Kohler 12RES Operation And Installation Instructions Manual page 22

System Component or Procedure
Fuel
Flexible lines and connections
Main tank supply level
Fuel piping
Lubrication
Oil level
Crankcase breather*
Change oil
Replace filter*
Cooling
Air ducts, louvers
Exhaust Line
Leakage
Insulation, fire hazards
Hangers and supports
DO Electrical System
See
Section
3.3
3.6
3.7
3.8
Visually
Inspect
X
X
X
X
X
X
X
Procedure
Check Change
R
X
X
X
X
Clean
X
Test
Battery charger operation, charge rate (if equipped)
Remove corrosion, clean and dry battery and rack
Clean and tighten battery terminals
Battery electrolyte level and specific gravity-;
AC Electrical System
Visible wear or damage
Wire abrasions where subject to motion
Tighten control and power wiring connections
Wire-cable insulation breakdown *
Engine and Mounting
Visible wear or damage
Air cleaner service
Spark plugs
Replace stepper motor coupling and bushing *
Compartment condition
Remote Control System
Remote control
Run generator set
Generator
Visible wear or damage
Exercise generator set
Rotor and stator *
Measure and record resistance readings of
windings with insulation tester (Megger, with
SCR assembly or rectifier disconnected)
General Condition of Equipment
Evidence of vibration, leakage, excessive noise,
temperature, or deterioration
Interior of sound enclosure
• Contact your local distributor/dealer for parts or service,
Not necessary for maintenance-free batteries,
X
X
X X
X
X
X
X
X
3.5
3.4
X
2.1 X
2.2
X
R
X
X
X X
X
X Action
R Replace as necessary
X
X
X
X
X
Figure 3-1 Service Schedule
Frequency
Quarterly
Weekly
Yearly
8 hours or
before use
Yearly or 500 hours
Yearly or 100 hours
Yearly or 200 hours
Yearly
Weekly
Yearly
Yearly
Monthly
Yearly
Yearly
Yearly
Quarterly
Six Months
Yearly
3 Years or 500 hours
Weekly
Yearly or 100 hours
Yearly or 300 hours
500 hours
Weekly
X Monthly
X Weekly
Quarterly
X Weekly
Yearly
X 3 Years
Weekly
Quarterly
10 Section 3 Scheduled Maintenance TP-6195 1/04