Volvo Neutra-Salt System - Regal 2200 Owner's Manual

CHAPTER 6

Volvo Neutra-Salt System

Neutra-Salt Engine Flushing System is available as a Volvo option
on gasoline engines only. Its purpose is to flush salt deposits that
develop in the engine's cooling system. It is intended for engines that
operate in brackish or salt water areas only. The system is not intended
for fresh water use.
CAUTION
!
THE NEUTRA-SALT SOLUTION WILL FREEZE. IF
FREEZING CONDITIONS ARE POSSIBLE, DRAIN
THE ENTIRE SYSTEM.
The Neutra-Salt solution leaves a corrosion inhibiting coating on all
metal engine parts. The solution travels through the engine via a
solenoid (after a rocker switch is activated) and a set of connecting
hoses. The manufacturer recommends using the system at the end of
the boating outing. Extra solution (Volvo # 41103103 available in
quarts and gallons)should be available from your Regal dealer.
FILL & TEST SYSTEM
1. Pour the quart bottle of Neutra-Salt concentrate into the reservior.
Wear protective eye-wear & gloves since the concentrate may cause
an eye irritation. In case of contact, flush eyes throughly with water
for 15 minutes.
2. Mark the fluid level on the reservoir. To prevent hearing loss, avoid
prolonged exposure to the audible alarm on the engine, particularly
in confined spaces. The alarm can reach 120 decibles.
3. Re-connect the power supply.
4. Connect water supply (flushette) so that the engine can be run.
5. Start the engine. Run at idle.
6-46