Subscribe to Our Youtube Channel
Related Manuals for Arctic Air AR23E
Summary of Contents for Arctic Air AR23E
- Page 1 INSTALLATION, OPERATION & MAINTENANCE MANUAL Reach-In Refrigerators and Freezers IMPORTANT Please read this manual completely before attempting to install or operate this equipment.
-
Page 2: Table Of Contents
......Model: AF23 ..................................17 Model: AF49 ..................................18 ARCTIC AIR WARRANTY ................................19... -
Page 3: Specifications
REACH-IN REFRIGERATORS AND FREEZERS SPECIFICATIONS SOLID DOOR REFRIGERATORS STORAGE SHELF CHARGE SHIP FICHE CAPACITY WEIGHT NEMA V/Hz/Ph CAPACITY MODEL# AMPS Cu. ft. Cu. ft. AR23E 115/60/1 14.0 3200 12.0 5-15P AR49E 115/60/1 28.1 5800 18.7 5-15P SOLID DOOR FREEZERS STORAGE SHELF SHIP CHARGE... - Page 4 Installation, Operation & Maintenance Manual REGISTRATION The.installation.date.and.appliance.model.must.be.documented.by.the.end.purchaser... Also,.refer.to.the.Warranty.section.for.additional.details.on.registering.the.appliance. Dealer.Information: Installer.Information: Installation.Date:...
-
Page 5: Safety Instructions
REACH-IN REFRIGERATORS AND FREEZERS SAFETY INSTRUCTIONS General Safety Arctic Air accepts no responsibility for any situation resulting from work carried out in an WARNING unprofessional manner, or from the incorrect interpretation or application of regulations. General Installation Incorrect installation or any modifications made to the appliance may damage property or WARNING result in injury or death. -
Page 6: Introduction
Installation, Operation & Maintenance Manual INTRODUCTION This. . manual. covers. the. Reach-In. Refrigerators. and. Confirm that all flooring is structurally strong enough • Freezers.. Please. read. this. manual. completely. before. to.support.the.weight.of.a.fully.loaded.unit;.a.fully. attempting.to.install.or.operate.this.equipment. loaded. unit. can. weigh. as. much. as. 1500. pounds.. . Consult with a structural engineer for confirmation if Site Preparation there is any reason to doubt the floor strength. -
Page 7: Installation
REACH-IN REFRIGERATORS AND FREEZERS INSTALLATION Location Electrical connection All.units.are.intended.for.indoor.use.only..A.fully.loaded. Refer. to. the. amperage. data. provided. in. the. SPECIFI- unit.can.weigh.as.much.as.1500.pounds...Choose.a.loca- CATIONS,.the.serial.tag,.the.local.electrical.code.and/or. tion with a level floor strong enough to support the total the.National.Electrical.Code..Have.a.licensed.electrician. weight of a fully loaded unit. Reinforce the floor if neces- confirm that the facility wiring is adequate for the unit and sary.. -
Page 8: Operation
Installation, Operation & Maintenance Manual OPERATION Refrigeration Cycles Callout Control / Function Indicator Refrigerators Indicates.the.fans.are.running. The.evaporator.fans.run.continuously.during.the.refrig- Press.to.start.the.manual.defrost. Defrost cycle. eration. cycles. to. maintain. the. factory. set. internal. tem- perature.range.at.34°F.to.38°F...The.door.switch.turns. Indicates.the.compressor.is. Compressor running. on.the.lights.when.the.door.is.opened. To.display.the.last.temperature. 1.. Every. 6. hours,. the. unit. turns. off. and. the. controller. alarm.. -
Page 9: Functions
REACH-IN REFRIGERATORS AND FREEZERS Functions Alarm Codes Display the Set Point: CODE CAUSE OUTPUTS Room.probe. Compressor.output.according. 1.. Press. and. release. the. SET. button,. the. set. point. failure to.par.Con.and.COF value.is.displayed. Evaporator. Defrost.end.is.timed probe.failure .. Press. and. release. the. SET. button. (again). or. wait. five seconds to return to the probe value display. -
Page 10: Maintenance
Installation, Operation & Maintenance Manual MAINTENANCE Stainless Steel Care and Cleaning DANGER Stainless. steel. contains. 70-80%. iron. which. will. rust.. It. TURN OFF THE POWER SWITCH AND also. contains. 1-30%. chromium. which. forms. an. invis- DISCONNECT THE UNIT FROM THE POWER ible passive film over the steel’s.surface.that.acts.as.a. -
Page 11: Gasket Maintenance
REACH-IN REFRIGERATORS AND FREEZERS Gasket Maintenance Open the Top Shroud Gaskets. require. regular. cleaning. to. prevent. mold. and. Loosen.and.remove.the.screw.from.the.two.holes.in.front. mildew. buildup. and. to. maintain. the. gasket. elasticity.. . of.the.top.shroud,.swing.the.top.shroud.up.180°.and.posi- Clean.gaskets.with.warm.soapy.water..Avoid.full.strength. tion.it.on.the.top.of.the.cabinet. cleaning.products.on.gaskets,.this.can.cause.the.gaskets. to.become.brittle.and.prevent.proper.sealing..Never.use. sharp.tools.or.knives,.which.could.tear.the.gasket.and/or. rip.the.bellows,.to.scrape.or.clean.the.gasket. Gaskets.are.easy.to.replace.and.do.not.require.the.use. of.tools..To.remove.and.replace.the.Dart.style.gasket,.pull. the. gasket. out. of. the. groove. in. the. door. and. press. the. new.gasket.back.into.place.. -
Page 12: Remove The Bottom Shroud (Applies Only To Bottom Mounted Condenser Units)
Installation, Operation & Maintenance Manual 5.. Maintain. the. door/hinge. assembly. at. about. 100°,. Remove the Bottom Shroud (applies only and slide it up to the top hinge pin. Confirm proper to bottom mounted condenser units) alignment,.and.then.fasten.the.bottom.hinge. Loosen.and.remove.the.bottom.shroud.two.top.screws.. 6.. The.door.must.swing.closed.by.itself.with.no.restric- Slide.the.bottom.shroud.up.and.out. tion, confirm that the door swings freely. -
Page 13: Wiring Diagrams
REACH-IN REFRIGERATORS AND FREEZERS WIRING DIAGRAMS Model: AR23E Model: AR49E... -
Page 14: Model: Af23
Installation, Operation & Maintenance Manual Model: AF23 Models: AF49... - Page 15 REACH-IN REFRIGERATORS AND FREEZERS Model: AR23E...
- Page 16 Installation, Operation & Maintenance Manual Model: AR49E...
-
Page 17: Model: Af23
REACH-IN REFRIGERATORS AND FREEZERS Model: AF23... -
Page 18: Model: Af49
Installation, Operation & Maintenance Manual Model: AF49... -
Page 19: Arctic Air Warranty
Additional three-year compressor warranty* In addition to the two (2) year warranty stated above, Arctic Air warrants its compressor units to be free from defects in both material and workmanship under normal and proper use and maintenance service for a period of three (3) additional years from the date of original installation but not to exceed five (5) years and three (3) months after shipment from Arctic Air. - Page 20 Broich Enterprises, Inc. / Arctic Air 6440 City West Parkway Eden Prairie, MN 55344 Phone: 952-941-2270 Fax: 952-941-3066 Website: www.arcticairco.com...
Need help?
Do you have a question about the AR23E and is the answer not in the manual?
Questions and answers