIES AND ELECTROLYTE AWAY FROM CHILDREN
GENERAL PRECAUTIONS AND INFORMATION
Follow these instructions closely when repairing, disassembling or reassembling the motorcycle or its components.
DANGER
Using naked flames is strictly forbidden when working on the motorcycle. Before servicing or
inspecting the motorcycle: stop the engine and remove the key from the ignition switch; allow for the
engine and exhaust system to cool down; where possible, lift the motorcycle using adequate
equipment placed on firm and level ground. Be careful of any parts of the engine or exhaust system
which may still be hot to the touch to avoid scalds or burns.
Do not put any vehicle parts into your mouth: vehicle components are not edible and some of them
are harmful or even toxic.
Unless expressly specified otherwise, assemblies are reassembled by reversing the dismantling
procedure. Where a procedure is cross-referred to relevant sections in the manual, proceed sensibly
to avoid disturbing any parts unless strictly necessary. Never attempt to polish matte-finished
surfaces with lapping compounds.
Never use fuel instead of solvent to clean the motorcycle.
Do not clean any rubber or plastic parts or the seat with alcohol, gas or solvents. Clean with water and
neutral detergent.
Always disconnect the battery negative (-) lead before soldering any electrical components.
When two or more persons service the same motorcycle together, special care must be taken to avoid
personal injury.
BEFORE DISASSEMBLING ANY COMPONENTS
•
Clean off all dirt, mud, and dust and clear any foreign objects from the vehicle before disassembling any
components.
•
Use the model-specific special tools where specified.
1 - 10
SXV / RXV 450 – 550