Download  Print this page

Radiator Fan System; System Circuit Inspection - KAWASAKI ZX400-H2 Quick Reference Manual

Quick reference guide (part 3).
Hide thumbs

Advertisement

A.
Tum Signal Relay
.Check the cond
ition
or the relay for the
following
troubles.
(1) Neither right nor left turn
signals
come on at all:
.Check that battery voltage is normal.
• Unplug the relay leads and use an ohmmeter to check
that there is
continuity
(close to zero ohms) between
the relay terminals.
* If there is no ohmmeter
reading,
or if there is several
ohms
resistance.
replace the relay with a new
one.
• Turn the meter to the 25 V DC
range,
connect the (+)
meter lead to the brown lead that was
disconnected
from the relay, and connect the (-) meter lead to the
orange
lead.
.With the ignition switch
on,
first switch the turn signal
switch to the R and then to the L
position.
The meter
should register battery voltage at
either position
.
*If it does not, the fuse, ign
ition
switch, or
wiring
is at
fault.
(2) Both right or both left turn signals come on and stay
on or flash too
slowly:
.Check that battery voltage is normal.
.Check that all wiring connections are
good.
• Check that the turn signal bulbs and indicator bulbs are
of the correct wattage.
*If all of the above check
good,
replace the
relay.
(3) A single light on one side comes on and stays on:
* Either the light that does not come one is burned out of
the incorrect wattage
,
or the wiring is broken or
improperly connected.
(4) Neither
light
on one side
comes:
*Unless both lights for that side are burned out, the
trouble is w
ith
the turn signal switch.
(5)
Flashing
rate is too fast:
*If this occurs on both the
right
and left
sides,
check that
the battery is not being
overcharged.
*If the magneto and the battery voltage are normal.
replace the turn signal
relay.
*If this occu
rs
on only one side, one or both of the turn
signal bulbs are of too high a wattage
.
ELECTRICAL SYSTEM 15-27
Radiator Fan System
Fan System Circuit Inspection
• Remove the left lower
fairing
and disconnect the leads
from the radiator fan sw
itch.
A. Fan Switch Terminals
• Using an auxiliary w
ire,
connect the radiator fan switch
leads.
* If the fan rotates. inspect the fan
switch.
*It the fan does not
rotate,
inspect the
following.
Fan Fuse (Junction Box)
Headlight Circuit
Leads and Connectors
Main Fuse
Fan

Advertisement

Table of Contents

Comments to this Manuals

Symbols: 0
Latest comments: