Download Print this page

Advertisement

SEARS
operator's
manual
MODEL NO. 143.004010
4.0 HORSEPOWER
10 CUBIC INCH (163 cc)
DISPLACEMENT
SOLID STATE IGNITION
CAUTION:
Read RULES for
Safe OPERATION
and INSTRUCTIONS
Carefully
ENGIN
• Operating
• Maintenance
• Repair Parts
_
alifornia
Proposition
65
WARNING:
The engine exhaust from this product contains
chemicals
known to the State of California
to cause cancer, birth defects or other reproductive
harm.
Sold by SEARS, ROEBUCK
AND CO., CHICAGO,
IL 60684 U.S.A.
and SEARS CANADA,
INC., TORONTO,
ONTARIO,
CANADA
Printed i nU.S.A.
4-1-00 181-1224-11

Advertisement

   Summary of Contents for CRAFTSMAN 143.004010

  • Page 1

    SEARS operator's manual MODEL NO. 143.004010 4.0 HORSEPOWER 10 CUBIC INCH (163 cc) DISPLACEMENT SOLID STATE IGNITION ENGIN CAUTION: • Operating Read RULES for Safe OPERATION • Maintenance and INSTRUCTIONS Carefully • Repair Parts WARNING: alifornia Proposition The engine exhaust from this product contains chemicals known to the State of California to cause cancer, birth defects or other reproductive...

  • Page 2

    OIL FILL PLUG AND DIPSTICK STARTER RECOIL MODEL AND D.O.M. DECAL COOLING FINS OIL DRAIN PLUG SPARK PLUG WIRE CLEANEF CONTROL LEVER BOTTOM OF ENGINE CARBUERTOR SPARK PLUG _MUFFLER Figure 1 THIS SYMBOL POINTS OUT IMPORTANT SAFETY INSTRUCTIONS WHICH IF NOT FOLLOWED COULD ENDANGER THE PERSONAL SAFETY ANDIOR PROPERTY OF YOURSELF AND OTHERS.

  • Page 3

    BEFORE STARTING (Continued) BEFORE STARTING (Continued) Slide rope stop onto starter rope and feed starter rope FILL FUEL TANK with gasoline as specified in the preceding through rope guide on mower handte (see Figure 4). "OIL & FUEL RECOMMENDATIONS," item 2. Feed starter rope through starter handle (see Figure 5) and NEVER MIX OIL WITH GASOLINE tie a left hand knot, leaving 1/2 inch to 1 inch of starter rope...

  • Page 4

    STARTING MAINTENANCE NEVER RUN ENGINE INDOORS OR IN ENCLOSED, POORLY] WARNING -- TEMPERATURE OF MUFFLER AND NEARBY AREAS MAY EXCEED 150°F (65°C). AVOID THESE AREAS. CONTAINS / VENTILATED AREAS. ENGINE EXHAUST GAS/ CARBON MONOXIDE, AN ODORLESS AND DEADLY (CARBON MONOXIDE IS ALSO PRESENT IN ENGINE_...

  • Page 5

    SEARS, ROEBUCK AND CO. (OR SEARS Just as your automobile needs professional mechanical maintenance CANADA, INC.) SERVICE CENTER. from time to time, so does your Craftsman engine. Replacement of the spark plug and air cleaner is made necessary by NORMAL use. (_) ENGINE SPEED Professional Air-Cooled Engine Service is as close as your nearest Sears Roebuck and Co.

  • Page 6

    TROUBLESHOOTING THE FOLLOWING MAY HELP AVOID A DELAY IN YOUR WORK OR SAVE THE EXPENSE OF A SERVICE CALL. ENGINE FALLS TO START OR STARTS WITH DIFFICULTY CAUSE REMEDY Controls not in start position. Move ENGINE CONTROL or equipment control to "HI" or START postion.

  • Page 7

    SEARS, ROEBUCK AND CO. Federal and California Emission Control Systems Limited Warranty Small Off-Road Engines CALIFORNIA & US EPA EMISSION CONTROL B. GENERAL EMISSIONS WARRANTY COVERAGE: Sears, Roebuck and Co. WARRANTY STATEMENT warrants to the original, end-use purchaser of the new engine or equipment and to each subsequent purchaser that each of its small off-road engines is:...

  • Page 8

    CRAFTSMAN 4-CYCLE ENGINE MODEL:143.004010 _--370K /287 370C 262/_ _'292 _/g2 _285 _292 275A "284 284A 370B_.,_ 209_ I 200 215_ 185// Page 7 181-1224-11...

  • Page 9

    CRAFTSMAN 4-CYCLE ENGINE MODEL:143.004010 Part Ref. Ref. Part Part Name Part Name 37280 40017 Intake Valve Seal Cylinder (Incl. 2, 20 & 150) 151A 26727 Dowel Pin *36783 Valve Cover Gasket 33734 Breather Element 36784 Valve Cover 36557 30200 Breather Ass'y. (Incl. 6 & 12A) Screw, 10-24 x 9/16"...

  • Page 10

    CRAFTSMAN 4-CYCLE ENGINE MODEL:143.004010 Ref, Ref. Part Part Name Part Name 37269 4.0 H.E Craftsman Decal 36085 Spark Arrestor Kit (Incl. 417) 370A 36261 Lubrication Decal (Optional) 370B 35167 Control Decal 650821 Screw, 10-32 x 1/2" (Optional) 370C 37318 Primer Decal...

  • Page 11

    REWIND STARTER NO. 590737 Ref. Part Part Name 590737 Rewind Starter 590740 Retainer 590616 Starter Dog 590617 DogSpring 590618A Pultey & Rewind Spring Ass'y 590687A Starter Housing Ass'y (40 degree irommet) 590535 Starter Rope (Length 98" x 9/64" dia.) 590701 Starter Handle 590760 Spring Clip...

  • Page 12

    The Model Number can be found on a decal on the blower SEARS housing (See Figure 1). Always mention the Model Number when requesting service or repair parts for your Craftsman Engine. All parts listed herein may be ordered from any SEARS, ROEBUCK AND CO.

Comments to this Manuals

Symbols: 0
Latest comments: