Changing The Brake Fluid - Yamaha TW200B Owner's Manual

PERIODIC MAINTENANCE AND ADJUSTMENT
performance.

Clean the filler cap before re-
moving. Use only DOT 4 brake
1 fluid from a sealed container.

Use only the specified brake flu-
id; otherwise, the rubber seals
2
may deteriorate, causing leak-
age.
3

Refill with the same type of
brake fluid. Adding a brake fluid
other than DOT 4 may result in a
4
harmful chemical reaction.

Be careful that water does not
5
enter the brake fluid reservoir
when refilling. Water will signifi-
6
cantly lower the boiling point of
the fluid and may result in vapor
lock.
7
NOTICE
8
Brake fluid may damage painted sur-
faces or plastic parts. Always clean
9
up spilled fluid immediately.
As the brake pads wear, it is normal for
the brake fluid level to gradually go
down. A low brake fluid level may indi-
cate worn brake pads and/or brake sys-
tem leakage; therefore, be sure to
check the brake pads for wear and the
brake system for leakage. If the brake
fluid level goes down suddenly, have a
Yamaha dealer check the cause before
further riding.
ECA17640
7-25

Changing the brake fluid

Have a Yamaha dealer change the
brake fluid at the intervals specified in
the TIP after the periodic maintenance
and lubrication chart. In addition, have
the oil seals of the brake master cylin-
der and caliper as well as the brake
hose replaced at the intervals listed be-
low or whenever they are damaged or
leaking.

Oil seals: Replace every two
years.

Brake hose: Replace every four
years.
EAU22721