Fuel System; Fuel System Warning; Fuel Tank Vent Line - Polaris RZR 900 2015 Service Manual

FUEL SYSTEM

FUEL SYSTEM WARNING

WARNING
Gasoline is extremely flammable and explosive under
certain conditions.
Always stop the engine and refuel outdoors or in a well
ventilated area.
Do not smoke or allow open flames or sparks in or near
the area where refueling is performed or where
gasoline is stored.
Do not overfill the tank. Do not fill the tank neck.
If you get gasoline in your eyes or if you swallow
gasoline, seek medical attention immediately.
If you spill gasoline on your skin or clothing,
immediately wash it off with soap and water and
change clothing.
Never start the engine or let it run in an enclosed area.
Engine exhaust fumes are poisonous and can result in
loss of consciousness or death in a short time.
Never drain the fuel when the engine is hot. Severe
burns may result.

FUEL TANK VENT LINE

NOTE
If the vent line fitting is removed from the fuel tank, it
must be replaced. The fitting will not hold properly once
it is removed.
Symptoms of a restricted fuel tank vent include the
following: collapsing fuel tank, engine miss or hesitation,
loss of engine performance
temperatures.
1. Remove the seats and the engine service panel.
2. Check the fuel tank vent line
deterioration or damage. Replace vent line if
necessary.
9926814 R08 -
Manual
© Copyright Polaris Industries Inc.
3. Be sure the vent line is routed properly and secured
or high exhaust
q
for signs of wear,
2015-2016 RZR 900
with cable tie(s).
NOTE
Make sure vent line is not kinked or pinched.
2016 RZR S 1000 Service
MAINTENANCE
2
2.21