Download Print this page

Advertisement

H
MODEL
NO
298.586191
O owner's
:_responsibility
• _ maintenance
el operation
shooting L
Publication
No.
96745_0:205
'

Advertisement

   Summary of Contents for CRAFTSMAN 298.586191

  • Page 1

    • MODEL 298.586191 O owner's :_responsibility • _ maintenance el operation shooting L Publication 96745_0:205...

  • Page 2: Table Of Contents

    TABLE OF CONTENTS Page N o. SPECIFICATIONS ..OWNER'S RESPONSIBILITY ........MAINTENANCE .........: ..LUBRICATION GEAR HOUSING ......4 MUFFLER INSPECTION ..• ..PROLONGED STORAGE ........OPERATIONS _ ........NEW AUTOMATIC CLUTCH ........BOAT MOUNTING ........

  • Page 3: Owner'sresponsibility

    IMPORTANT Owner's Responsibility and Operating Safety Check List BE SURE TO READ AND DO TH_:FOLLOW}N_ _rORE OPERATING YOUR OUTBOARD MOTOR SAFETY CHECK LIST Learn and observe the boating laws of the U.S. Coast: Guard. state, I_aJ author- ities U.S. Coast Guard regulations require=the...

  • Page 4

    MAJOR PARTS Starlet Handle -Choke Lever Power Head Spark Plug Sl0p Bull0n ..Sleeting Handle FuelShuFoUValve Fuel Sedimenl B 0wl Twist: Grip and Filter Dual Aulomalic Clulch Housing ClampStud Handles ReverseDriving LOCkL _ TransomBracket Tilt Pin Adjuslmenl- Drive Shall Pipe MulflerPipe..

  • Page 5: Maintenance

    MAINTENANCE outboard motor should LUBRICATION--GEAR HOUSING mounted stand vertically with Gear Housing has been pre.lubricated power head up for storage. the factory; however, the grease level should Pull starter handle slowly until resist. checked as follows using SAE out- ance is felt to compression pres.

  • Page 6: Boat Mounting

    OPERATION 6. BOAT MOUNTING ,J= Mount the motor on the center at the bool transom (sternl. {See Figure4). CAUTION Hand tighten transom bracket and clamp stud handles simultaneously. not use a- wrench Or any other device that would cause damage to brackets.

  • Page 7: 2-cycle Engine Fuel Mixture

    OPERATIOX 2-CYCLE ENGINE FUEL MIXTURE Use agood grade of regular gasoline. (See mix- _ in9 table below,) CAUTION Always use BIA certified TC-W oil in the 50:1 ratio. Failure to d0to result ih excessive spark plug fouling, piston scoring, or bearing failure.

  • Page 8: Flooding

    OPERATION L WARN|NG • In case of an Emergency, the engine be stopped by moving the Choke Lever to FUll Choke Position. motor will be opelatedif0r_-_ period of time; if it is to be removed from the boat, or if it is to be tilted:up, recommend following...

  • Page 9: Ignition System

    OPERATION FLYWHEEL MAGNETO IGNITION SYSTEM WITH TRANSISTERIZED ELECTRONIC IGNITOR The magneto ignition system consists of the following component parts! Flywheel, Tran- sisterized Electronic Ignitor and ignition Coil. Inmect the following engine fails or is herd to start: _-{1) Spark plug as often as necef4ary.

  • Page 10: Trouble Shooting Check List

    TFIOUBLESHOOTING CHECK LIST *Take you_ outboard motor into =_ny one of over 2000 Sears Sq=viee Units. "l'a=t k Empty Fuel ..Shut,OH Valve Closed Fuel Line Kinked o( Pinched ..:uu,,_ i .... Fuel Filler Dirty or Clogged " Vent Screw on Fuel Tank...

  • Page 11: Replacement Parts

    REPLACEMENT ,PARTS MODEL No.298.586191...

  • Page 12

    FIG'1 ENGINE...

  • Page 13

    FIGol ENGINE REF.No. PARTS NAME P.P,No. O'ly o_e+_o2ol.zou :YLIHD[I SHIOHD ;sT.o4ooo+goo ;PALE PLUG ASS'Y 018-00540-200 SPAI[ PLU_-BHESA 002-10200-803 _YLIEOEE COEP, • 017-10200-202 :+[IMDEI Gks£ET 040-10100+ZOO p:ISTON ||KG++ ..041-10|00-201 PI$TOH+:_II_G 03_-02000-20! _ISTOXPIX CI|CLIP PISTOH_+ 031-10100-210 Q_t-_OIQO-200 PISTON 1¢I35" C[ANI+$HAFrT_OMP. 048-I0242-800 HOOD+IUPF £EY 3Xi+X$.

