Changing The Basic Position Of The Foot Brake Pedal; Check The Rear Brake Fluid Level; Refilling The Rear Brake Fluid Reservoir - HUSABERG "05 Owner's Manual

MAINTENANCE WORK ON CHASSIS AND ENGINE
CHANGING THE BASIC POSITION OF THE FOOT
BRAKE PEDAL *
The basic position of the foot brake pedal can be altered by turning the
stop screw (1). The free play at the foot brake pedal must then be adjus-
ted by means of the piston rod (2).
Measured on the outside, the foot brake pedal must have 3-5 mm (0.12–
0.20 in) of free play before the piston rod can move the piston in the brake
cylinder (to be recognised from the resistance on the foot brake pedal).
CAUTION: If this free play is not present, then pressure can
build up in the brake system when driving, causing the rear
wheel to brake.The braking system overheats and may even
fail completely in extreme cases.

CHECK THE REAR BRAKE FLUID LEVEL

The reservoir for the rear disc brake is located above the main brake cylin-
der. The level of brake fluid may not fall below the „MIN" mark when the
vehicle has been left standing upright.
WARNING: If the brake fluid level drops below the minimum
either the brake system has a leak or the brake pads are com-
pletely worn. In this case, consult an authorized Husaberg
dealer immediately.

REFILLING THE REAR BRAKE FLUID RESERVOIR *

When the brake fluid level has dropped to the MIN mark, you need to refill
the brake fluid reservoir.
For easier access to the brake fluid reservoir it is recommended to remove
the hexagon screw. Then move the container outwards as indicated in
the illustration. Remove plug (3) with rubber boot (4) and add brake fluid
DOT 5.1 (Motorex Brake Fluid DOT 5.1) up to the „MAX" mark. Replace
rubber boot and plug. Overflown or spilled brake liquid must be rinsed off
with water. Mount the screw and fix the brake fluid reservoir to the frame,
always making sure to prevent kinks in the connecting hose.
WARNING: Never use DOT5 brake fluid! It is based on silicone
oil and of a purple color. Seals and brake hoses must be
especially adapted to it.
Store brake fluid out of reach of children.
Brake fluid can cause skin irritation. Avoid contact with skin
and eyes. If you get brake fluid in your eyes, rinse with plenty
of water and consult a doctor.
CAUTION: Don't let brake fluid get in contact with paint, it
is an effective paint remover.
Use only clean brake fluid taken from a tightly sealed
container!
2
- 40 -
1
3-5mm
3
4