Download Print this page

FireMagic Aurora A430i Installation Instructions And Owner's Manual

Built-in outdoor gas grills
Hide thumbs

Advertisement

BUILT-IN OUTDOOR GAS GRILLS
A430i, A530i, A540i, A660i & A790i
INSTALLATION
INSTRUCTIONS AND
OWNER'S MANUAL
INSTALLER:
Leave these instructions with consumer.
CONSUMER:
Retain for future reference.
IMPORTANT:
READ THESE INSTRUCTIONS CAREFULLY BEFORE STARTING INSTALLATION OR USE.
DANGER:
IF YOU SMELL GAS
1. Shut off the gas to the appliance.
2. Extinguish any open fl ame.
3. Open lid.
4. If odor continues, keep away from the
appliance and immediately call your
gas supplier or the fi re department.
CODE AND SUPPLY REQUIREMENTS: This grill
must be installed in accordance with local codes
and ordinances, or, in the absence of local codes,
with the latest National Fuel Gas Code (ANSI
Z223.1/NFPA 54), or Natural Gas and Propane
Storage and Handling Installation Code (CSA-
B149.1).
This appliance and its dedicated manual shutoff
valve must be disconnected from the gas-supply
piping system when testing the system at pressures
in excess of ½ psig (3.5 kPa).
This appliance must be isolated from the gas-
supply piping system by closing its dedicated
manual shutoff valve during any pressure testing
of the gas-supply system at pressures up to and
including ½ psig (3.5 kPa).
254-G-19-5
Robert H. Peterson Co. • 14724 East Proctor Avenue • City of Industry, CA 91746
REV 4 - 1011240804
WARNINGS AND SAFETY CODES
:
A790i shown
WARNING:
1. Do not store or use gasoline or other
fl ammable vapors and liquids in the
vicinity of this or any other appliance.
2. An LP cylinder not connected for use
shall not be stored in the vicinity of this
or any other appliance.
WARNING:
Improper installation, adjustment, alteration,
service, or maintenance can cause injury
or property damage. For proper installation,
refer to the installation instructions. For
assistance or additional information,
consult a qualifi ed professional installer,
service agency, or the gas supplier.
Certifi ed to:
All electrical outlets in the vicinity of the grill must
be properly grounded in accordance with local
codes, or, in the absence of local codes, with the
National Electrical Code, ANSI/NFPA 70, or the
Canadian Electrical Code, CSA C22.1, whichever
is applicable.
Keep all electrical-supply cords and fuel-supply
hoses away from any heated surface.
1
ANSI Z21.58a-2008
CSA 1.6a-2008
L-C2-276

Advertisement

loading

  Related Manuals for FireMagic Aurora A430i

  Summary of Contents for FireMagic Aurora A430i

  • Page 1 BUILT-IN OUTDOOR GAS GRILLS A430i, A530i, A540i, A660i & A790i INSTALLATION INSTRUCTIONS AND OWNER’S MANUAL INSTALLER: Leave these instructions with consumer. A790i shown CONSUMER: Retain for future reference. IMPORTANT: READ THESE INSTRUCTIONS CAREFULLY BEFORE STARTING INSTALLATION OR USE. WARNINGS AND SAFETY CODES...
  • Page 2 INSTALLATION INSTRUCTIONS ET MANUEL DU PROPRIÉTAIRE GRIL EXTÉRIEUR DE GAZ DU BUILT-IN IMPORTANT: LISEZ CES INSTRUCTIONS SOIGNEUSEMENT AVANT DE COMMENCER L’INSTALLATION OU L’UTILISATION SÛRETÉ ET CODES D’AVERTISSEMENT DANGER: AVERTISSEMENT: 1. Ne stockez pas ou n’employez pas SI VOUS SENTEZ LE GAZ l’essence ou d’autres vapeurs et liquides 1.
  • Page 3: Table Of Contents

    CONTENTS 4 REPLACEMENT PARTS LIST 6 MODEL SPECIFICATIONS 6 GRILL MAINTENANCE AND SAFETY INFORMATION 7 INSTALLATION REQUIREMENTS 8 INSTALLING THE BUILT-IN UNIT 9 SAFE USE & MAINTENANCE OF PROPANE GAS CYLINDERS 13 LIGHTING (IGNITION) INSTRUCTIONS 14 AURORA DIGITAL THERMOMETER 15 OPTIONAL ROTISSERIE 16 OPTIONAL INFRARED BURNER OPERATION 17 GRILLING TIPS 18 ACCESSORIES...
  • Page 4: Replacement Parts List

