Table of Contents
Advertisement
Quick Links
Attention:
Carefully read through the instal-
lation and operating instructions
and safety information before
installing and putting the unit into
service.
These instructions must always
be issued to the owner/user.
Installation and operating
instructions
JUDO BIOSTAT 25 TGA
Water treatment device
Valid for: Canada
Language: English
Fig.: BST 25 TGA
For lime protection according to DVGW-W510
Advertisement
Table of Contents
Related Manuals for Judo BIOSTAT 25 TGA
Summary of Contents for Judo BIOSTAT 25 TGA
- Page 1 Installation and operating instructions JUDO BIOSTAT 25 TGA Water treatment device Valid for: Canada Language: English Attention: Carefully read through the instal- lation and operating instructions and safety information before installing and putting the unit into service. These instructions must always be issued to the owner/user.
- Page 2 Trademarks used in this document are protected and registered trademarks of the respective holder. © JUDO Wasseraufbereitung GmbH D-71364 Winnenden All rights reserved. Reprints – even of extracts – are only permitted with special written approval. JUDO BIOSTAT 25 TGA...
- Page 3 This device complies with Part 15 of the FCC Rules. Operation is subject to the following two conditions: (1) this device may not cause harmful interference, and (2) this device must accept interference received, including interference that may cause undesired operation. JUDO BIOSTAT 25 TGA...
-
Page 4: Table Of Contents
1.2 Safety information and dangers 10.5 Scope of supply......24 due to non-compliance ....6 1.3 Units used........6 11. Spare parts BIOSTAT 25 TGA ..25 2. Intended use ........7 12. Customer service ......28 2.1 Water pressure ......7 2.2 Notes on special dangers .... -
Page 5: About This Operating Instructions
Apart from the instruction manual and the laws governing health & safety applicable in the country and place of use, the recognised technical regulations for safe and proper work must also be observed. Fig. 1: Built-in rotary flange JUDO BIOSTAT 25 TGA... -
Page 6: Safety Information And Dangers Due To Non-Compliance
Units (SI = System International), the follo- wing units are used: Unit Conversion °F °F = 9/5 °C + 32 1 bar = 15 psi /h = 4.4 gpm = 264 gal ¾" DN 20 1" DN 25 1½" DN 40 JUDO BIOSTAT 25 TGA... -
Page 7: Intended Use
The water treatment device is only to be used in a technically perfect condition, for their intended use, safely and aware of the dangers and with full observance of the instruction manual! JUDO BIOSTAT 25 TGA... -
Page 8: Notes On Special Dangers
Electrical devices / equip- reducer. ment located near the water treatment device must therefore be splash proof and comply with the legal regulations for wet rooms (IP44). JUDO BIOSTAT 25 TGA... -
Page 9: Product Information
DVGW mark (see fig. 3). properly all the maintenance and servicing work. JUDO BIOSTAT 25 TGA... -
Page 10: Requirements For The Place Of Installation
In this case, people close to the water treat- ment device are exposed to a health risk Always install the water treatment device in due to the large quantities of water. a vertical position (± 5°)! Unless, impairments of its function can occur. JUDO BIOSTAT 25 TGA... -
Page 11: Discharging The Flushing Water
The loose end of the hose has to be firmly strained! fixed with the included adhesive tape at the pipe or a similar object. JUDO BIOSTAT 25 TGA... - Page 12 Ensure that the wastewater con- nection functions before plugging the power supply unit into the socket. Flushing water discharge options > 1 inch (20 mm) > 6 inch 150 mm Fig. 6: Flushing water discharge options JUDO BIOSTAT 25 TGA...
-
Page 13: Operation
– The power supply must be freely acces- sible. Electrical circuit 1 5 m³ 2 10 m³ 3 20 m³ 4 40 m³ 5 Ox 1 6 Ox 2 LEDs DIP switch manual pushbutton Fig. 7: Electrical circuit JUDO BIOSTAT 25 TGA... -
Page 14: Setting The Cleaning Interval
In case of incorrect settings the circuit responds with an acoustic signal tone (see chapter “Fault”). – Remount the panelling of the water treat- ment device (see chapter “Mounting of the panelling”). Plug the power supply into the socket! JUDO BIOSTAT 25 TGA... - Page 15 Although this formation of crystals does reduce the hardness of the water, the reduction is so small that they remain undetectable by means of simple measuring instruments. JUDO BIOSTAT 25 TGA...