  • Page 14

    IG.2 TANK, CLUTCH & MUFFLER fIG,3 P_._._...

  • Page 15

    /:// ¸¸7¸::¸ : • FIG.2 TANK, CLUTCH & MUFFLER PARTS NAME )'ly TANK ASS+Y TAXi GASIET. ENGINE COVER (SEALS) CUSHION HUiBEI COLLAI STANTEI PAUL EASE STAZTEI PAVL SPNIHG STAITEl PAUL STEPBOLT FUEL TAXI FUEL TAME BAND COMP. FUEL TAN[ DBACXET CONP+ FUEL TAXI...

  • Page 16: Starter

    JG,3 RECOIL STARTER - ..REF.No. P.P.No, PARTS NAME Q'ty 13-000 7S_-I0207-g00 EECOIL STARTEI ASS'Y _00| 772-10207-200 RECOIL STAR?El BOOY -002 774-10200-200 STARTER ROPE REEL ..-003 770-10200-203 EECOIL SP|IflG :OOg T83-01006-20| sTAITI! tOPE 780-10201-200 LOPE GOIDE -011 -012 785-10207-20! STAETER HAROLE :013 833-10207-200...

  • Page 17

    FIG.4 CARBURETOR © {_ ....-" 31 -- _'_ P.P;No. REF.No. PARTS NAME_ :i' O'ly CAteU_TO_IXSS'Y ..-o02 597-zolzo-2oo CABLE ADJUSTER 4-003 595-20200-200 EODY 4-004 594-20202"200 TltEOTTLE VALVE SP_iMG THEOTTLE SEAT " SPE|EG 1-005 _19-20Z02-200 4-000 593-20202_200 !JET WEEOLE CLIP 1-007 592-2002T'920...

  • Page 18

    FIG:5 HANDLE & BRACKET...

  • Page 19

    FIG.5 HANDLE & BR'ACKET REF.No. P.P, No. PARTS NAME O'ty 5.000 a70-35552-000 TVIS] GK|P kSS'Y 5-001 aSS-O;OSS-ao0 t|II0TTLE VI_E COHP, S'00S 200"35300-100 CLUTC8 OlUN C0HP. 5"OOa 003-51042-00Z IIRG _TOP 5-007 000-8|800-404 EALL BEAE]EG sO004DD 5-OOa 003-50020-002 STOP IIHG 5-000 185"35300-203 CLUTCH CASE S'O|O...

  • Page 20

    FIG'6 DRIVE SHAFT PIPE,& GEAR ICASE --13...

  • Page 21

    FIG,6 DRIVE SHAFT PIPE& GEAR CASE REFoNo. PARTS NAME O'ty P.P.N0. ogo+35joo-uoo :8-001 DZI¥E.SIIAFT PIPE ASS'Y " 0+002 075-35300"800 9RIVE':-SHAFT CONP, 8-003 086-35500-200 BEAEIHQ HOLDEi CLiP 0 +004 gOD-O210_-SZI NEEDLE 8EA_]HG tOJ5 +OOS 03_-3S50o-200 DEALING NOLDEE 1_-008 091+35500-200 OLIVE SHAFT PIP+ GASKET O +007...

  • Page 22

    FIG.7 TOOLS ii!i ..PARTS ..NAME ..io',y REENo, P.P.No. g_5-3S3O4-QO0 TOOL 7-000 1-001 851-20oo0-201 SPAK[ PLUG BOX SPANHE_ 7-002 i808-2oo00-2oo SPANNER I0X13" ? -003 882-20000-200 PLUS 9rIVER ?-Q04 948-32352-_00 TOOL...

  • Page 23

    MODEL 298.586191 For quick service or repair, take your Outboard Motor to any Sears Service Unit throughout FULL ONEYEARWARRANTYON U.S. and Canada Each Service Unit is staffed OUTBOARDMOTOR trained technicians, using Sears approved For One year from the first day of use of parts and repair procedures...

Comments to this Manuals

Symbols: 0
Latest comments: