Download Print this page

BMW R1150RT - MAINTENANCE INTEGRAL ABS Maintenance Manual: Instructions For Filling Rear Wheel Circuit Reservoir

Hide thumbs

Advertisement

Instructions for filling rear wheel
circuit reservoir
e
Attention:
Integral brakes, the front brake must be ready for
use.
34 1 536
Top up fluid in rear wheel-circuit reservoir to
"MAX" mark if necessary.
Fully tighten resetting tool, BMW No. 34 1 531,
and adapter, BMW No. 34 1 536.
e
Attention:
The piston in the base of the wheel-circuit reservoir
must always be covered by the fluid, as otherwise air
can be drawn into the brake system.
Bleed the system again if this happens.
Switch on the ignition.
L
Note:
After switching on the ignition, always wait for the
BMW Integral ABS to complete its self-diagnosis.
Do not operate the brake lever until self-diagnosis
has completed.
Operate the footbrake lever until the pistons of
the rear brake caliper are in contact with
resetting tool, BMW No. 34 1 531, and
adapter, BMW No. 34 1 536.
00.46
MAX
MIN
Top up the fluid in the wheel-circuit reservoir until
one of the three protrusions in the filler neck just
34 1 531
touches the surface of the fluid (arrow).
Remove resetting tool, BMW No. 34 1 531, and
adapter, BMW No. 34 1 536.
R28000170
d
Warning:
Make sure that the wheel-circuit reservoir does not
overflow when the brake pads/brake calipers are in-
stalled.
Install rear brake pads and brake caliper.
Disconnect the container from the wheel-circuit
reservoir.
Hand-tighten cap of rear wheel-circuit reservoir.
Check operation of the brake system with the ig-
nition switched on.
e
Attention:
After all the work on the brake system has been
completed, run a bleed test using the
BMW MoDiTeC.
Perform bleed test with BMW MoDiTeC.
(
00.29)
a
Install fuel tank.
Brake fluid ...................................................DOT 4
X
Tightening torque:
Bleed screw in rear brake caliper ................... 5 Nm
Brake caliper to rear wheel drive .................. 40 Nm
R28340090

Advertisement

Chapters

Comments to this Manuals

Symbols: 0
Latest comments:
  • GHGHGH Feb 04, 2015 09:08:
    MUY UTIL MUY BIEN, MUY UTIL MUY BIEN, MUY UTIL MUY BIEN