    REPLACEMENT PARTS LIST To order replacement par ts, contact your ® l o c a l F i r e M a g i c dealer. L-C2-276 REV 4 - 1011240804...
  • Page 5: If Equipped

    3001-59-1 3001-57-1 3001-57-1 3001-56-1 Fire Magic ® cookbook‡ 3595 3595 3595 3595 3595 Thermometer wire harness‡ 24177-25 24177-25 24177-25 24177-25 24177-25 * If equipped † Not available on A430i or A530i models ‡ Not shown L-C2-276 REV 4 - 1011240804...
  • Page 6: Model Specifications

    MODEL SPECIFICATIONS ® Fire-Magic Model Specifi cations Table Table 1 A430i A530i A540i A660i A790i Countertop to unit bottom (cut-out)* 12" 12" 12" 12" 12" 25- 1 / 2 " 25- 1 / 2 " 37- 3 / 4 "...
  • Page 7: Installation Requirements

    INSTALLATION REQUIREMENTS This grill is designed for outdoor use only. DO NOT use this grill under unprotected fl ammable surfaces. DO NOT use this grill inside a building, garage, enclosed area, or an unprotected covered area (see EXHAUST REMOVAL below). DO NOT use this grill in or on a recreational vehicle or boat. Important: The grill must have a minimum of 18"...
  • Page 8: Installing The Built-In Unit

    INSTALLING THE BUILT-IN UNIT COUNTER PREPARATION CONNECTING THE GAS SUPPLY Consult Table 1 for non-combustible enclosure cut- CAUTION: Use only C.S.A. listed stainless-steel out dimensions. A Robert H. Peterson insulating fl ex connectors within the enclosure. liner must be used if the counter or any supporting WARNING construction is combustible.
  • Page 9: Safe Use & Maintenance Of Propane Gas Cylinders

    SAFE USE & MAINTENANCE OF PROPANE GAS CYLINDERS IMPORTANT FOR YOUR SAFETY READ AND FOLLOW ALL WARNINGS PROVIDED WITH THE PROPANE-GAS CYLINDER. When operating this appliance with a propane-gas cylinder, these instructions and warnings MUST be observed. FAILURE TO DO SO MAY RESULT IN A SERIOUS FIRE OR EXPLOSION. The use of pliers or a wrench should not be necessary.
  • Page 10 UTILISATION SÛRE ET ENTRETIEN DES CYLINDRES DE GAZ IMPORTANT POUR VOTRE SÛRETÉ LISEZ ET SUIVEZ TOUS LES AVERTISSEMENTS ÉQUIPÉS DE VOTRE CYLINDRE DE GAZ DE PROPANE. En actionnant cet appareil avec un cylindre de gaz de propane ON DOIT observer ces instructions et avertissements. LE MANQUE DE FAIRE AINSI PEUT AVOIR COMME CONSÉQUENCE UNE INCENDIE OU UNE EXPLOSION SÉRIEUSE.
  • Page 11: If Equipped

    Digital Drip Thermometer Fig. 11-1 Tray A430i and A530i controls To remove the control panel: • Turn off the gas shutoff valve. • Pull off the control knobs. Unscrew and remove the control panel screws and washers. • Lift the control panel up and outward, allowing it to rest on the internal chain(s).
  • Page 12 ALLUMAGE DES INSTRUCTIONS (D’ALLUMAGE) Lisez toutes les instructions avant l’allumage, et suivez ces instructions chaque fois vous lumière le unité. ÉCLAIRAGE ÉLECTRONIQUE ÉCLAIRAGE MANUEL Note: L’éclairage électronique exige une batterie installée ATTENTION: Attendez toujours cinq (5) minutes le gaz de 9 volts avec une bonne charge. pour se dégager après que n’importe quelle 1.
  • Page 13: Lighting (Ignition) Instructions

    LIGHTING (IGNITION) INSTRUCTIONS Read all instructions before lighting, and follow these instructions each time you light the unit. ELECTRONIC LIGHTING MANUAL LIGHTING Note: Electronic lighting requires an installed 9-volt CAUTION: Always wait fi ve (5) minutes for gas to battery with a good charge. clear after any unsuccessful lighting attempt.
  • Page 14: Aurora Digital Thermometer

