Download Print this page

Craftsman 107289850 PGT9500 Operator's Manual page 37

30/54" 2wd
Hide thumbs Also See for 107289850 PGT9500:

Advertisement

Emissions Control System WarrantyStatement
California, United StalesandCanadaEmissions ControlDefectsWarranty
Statement
The CaliforniaAir ResourceBoard(CARB), U.S.EPAadn B&S are pleasedto explain the
Emissions Control SystemWarranty on your small off-road engine (SORE).In Califor-
nai, new small off-road enginesmodel year 2006 and latermust be designed,built and
equippedto meet the State's strigent anti-smog standards.Elsewherein the United States,
new non-road, spark-ignition enginescertified for model year 1997and latermust meet
similar standards setforth bythe U.S.EPA.B&S must warrant the emissions control sys-
tem on your engine for the periods of time listedbelow, provided there has been no abuse,
neglect or improper maintenanceof your small off-road engine.
Your emissions control system includes parts such as the carburetor,air cleaner,ignition
system, fuel line, muffler and catalytic converter.Also included may be connectors and
other emissions relatedassemblies.
Where a warrantablecondition exists, B&S will repair your small off-road engine at no
cost to you including diagnosis,parts and labor.
Bfiggs & Stratton
Emissions Control Defects Warranty Coverage
Small off-road engines are warranted relative to emissions control parts defects for a
period of two years, subject to provisions set forth below. If any covered part on your
engine is defective, the part will be repaired or replacedby B&S.
Owner's Warranty
Responsibility
As the small off-road engine owner,you are responsiblefor the performance of the required
maintenancelisted in your Operatingand MaintenanceInstructions. B&S recommends
that you retainall your receiptscovering maintenanceon your small off-road engine, but
B&S cannot deny warranty solely for the lack of receiptsor for your failure to ensurethe
performance of all scheduledmaintenance.
As the small off-road engine owner,you should however be awarethat B&S may deny you
warranty coverage if your small off-road engine or a part has failed due to abuse,neglect,
improper maintenanceor unapproved modifications.
Youare responsiblefor presentingyour small off-road engine to an AuthorizedB&S Service
Dealeras soon as a problem exists. The undisputed warranty repairsshould be completed
in a reasonableamount of time, not to exceed30 days.
If you have any questions regardingyour warranty rights and responsibilities,you should
contact a B&S ServiceRepresentativeat (414) 259-5262.
The emissions warranty is a defectswarranty. Defectsare judged on normal engine perfor-
mance. The warranty is not relatedto an in-use emissions test.
The following are specific provisions relative to your Emissions Control Defects Warranty Coverage. It is in addition to the B&S engine warranty for non-regulated engines found
in the Operating and Maintenance Instructions.
1. Warranted Parts
Coverageunder this warranty extends only to the parts listed below (the emissions
control systems parts) to the extent these parts were present on the engine
purchased.
a.
Fuel Metering System
. Cold start enrichment system (soft choke)
Carburetor and internal parts
, Fuel pump
Fuel line, fuel line fittings, clamps
Fuel tank, cap and tether
Carbon canister
b.
Air Induction System
, Air cleaner
Intake manifold
Purge and vent line
c.
Ignition System
. Spark plug(s)
Magneto ignition system
d.
Catalyst System
Catalytic converter
Exhaust manifold
Air injection system or pulse valve
e.
Miscellaneous Items Usedin Above Systems
Vacuum, temperature, position, time sensitive valves and switches
Connectors and assemblies
2. Length of Coverage
3. No Charge
Repair or replacement of any Warranted Part will be performed at no charge to the
owner, including diagnostic labor which leads to the determination that a War-
ranted Part is defecttive, if the diagnostic work is performed at an Authorized B&S
Service Dealer as listed in the "Yellow Pages" under "Engines, Gasoline,"" Gasoline
Engines," "Lawn Mowers," or similar category.
4. Claims and CoverageExclusions
Warranty claims shall be filed in accordance with the provisions of the B&S Engine
Warranty Policy. Warranty coverage shall be excluded for failures of Warranted Parts
which are not original B&S parts or because of abuse, neglect or improper main-
tenance as set forth in the B&S Engine Warranty Policy. B&S is not liable to cover
failures of Warranted Parts caused by the use of add-on, non-original, or modified
parts.
5. Maintenance
Any Warranted Part which is not scheduled for replacement as required maintenance
or which is scheduled only for regular inspection to the effect of "repair or replace as
necessary" shall be warranted as to defects for the warranty period. Any Warranted
Part which is scheduled for replacement as required maintenance shall be warranted
as to defects only for the period of time up to the first scheduled replacementfor
that part. Any replacement part that is equivalent in performance and durability may
be used in the performance of any maintenance or repairs. The owner is responsible
for the performance of all required maintenance, as defined in the B&S Operating
and Maintenance Instructions.
B&S warrants to the initial owner and each subsequent purchaser that the Warranted 6. Consequential Coverage
Parts shall be free from defects in materials and workmanship which caused the
Coveragehereunder shall extend to the failure of any engine components caused by
failure of the Warranted parts for a period of two years from the date the engine is
the failure of any Warranted Part still under warranty.
delivered to a retail purchaser.
Engines that are certified to meet the California Air Resources Board (CARB) Emis-
sions Standard must display information regarding the Emissions Durability period
and the Air Index. Briggs & Stratton makes this information available to the con-
sumer on our emissions labels. The engine emissions label will indicate certification
information.
The Emissions gnrability Period describes the number of hours of actual running
time for which the engine is certified to be emissions compliant, assuming proper
maintenance in accordance wiht the Operating and Maintenance Instructions. The
following categories are used:
lVloderate:
Engine is certified to be emissions compliant for 125 hours of actual running time.
intermediate:
Engineis certifiedto beemissionscompliantfor 250hoursof actualrunningtime.
Extended:
Engine is certified to be emissions compliant for 500 hours of actual engine running time.
For example, a typical walk-behind lawn mower is used 20 to 25 hours per year. There-
fore, the Emissions Durability Period of an engine with an intermediate rating would
equate to 10 to 12 years.
Briggs & Stratton engines are certified to meet the United States Environmental Protec-
tion Agency (ESEPA) Phase2 emissions standards. For Phase 2 certified engines, the
Emissions Compliance Period referred to on the Emissions Compliance label indicates the
number of operating hours for which the engine has been shown to meet Federalemis-
sions requirements.
For engines less than 225 cc displacement.
Category C= 125 hours, Category B= 250 hours, Category A= 500 hours
For engines of 225 cc or more displacement.
Category C= 250 hours, Category B= 500 hours, Category A= 1000 hours
5

Advertisement

loading

This manual is also suitable for:

Pgt9500