Maintenance Cleaning procedures This section contains the recommended cleaning procedures for the Xerox DocuColor 2006. Cleaning the Printer covers The Printer does not require cleaning. However, if you wish to clean the outside covers, perform the following procedure. WARNING Always switch off the power and disconnect the power cord from the wall outlet in order to avoid an electrical shock when cleaning the DocuColor 2006.
Moisten a clean, soft cloth with water and wipe the glass. Wipe dry with a clean, dry, soft cloth. 301265a Moisten another clean, soft cloth with water and wipe the white area under the Document Glass Cover. Wipe dry with a clean, dry, soft cloth. 301146a 25-2 Xerox DocuColor 2006...
Page 3
When the visible area is clean, grasp the top and bottom edges of the feed belt and carefully pull it in the right-hand direction. 0301258A - W O L Clean the new area. Repeat step 3 until the entire belt is clean. 25-3 Xerox DocuColor 2006...
Page 4
25. Maintenance Cleaning procedures Close the Document Feeder Cover. Open the jam access cover. 301270a Clean the feed rollers as shown. 301259a Close the access cover. 25-4 Xerox DocuColor 2006...
Dry Ink Cartridge is displayed on the Control Panel. Open the Printer Front Cover. 301034B-WOL If the cartridge to be replace is not visible in the opening perform the following steps: Press the Anti-rotation button. 0 301027C-WOL Xerox DocuColor 2006 25-5...
Page 6
DO NOT attempt to use old cartridges, as they could cause print quality problems. NEVER dispose of old dry ink cartridges in an open flame. Dry Ink is flammable and could explode, causing burns and other injuries. 25-6 Xerox DocuColor 2006...
Page 7
Ensure that the arrow on the cartridge can be seen on the top, and insert the cartridge into the Printer as far as it will go. 301041c CAUTION If the cartridge is not all the way into the Printer, the knob cannot be turned to the next position. Xerox DocuColor 2006 25-7...
Page 8
If the knob can be rotated to the next cartridge, you have successfully installed the new cartridge. If required, repeat the procedure for any other Dry Ink Cartridges that need replacing. 10. When all the Dry Ink Cartridge replacements have been completed, close the Printer Front Cover. 301077b 25-8 Xerox DocuColor 2006...
Copy Print Cartridge. Open the Front Cover of the Printer. 301034B-WOL Rotate the yellow lever A in the direction of the arrow, until the dot is aligned with the Unlocked symbol. 301044 Xerox DocuColor 2006 25-9...
Page 10
Cartridge and pull it slowly toward you. DO NOT remove it from the Printer at this time. 0301120A- W O L Grasping the handle, remove the cartridge from the Printer. Ensure that the cartridge remains level. 0301121A- W O L 25-10 Xerox DocuColor 2006...
Page 11
DO NOT touch the blue surface of the drum. If the drum is scratched, or contaminated with oil from your hand, the output can be degraded. Hold the cartridge by the handle. While keeping the cartridge level, remove the protective foam wrap. 301036c Xerox DocuColor 2006 25-11...
Page 12
11. Rotate lever B in the direction of the arrow until the dot is aligned with the Locked symbol. 301038b If lever B will not move to the Locked position, ensure that the cartridge is all the way into the machine. 25-12 Xerox DocuColor 2006...
Page 13
25. Maintenance 12. Rotate lever A in the direction of the arrow until the dot is aligned with the Locked symbol. 301039b 13. Close the Printer Front Cover and switch on the DocuColor 2006 power. 301077b Xerox DocuColor 2006 25-13...
0301122A- W O L Open the Printer Front Cover. 301034B-WOL Grasp the Waste Container handle, and pinch and hold the lever as shown below. Keeping the container level, pull it out of the Printer. 0301123A- W O L Xerox DocuColor 2006 25-15...
Page 16
DO NOT dispose of used Waste Containers in an open flame. Used Dry Ink could explode and cause burns. Push the new Waste Container into the Printer until it clicks into place. Close the Front Cover. 301077b 25-16 Xerox DocuColor 2006...
If moving Dry Ink from a cold area to a warm area, allow at least one hour for the cartridge temperature to equalize. If condensation occurs, wait for 12 hours before installing the cartridge in the Printer. Xerox DocuColor 2006 25-17...
Do not allow direct sunlight to strike the drum surface. • Do not attempt to reuse the Dry Ink collected in the waste container. • Always keep the Copy/Print Cartridge level. • Do not shake or tilt the cartridge. 25-18 Xerox DocuColor 2006...