    AURORA DIGITAL THERMOMETER Your Aurora outdoor gas grill comes with a digital Fig. 14-1 thermometer, which includes a built-in timer and alarms. The thermometer is located on the control panel between the knobs. Plug in meat probe as shown in Fig. 14-3. Thermometer battery access drawer (Fig 14-4).
  • Page 15: Optional Rotisserie

    OPTIONAL ROTISSERIE CAUTION: WHEN USING THE BACKBURNER; KEEP Backburner cover Rotisserie THE OVEN LID CLOSED TO PREVENT HEAT rod bracket Warming rack LOSS, PROVIDE PROPER CONVECTION, AND PROVIDE PROPER VENTING. THIS WILL Rotisserie rod rear bracket ENSURE EVEN COOKING TEMPERATURES. Rotisserie DO NOT KEEP YOUR OVEN LID OPEN DURING motor...
  • Page 16: Optional Infrared Burner Operation

    OPTIONAL INFRARED BURNER OPERATION The Fire Magic ® infrared (IR) searing burner (optional) WARNING cooks with a powerful radiant heat. Only handle the infrared burner cover when the grill is cold or with a well-insulated long-handled tool or heat resistant gloves. Cover SIDE VIEW (with cover on) Cut-out for...
  • Page 17: Grilling Tips

    GRILLING TIPS The art of grilling involves learning the nuances of your WIND CONSIDERATIONS grill and knowing how various cuts of meat and other Wind direction can have an effect on the grill, foods cook on it under different settings and conditions. especially with the oven open.
  • Page 18: Accessories

    ACCESSORIES THE WARMING RACK (if equipped) THE GRILL BRUSH (OPTIONAL) The warming rack (Fig. 18-2) is packed separately. ® Purchase a Fire Magic stainless-steel grill brush (sold separately) to keep your grill cleaner. It comes with To install the warming rack, lift the front of the rack scraper for large particles and a replaceable head with up slightly and insert the rack hangers into the two brass bristles for overall cleaning.
  • Page 19: Fire Magic ® Drip Tray

    FIRE MAGIC DRIP TRAY ® Drippings from grilling flow through specially designed channels and collect in the drip tray. Check the drip tray regularly and empty when required. Fig. 19-1 Fig. 19-2 Pull out the drip tray and place liner ®...
  • Page 20: Care & Cleaning

    CARE & CLEANING CARE AND CLEANING APPLIANCE MUST BE COMPLETELY COOL WHEN CLEANING. DO NOT SPRAY ANY CLEANER OR LIQUIDS ON THE APPLIANCE WHEN HOT. Stainless steel surfaces when exposed to temperatures produced by the grilling process will change color. The stainless steel will change color from silver to brown and blue.
  • Page 21: Troubleshooting

    TROUBLESHOOTING If you have trouble with this Fire Magic grill, please use this list to identify the problem. By trying one or more of the ® solutions to the possible cause, you should be able to solve the problem. If this list does not cover your present problem, or if you have other technical diffi...
  • Page 22: Converting The Gas Type

    CONVERTING THE GAS TYPE REGULATOR CONVERSION Required tools: • Phillips-head screwdriver (#2 medium) The gas regulator, located behind the control panel, must • Needle-nose pliers be set for the type of gas used to fuel the grill. To check • "...
  • Page 23: If Equipped

    CONVERTING THE GAS TYPE 4. Remove the back panel by pulling the bottom toward the front of the grill and rotating it upward and outward until the two top tabs attached to back wall of the oven can be removed from the slots in the top of the plate.
  • Page 24: Burner Air Shutter Adjustment

    BURNER AIR SHUTTER ADJUSTMENT AIR SHUTTER ADJUSTMENT 1. Follow the safety precautions and steps for main burner removal Important: Air shutters are preset at the Fig. 24-2 in the CHANGING factory based on the gas the grill is Adjustment THE MAIN BURNER built to burn.
  • Page 25: If Equipped

    BURNER AIR SHUTTER ADJUSTMENT (Continued) BACKBURNER (IF EQUIPPED) Too large an air shutter opening will allow too much air into the burner, which will cause the fl ames fi rst The air shutter is set at the factory. However, to shorten and then to appear to lift up off the ports. altitude or other local conditions may require air For the bottom of the fl...
  • Page 26: Warranty

    WARRANTY ® LIFETIME WARRANTY - Fire Magic cast stainless-steel burners, stainless-steel rod cooking grids, and stainless-steel housings are ® warranted for as long as you own your Fire Magic grill. ® FIFTEEN-YEAR WARRANTY - Fire Magic cast brass burners, brass valves, backburner assemblies (except ignition parts), and ®...