-
Page 16: Control Lamps, Manual Pushbuttons
LED 5 Fault hand Manual cleaning / flushing Red flashing light: the water treatment device is not ready for use (see chapter “Fault”). Fig. 9: Control lamps, manual pushbuttons Hand manual pushbutton Triggers a cleaning / flushing cycle. JUDO BIOSTAT 25 TGA... -
Page 17: Cleaning / Flushing
(2). Failure to observe the maintenance demand If the maintenance demand (LED 3 red) is ignored, water treatment will no longer take place after 10 days. The LED 3 flashes red then. JUDO BIOSTAT 25 TGA... -
Page 18: Warning Message "Battery Low
– Ensure that the cable is not trapped! – Refit the type plate in the blanks, of the panelling, situated above and below. – Push the panelling completely together. Plug the power supply into the socket! JUDO BIOSTAT 25 TGA... -
Page 19: Replacing The Batteries
Plug the power supply into the socket! – Return run-down batteries to a distri- butor or to a properly-authorised local disposal return point. Only use 9 V alkaline type block batteries (see battery description). JUDO BIOSTAT 25 TGA... -
Page 20: Stoppages
In addition, people near the water treat- ment device can be injured by breaking off water treatment device parts. – When restarting the water treatment device, follow the instructions for a new water treatment device. JUDO BIOSTAT 25 TGA... -
Page 21: Fault
Remove the spherical valve actuator with a sudden pull. Close the spherical valve with the included hand lever. LED 4 flashes red. Battery is Replace by a new battery (type alkaline). Return empty. run-down batteries to the collection points. JUDO BIOSTAT 25 TGA... -
Page 22: Maintenance
These substances can chemically attack the wearing materials, etc. should be carried out plastic parts, which can lead to brittleness or by the specialist trade or the factory’s even fractures. customer service department. Such cleaners must therefore not be used. JUDO BIOSTAT 25 TGA... -
Page 23: Data Sheet
– Maximum ambient temperature and water temperature: 86 °F (30 °C). 10.1 Type – The water to be treated must possess JUDO BIOSTAT 25 TGA quality of drinking water! Water treatment device – Threaded connection according to Abbreviated name: BST 25 TGA DIN EN 10226-1. -
Page 24: Mounting Dimensions
– wall support (2200500) to prevent the problems in cold water: water treatment device from twisting. A metering pump JUDO JULIA has to be No support of weight! mounted ion the water pipe after the water – installation and operating instructions treatment device, in order to enrich propor- –... -
Page 25: Spare Parts Biostat 25 Tga
Spare parts BIOSTAT 25 TGA BIOSTAT 25 TGA Spare parts JUDO BIOSTAT 25 TGA... - Page 26 Spare parts BIOSTAT 25 TGA List of spare parts BIOSTAT 25 TGA Description Item (Recommended average replacement interval Piece Order no. AU /piece for wearing part [*]) Cheese head screw M8x65 1650365 Disc A8,4 1607125 EJOT screw 1650201 Sliding contact...
- Page 27 Spare parts BIOSTAT 25 TGA Description Item (Recommended average replacement interval Piece Order no. AU /piece for wearing part [*]) Clamping fixture large 1120625 Clamping fixture small 1120624 Wastewater hose 2633342 Hose clamp 1633344 201 Engine cowling 2210390 202 Brush drive complete...
-
Page 28: Customer Service
All illustrations, dimensions and information for the different models are those valid on the date of prin- ting. All rights are reserved for modifications as a result of technical progress or further developments. Claims with regard to models or products are excluded. 1702207 • 2010/04 JUDO BIOSTAT 25 TGA...
Need help?
Do you have a question about the BIOSTAT 25 TGA and is the answer not in the manual?
Questions and answers