Download  Print this page

KAWASAKI ZX400-H2 Quick Reference Manual Page 35

Quick reference guide (part 3).
Hide thumbs

Advertisement

15-14 ELECTRICAL SYSTEM
Connect the hand tester
(special
tool:
57001
-983)
as shown in table.
Note the
readings
(total 3 measurement)
Stator Coil Resistance
Meter
Connections
Reading
Range
Meter (+) to
Meter (-) to
One yellow
Another
0.2 -
x 1
o
lead
yellow lead
0.90
(Connector 1)
(Connector 1)
*If there is more resistance than shown in the
Table,
or
no meter reading (infinity) for any two
leads,
the stator
has an open lead and must be
replace.
Much less than
this resistance means the stator is shorted
,
and must be
replaced.
• Using the highest resistance range of the hand tester
measure the resistance between each of the yellow
leads and chassis ground.
*
Any meter
reading
less than infinity (00) indicates a
short,
necessitating
stator replacement.
*
If the stator co
ils
have normal
resistance,
but the voltage
check showed the alternator to be
defective;
then the
rotor magnetism have probably weakened, and the rotor
must be
replaced.
Rectifier Inspection
• Check the
rectifier
resistance as follows.
.Remove the regulator/rectifier and disconnect the
connector 2 (see Charging System Wir
ing
Diagram).
.Connect an ohmmeter to the
regulator/rectifier
as
shown in the Table, and check the
resistance
in both
directions of each diode following the
table.
Rectifier Circuit Inspection
Connections
Meter
No.
Meter
(+)
to Meter (-) to
Reading
Range
1
Y,
2
Y2
W
00
3
Y3
4
Y,
5
Y2
BK/Y
x 10
n
6
Y3
1/2 scale
or
7
Y,
x 100
o
i " -
8
W
Y2
i " -
9
Y3
10
Y,
t - - -
11
BK/Y
Y2
00
t - - -
12
Y3
@
...J
CXl
~
a::
+
>-
>-
_ - - - - - - - - - - - -.....
Conn ecto
;;.r- - - - -
BR
-----------=--1
.11-_ _
W
-------1----t...
BK
/ Y - - - ,
>-
Charging System Wiring Diagram
1.
Altern
ator
2.
Connector 1
3. Regulator/
Rectifier
4.
Connector
2
5. Diode
(
Rectifier)
6.
Contro
l Circuit (IC)
7.
Connector 5
8.
M
ain
Fuse 30A
9.
Connector 3
10.
Connector 4
11.
Ignition Sw itch
12.
Headlight 10A Fuse (J unction
Box)
13.
Taillight
10A
Fuse
(J uncti on
Box)
14.
Battery
15. Load

Advertisement

Table of Contents

Comments to this Manuals

Symbols: 0
Latest comments: