Motor; Controller (Brain Module) System; Stopping In An Emergency - Gio Electric Italia 500W Manual

Never submerse the charger in liquids, or expose them directly to rain.
Note: DO NOT leave the charger plugged and unattended for more than 12 hours. If you smell
burnt or have smoke coming out of the charger – disconnect it right away and contact your
local dealer.

4 Motor:

GIO electric scooter features a high torque, high efficiency, permanent magnet (brushless)
motor.
The motor is maintenance-free, but it is generally advisable to check all other components for
loose or corroded connections on a regular basis, and it is normal for the motor to make some
noise when activated.
Scooters are not designed to be driven in heavy rain or in water deeper than the height of the
motor. This is likely to cause severe damage to components resulting in costly repairs or total
replacement.

5 Controller (brain module) system:

The controller system is comprised of a control module, throttle, and front and rear brake
levers. Their functions are to control the speed of the bicycle by regulating the power going to
the motor, and to protect it against either too much or too little voltage. On some models this
is also augmented by the EABS (Electrically Assisted Braking System) which actually recharges
the batteries under braking.

6 Stopping in an emergency:

Always check front and rear brakes before operating, and never operate an electric scooter
without doing so first. If they are not working and you are not able to remedy this using the
information contained in this book, then please proceed to your local dealer for repairs or
adjustments. Safety is the most important thing, and brake failure is particularly dangerous on
declines or in situations when something pulls or runs out in front of you. If the brakes do fail
while riding, try to slow down before you hit something, seek an alternate escape route.
Remember: It isn't the speed that can hurt, it is the sudden stop! Always assume that
automobiles cannot see you, and never drive dangerously, without a properly fitted and
secured helmet, under the influence, when over-tired, in bad weather, or on unsafe road
conditions.
Page | 8
8
Italia 500w Electric Scooter Owner Manual.indd 8 2/5/2014 10:36:13 PM