Advertisement
The LP gas tank mustbe constructed a ndmarked
in accordance w ith specifications of the U.S.Dept.
of Transportation (DOT).In Canada, t he LP gastank
mustmeetthe Canadian Transportation andCommu-
nications (CTC)specifications. Alsobe sureto read
andfollowall LP instructions b elow.
1. The LP gastank has a shutoffvalve,termi-
natingin an LP gassupplytank valve outlet,
that is compatible with a Type 1 tank con-
nectiondevice.The LP gas tank mustalso
havea safetyreliefdevicethat hasa direct
connection with the vaporspaceof the tank.
2. The tank supplysystemmustbe arranged
forvaporwithdrawal.
3. The LP gas tank usedmusthavea collar
to protectthe tankvalve.
Proper
Placement
and Clearance
of Grill
Never use your charcoal/gas grill in a garage, porch,
shed, breezeway or any other enclosed area. Your
charcoal/gas grill is to be used outdoors
only, at least
24 inchesfrom
the back and side of any combus-
tible surface. Your charcoal/gasgrill
should not be
placed under any surface that will burn. Do not
obstruct the flow of ventilation
air around the char-
coal/gas grill housing.
This outdoor charcoal/gas grill is not intended to be
installed in or on recreational vehicles and/or boats.
•
Never connect an unregulated
LP gas tank to
your gas grill. The gas regulator assembly
supplied with your gas grill is adjusted to have
an outlet pressure of 11" water column (W.C.)
for connection
to an LP gas tank.
•
Only use the regulator
and hose assembly
supplied with your gas grill. Replacement
regulators
and hose assemblies
must be those
specified
by Sears.
•
Have your LP gas tank filled by a reputable
propane gas dealer and visually
inspected and
re-qualified
at each filling.
•
Never fill the gas tank beyond 80% full.
Have your propane gas dealer check the
release valve after every filling to ensure that it
remains free of defects.
•
Always keep LP gas tanks in an upright
position.
•
Donotstore(oruse)gasotineorother
flammable
vapors and liquids in the vicinity of this gas grill.
•
An LP gas tank that is not connected for use must
NOT be stored on bottom shelf or in the vicinity of
this or any other gas grill.
•
Do not subject the LP gas tank to excessive heat.
•
Never store an LP gas tank indoors. If you
store your gas grill in the garage or other indoor
location, always
disconnect the LP gas tank
first and store it safely outside.
• LP gas tanks must be stored outdoors in a
well-ventilated
area and out of the reach of
children.
Disconnected
LP gas tanks must not
be stored in a building,
garage or any other
enclosed area.
• When
your gas grill is not in use the gas
must be turned off at the LP gas tank.
• The regulator
and hose assembly can be seen
after opening the doors (if applicable),
and
must be inspected before each use of the
grill. If there is excessive
abrasion or wear or
if the hose is cut, it must be replaced prior
to the grill being used again.
• Keep the gas regulator
hose away from hot
grill surfaces and dripping grease. Avoid
unnecessary
twisting of hose. Visually
inspect
hose prior to each use for cuts, cracks,
excessive
wear or other damage.
If the hose
appears damaged
do not use the gas grill.
Call Sears at 1-800-4-MY-HOME®(1-800-469
-
4663) for a Sears authorized
replacement
hose.
• Never light your gas grill with the lid closed
or before checking
to insure the burner tubes
are fully seated over the gas valve orifices.
• Never allow children to operate your grill. Do
not allow children
to play near your grill.
Z WARNING
If you smell gas:
Shut off gas supply to the gas grill.
Turn the Control Knobs to OFF position.
Extinguish any open flame such as candle,
cigarette, lighter, etc., that could cause gas
to ignite.
Open Grill Lid.
Get away from the LP gas tank.
Do not try to fix the problem yourself.
If odor continues or you have a fire you cannot
extinguish, call your firedepartment.
Do not call
near the LP gas tank because your telephone is
an electrical device and could create a spark
resulting in fire and/or explosion.
NOTE: The normal flow of gas through the
Regulator and Hose Assembly
can create a
humming
sound. A low volume of sound is
perfectly normal and will not interfere with
operation
of the grill. If humming sound is
loud and excessive
you may need to purge
air from the gas line or reset the Regulator
excess gas flow device. This purging proce-
dure should be done every time a new LP
gas tank is connected
to your grill. For help
call the Grill Information
Center.
3
Advertisement
